2003 SUBARU FORESTER power steering

11 -2 1
Maintenance and service
–CONTINUED –
bles. Make sure the cables are replaced in the cor-
rect order.
Recommended spark plugs
RC10YC4 (Champion)
BKR6E-11 (NGK)
BKR5E-11 (NGK)
Drive belts
1) Power steering pump pulley
2) Air conditioner compressor pulley
3) Crank pulley
The alternator, power steering pump, and air condi-
tioner compressor depend on drive belts. Satisfactory
performance requires that belt tension be correct.
To check belt tension, place a straightedge (ruler)
across two adjacent pulleys and apply a force of 22 lb
(98 N, 10 kg) midway between the pulleys by using a
spring scale. Belt deflection should be the amount
specified. If a belt is loose, cracked, or worn, contact
2
3 A
B
1
HSB033BB

11 -2 9
Maintenance and service
–CONTINUED –
Power steering fluid Checking the fluid level
1) Reservoir tank
The power steering fluid expands greatly as its tem-
perature rises; the fluid level differs according to fluid
temperature. Therefore, the reservoir tank has two dif-
ferent checking ranges for hot and cold fluids.
Check the power steering fluid level monthly.
1. Park the vehicle on a level surface, and stop the en-
gine. 1) Specified range
2. Check the fluid level of the reservoir tank.
When the fluid is hot after the vehicle has been run:
Check that the oil level is between “HOT MIN” and
“HOT MAX” on the surface of the reservoir tank.
When the fluid is cool before the vehicle is run: Check
that the oil level is between “COLD MIN” and “COLD
MAX” on the surface of the reservoir tank.
3. If the fluid level is lower than the applicable “MIN”
line, add the recommended fluid as necessary to bring
the level between the “MIN” and “MAX” line.
If the fluid level is extreme low, it may indicate possible
leakage. Consult your SUBARU dealer for inspection.
1
HSB044BB
1 1
HSB045BB

11 - 3 0
Maintenance and service
Be careful not to burn yourself because the flu-
id may be hot.

When power steering fluid is being added,
use only clean fluid, and be careful not to allow
any dirt into the tank. And never use different
brands together.
Avoid spilling fluid when adding it in the tank.
Recommended fluid
“Dexron III” Type Automatic Transmission Fluid
Brake fluid Checking the fluid level
1) “MAX” level mark
2) “MIN” level mark
Check the fluid level monthly.
Check the fluid level on the outside of the reservoir. If
the level is below “MIN”, add the recommended brake
fluidto“MAX”.
Use only brake fluid from a sealed container.
M AXMAX
M INMIN
HSB018GB
1 2

12-4
Specifications
Capacities
Tires
Fuel tank15.9 US gal (60 liters, 13.2 Imp gal)
Engine oil4.2 US qt (4.0 liters, 3.5 Imp qt)
Transmission oilManual transmission3.7 US qt (3.5 liters, 3.1 Imp qt)
Automatic transmission9.8 US qt (9.3 liters, 8.2 Imp qt)
AT differential gear oil1.3 US qt (1.2 liter, 1.1 Imp qt)
Rear differential0.8 US qt (0.8 liter, 0.7 Imp qt)
Power steering gear fluid0.7 US qt (0.7 liter, 0.6 Imp qt)
Engine coolantManual transmission