1622003 MR2 from Aug. ’03 Prod. (OM17511U)
Before making these checks, make sure
you have followed the correct starting
procedure given in “How to start the
engine” on page 154 in Section 3 and that
you have sufficient fuel. Also check
whether the other keys will start the
engine. If they work, your key may be
broken. Have the key checked at your
Toyota dealer. If none of your keys work,
there may be a malfunction in the immobi-
lizer system. Call your Toyota dealer. (See
“Keys” on page 8 in Section 1 2.)
If the engine is not turning over or is
turning over too slowly—1. Check that the battery terminals are tight and clean.
2. If the battery terminals are O.K., switch on the interior light.
3. If the light is out, dim or goes out when the starter is cranked, the battery
is discharged. You may try jump start-
ing. See “(c) Jump starting” on page
163 for further instructions.
If the light is O.K., but the engine still will
not start, it needs adjustment or repair.
Call a Toyota dealer or qualified repair
shop.NOTICE
Sequential manual transmission
only: Your vehicle cannot be pull
or push started.
Do not pull or push start the ve-
hicle. It may damage the vehicle or
cause a collision when the engine
starts. Also the three way catalytic
converter may overheat and become
a fire hazard.
If the engine turns over at its normal
speed but will not start—
1. The engine may be flooded because of repeated cranking. See “(b) Starting a
flooded engine” on page 162 for further
instructions.
2. If the engine still will not start, it needs adjustment or repair. Call a Toyota
dealer or qualified repair shop.
(b) Starting a flooded engine
If the engine will not start, your engine
may be flooded because of repeated
cranking.
Sequential manual transmission: If this
happens, turn the key to “START” with the
accelerator pedal and brake pedal fully
depressed. Keep the key, accelerator ped-
al and brake pedal in these positions for
15 seconds and release them. Then re-
lease the accelerator pedal, and try crank-
ing the engine with the brake pedal de-
pressed.
Manual transmission: If this happens,
turn the key to “START” with the accelera-
tor pedal fully depressed. Keep the key
and accelerator pedal in these positions
for 15 seconds and release them. Then
try starting the engine with your foot off
the accelerator pedal.
If the engine does not start after 15 sec-
onds of cranking, release the key, wait a
few minutes and try again.
If the engine still will not start, it needs
adjustment or repair. Call a Toyota dealer
or qualified repair shop for assistance.
03 07.07
If your vehicle will not start—
(a) Simple checks
1632003 MR2 from Aug. ’03 Prod. (OM17511U)
NOTICE
Do not crank for more than 30 sec-
onds at a time. This may overheat the
starter and wiring systems.
(c) Jump starting
To avoid serious personal injury and
damage to your vehicle which might re-
sult from battery explosion, acid burns,
electrical burns, or damaged electronic
components, these instructions must be
followed precisely.
If you are unsure about how to follow this
procedure, we strongly recommend that
you seek the help of a competent me-
chanic or towing service.
CAUTION
Batteries contain sulfuric acid
which is poisonous and corrosive.
Wear protective safety glasses when
jump starting, and avoid spilling
acid on your skin, clothing, or ve-
hicle.
If you should accidentally get acid
on yourself or in your eyes, remove
any contaminated clothing and flush
the affected area with water imme-
diately. Then get immediate medical
attention. If possible, continue to
apply water with a sponge or cloth
while en route to the medical office.
The gas normally produced by a
battery will explode if a flame or
spark is brought near. Use only
standardized jumper cables and do
not smoke or light a match while
jump starting.
Warning: Battery posts, terminals and
related accessories contain lead and
lead compounds, chemicals known to
the State of California to cause can-
cer and reproductive harm. Wash
hands after handling.
NOTICE
The battery used for boosting must
be 12 V. Do not jump start unless you
are sure that the booster battery is
correct.
03 07.07
1642003 MR2 from Aug. ’03 Prod. (OM17511U)
JUMP STARTING PROCEDURE1. If the booster battery is installed in another vehicle, make sure the vehicles
are not touching. Turn off all unneces-
sary lights and accessories.
2. If required, remove all the vent plugs from the booster and discharged batter-
ies. Lay a cloth over the open vents
on the batteries. (This helps reduce the
explosion hazard, personal injuries and
burns.)
3. If the engine in the vehicle with the booster battery is not running, start it
and let it run for a few minutes. During
jump starting, run the engine at about
2000 rpm with the accelerator pedal
lightly depressed.
SB41055
Discharged battery
Booster
battery
Positive terminal
(“+” mark)
Positive
terminal
(“+” mark)
Jumper
cable
4. Make the cable connections in the or-
der a, b, c, d.
a. Connect the clamp of the positive
(red) jumper cable to the positive (+)
terminal on the discharged battery.
b. Connect the clamp at the other end
of the positive (red) jumper cable to
the positive (+) terminal on the booster
battery.
SB41056
Jumper cable
Booster
battery Negative terminal
(“ ” mark)
Discharged
battery
c. Connect the clamp of the negative
(black) jumper cable to the negative ( )
terminal on the booster battery.
d. Connect the clamp at the other end
of the negative (black) jumper cable to
a solid, stationary, unpainted, metallic
point of the vehicle with the discharged
battery.
The recommended connecting point is
shown in the following illustration:
03 07.07
1652003 MR2 from Aug. ’03 Prod. (OM17511U)
SB41040
Connecting point
Do not connect the cable to or near
any part that moves when the engine
is cranked.
CAUTION
When making the connections, to
avoid serious injury, do not lean over
the battery or accidentally let the
jumper cables or clamps touch any-
thing except the correct battery termi-
nals or the ground.
5.Sequential manual transmission: Turn
the ignition switch to “ON” position.
Hold down the brake pedal firmly, and
place the selector lever to “N” position.
Make sure that the “N” indicator in the
instrument cluster comes on. Then
start your engine in a normal way.
Manual transmission: Start your en-
gine in the normal way.
After starting, run it at about 2000 rpm
for several minutes with the accelerator
pedal lightly depressed.
6. Carefully disconnect the cables in the exact reverse order: the negative cable
and then the positive cable.
7. Carefully dispose of the battery cover cloths—they may now contain sulfuric
acid.
8. If removed, replace all the battery vent plugs.
If the cause of your battery discharging is
not apparent (for example, lights left on),
you should have it checked at your Toyota
dealer. If your engine stalls while driving...
1. Reduce your speed gradually, keeping a straight line. Move cautiously off the
road to a safe place.
2. Turn on your emergency flashers.
3. Sequential manual transmission: Turn
the ignition key to “ACC” or “LOCK”
position. Approximately 5 seconds after,
try starting the engine again.
Manual transmission: Turn the ignition
key to “ACC” or “LOCK”, and try start-
ing the engine again.
If the engine will not start, see “If your
vehicle will not start—” on page 162 in
this Section.
CAUTION
If the engine is not running, the pow-
er assist for the brakes and steering
will not work so steering and braking
will be much harder than usual.
03 07.07
If your engine stalls while
driving
2492003 MR2 from Aug. ’03 Prod. (OM17511U)
Economical driving158
. . . . . . . . . . . . . . .
Good driving practice 96
. . . . . . . . . . . . . .
Winter driving tips 156
. . . . . . . . . . . . . . . .
During
Break in 130
. . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel
and repairs 158 . . . . . . . . . . . . . . . . . . . .
Electrical system Battery 222,223 . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 200 . . . . . . . . . . . . . . . . . . .
Fuses 224 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 69 . . . . . . . . . . . .
Emergency, In case of Blown fuse 224 . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 69 . . . . . . . . . .
Flat tire 167 . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the
engine speed 166 . . . . . . . . . . . . . . . . . .
If you cannot shift the sequential manual transmission
selector lever 181 . . . . . . . . . . . . . . . . . .
If you lose your keys 182 . . . . . . . . . . . . . .
If your engine stalls
while driving 165 . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 177 . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 162 . . . . . . . .
Jump starting 163 . . . . . . . . . . . . . . . . . . . .
Overheating 166 . . . . . . . . . . . . . . . . . . . . . Towing 177
. . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 195 . . . . . . .
Engine
Before starting the engine 154 . . . . . . . . .
Checking the coolant level 208 . . . . . . . .
Emission control device 132 . . . . . . . . . . .
Engine compartment 198 . . . . . . . . . . . . . .
Exhaust gas caution 133 . . . . . . . . . . . . . .
Hood release 16 . . . . . . . . . . . . . . . . . . . . .
Identification Number 139 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 134 . . . . . . . . . . . . . . . . . .
Oil level 206 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 166 . . . . . . . . . . . . . . . . . . . . .
Starting procedure 154 . . . . . . . . . . . . . . .
Three way catalytic converter 132 . . . . .
Engine coolant Temperature gauge 74 . . . . . . . . . . . . . . . .
Winter driving tips 156 . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 74 . . . .
Engine immobilizer system 10 . . . . . . . . . . .
Engine oil Winter driving tips 156 . . . . . . . . . . . . . . . .
Exhaust gas cautions 133 . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 134 . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 68 . . . . . . . . . . . . . . . . . . .
Flat tire After changing wheels 175 . . . . . . . . . . . . Changing tire 173
. . . . . . . . . . . . . . . . . . . .
If you have a flat tire 167 . . . . . . . . . . . . . .
Jack point 172 . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 167 . . . . . . . . . . . . . .
Jacking up 172 . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 171 . . . . . . . . . . . . .
Lowering vehicle 174 . . . . . . . . . . . . . . . . .
Wheel block 171 . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 173 . . . . . . . . . . . . . . . . . . . . . .
Floor mat 128 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level Brake 209 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 210 . . . . . . . . . . . . . . . . . . .
Washer fluid 225 . . . . . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 132 . . . . . .
Front box 123 . . . . . . . . . . . . . . . . . . . . . . . . . .
Front fog light switch 70 . . . . . . . . . . . . . . . .
Fuel Filler door o pener 18. . . . . . . . . . . . . . . . .
Fuel economy 158 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 132 . . . . . . . . .
Gauge 74 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 132 . . . . .
Tank cap 18 . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 130 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 132 . . . . . . . . . .
Fuses Fuse box 199 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 200 . . . . . . . . . . . . . . . . . . . . .
03 07.07
2502003 MR2 from Aug. ’03 Prod. (OM17511U)
G
GaugeEngine temperature 74 . . . . . . . . . . . . . . .
Fuel 74 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 193 . . . . . . . . . . . . . . .
Glove box 123 . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice Manual transmission 96 . . . . . . . . . . . . . .
H
Hazard switch 69
. . . . . . . . . . . . . . . . . . . . . .
Headlight switch 68
. . . . . . . . . . . . . . . . . . . .
High speed operation
During break in 130
. . . . . . . . . . . . . . . . . .
Hood release, Engine 16
. . . . . . . . . . . . . . . .
How to start the engine 154
. . . . . . . . . . . . .
I
Identification
Engine 139 . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 139 . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 84 . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5 . . . . . . . . . . . . . . . . . . . .
Instrument panel Cigarette lighter and ashtray 122 . . . . . . .
Clock 122 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5 . . . . . . . . . . . . . . . . . .
Odometer 75 . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 75 . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 75 . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 70 . . . . . . . . . Instrument panel overview 2
. . . . . . . . . . . .
Interior light 70 . . . . . . . . . . . . . . . . . . . . . . . .
Iridium tipped spark plugs 135 . . . . . . . . . .
J
Jack
Location 169 . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 204 . . . . . . . . . . . . . . .
Jump starting 163 . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 82
. . . . . . . . . . . . . . . .
Keys 8,182
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Back up lights 232 . . . . . . . . . . . . . . . . . . .
Front fog lights 230 . . . . . . . . . . . . . . . . . . .
Front turn signal lights 231 . . . . . . . . . . . .
Front side marker lights 231 . . . . . . . . . . .
Headlights 228 . . . . . . . . . . . . . . . . . . . . . . .
License plate lights 233 . . . . . . . . . . . . . . .
Parking lights 231 . . . . . . . . . . . . . . . . . . . .
Rear turn signal lights 232 . . . . . . . . . . . .
Rear turn signal, stop/tail, stop and back up lights 232 . . . . . . . . .
Light, Interior Interior light 70 . . . . . . . . . . . . . . . . . . . . . .
Light bulbs, replacing 226 . . . . . . . . . . . . . . .
Light reminder buzzer 77 . . . . . . . . . . . . . . .
Limited slip differential 138 . . . . . . . . . . . . . Load limits 149
. . . . . . . . . . . . . . . . . . . . . . . .
Lock Side doors 11 . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 84 . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 77 . . . . . . . . . . .
Low engine oil pressure warning light 77 . . . . . . . . . . . . . . . . . . . . . .
Luggage space 125 . . . . . . . . . . . . . . . . . . . .
M
Maintenance
Do it yourself maintenance 201 . . . . . . .
Does your vehicle need repairing? 195 . . . . . . . . . . . . . . . .
General maintenance 193 . . . . . . . . . . . . .
Maintenance requirements 192 . . . . . . . .
Parts and tools 203 . . . . . . . . . . . . . . . . . . .
Where to go for service 192 . . . . . . . . . . .
Malfunction indicator lamp 77 . . . . . . . . . . .
Manual transmission
Driving with amanual transmission 96 . . . . . . . . . . . . .
Shift pattern 96 . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 96 . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed Manual transmission 96 . . . . . . . . . . . . . .
Sequential manual transmission 85 . . . .
Mirror Anti glare inside rear view 66 . . . . . . . . .
03 07.07
2512003 MR2 from Aug. ’03 Prod. (OM17511U)
MirrorsFolding rear view 66 . . . . . . . . . . . . . . . . . .
Outside rear view 64 . . . . . . . . . . . . . . . . .
Power rear view 65 . . . . . . . . . . . . . . . . . . .
N
New vehicle break in 130
. . . . . . . . . . . . . . .
O
Odometer 75
. . . . . . . . . . . . . . . . . . . . . . . . . .
Oil Consumption 134
. . . . . . . . . . . . . . . . . . . .
Power steering 210
. . . . . . . . . . . . . . . . . . .
Viscosity and grade 206,239
. . . . . . . . . .
Oil power steering 210
. . . . . . . . . . . . . . . . . .
Open door warning light 77
. . . . . . . . . . . . . .
Operation in foreign countries 132 . . . . . . .
Overheating, Engine 166
. . . . . . . . . . . . . . . .
Overheating, Engine coolant 74
. . . . . . . . . .
Overview Engine compartment 198
. . . . . . . . . . . . . .
Instrument cluster 4
. . . . . . . . . . . . . . . . . .
Instrument panel 2
. . . . . . . . . . . . . . . . . . .
P
Parking brake
Operation 97 . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 97 . . . . . . . . . . . . . . . . . . . .
Parking brake reminder light 77 . . . . . . . . . .
Parts and tools 203 . . . . . . . . . . . . . . . . . . . . . Passenger airbag manual
on off switch 45 . . . . . . . . . . . . . . . . . . . . .
Passenger ’s seat belt reminder light 77 . . . . . . . . . . . . . . . . . . . . .
Polishing 185 . . . . . . . . . . . . . . . . . . . . . . . . . .
Power door lock switch 12 . . . . . . . . . . . . . .
Power rear view mirror control 65 . . . . . . . .
Power steering fluid level 210 . . . . . . . . . . .
Power window switches 13 . . . . . . . . . . . . . .
Power window lock switch 14 . . . . . . . . . . . .
Pretensioners (seat belt pretensioners) 35 . . . . . . . . . . .
Protecting your Toyota
from corrosion 184 . . . . . . . . . . . . . . . . . . .
R
Radiator
Coolant, Engine 208 . . . . . . . . . . . . . . . . . .
Rear view mirror, Anti glare inside 66 . . . . . . . . . . . . . . . . . .
Rear view mirror, Power controlled 65 . . . . . . . . . . . . . . . . . .
Rear view mirrors, Folding 66 . . . . . . . . . . .
Rear view mirrors, Outside 64 . . . . . . . . . . .
Rear window defogger switch 71 . . . . . . . . .
Reporting safety defects
for U.S. owners 246 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 28 . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 34 . . . . . . . . . . . . . . . . . . . Seat belts
Cleaning 188 . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 31 . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt precautions 31 . . . . . . . . . . . . . .
Seat belt pretensioners 35 . . . . . . . . . . . .
Seating capacity 149 . . . . . . . . . . . . . . . . . . .
Seats 28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sequential manual transmission Driving with a sequential manual transmission 85 . . . . . . . . . . .
Shift pattern 85 . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 88 . . . . . . . . . . . . . . . . . . . .
Service and maintenance 192 . . . . . . . . . . .
Service reminder indicators 77 . . . . . . . . . .
Side door locks 11 . . . . . . . . . . . . . . . . . . . . .
Side vents 119 . . . . . . . . . . . . . . . . . . . . . . . . .
Soft top 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spare fuse 224 . . . . . . . . . . . . . . . . . . . . . . . .
Spare tire 169 . . . . . . . . . . . . . . . . . . . . . . . . .
Spark plugs lridium tipped spark plugs 135 . . . . . . . .
Specifications 237 . . . . . . . . . . . . . . . . . . . . .
SRS driver and passenger airbags 37 . . . . . . . . . . . . . . . .
SRS warning light 77 . . . . . . . . . . . . . . . . . . .
Starting Cold weather 154 . . . . . . . . . . . . . . . . . . . .
Engine 154 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 163 . . . . . . . . . . . . . . . . . . . .
Steering Column lock 84 . . . . . . . . . . . . . . . . . . . . . .
Tilt steering wheel 64 . . . . . . . . . . . . . . . . .
Suspension and chassis 140 . . . . . . . . . . . .
03 07.07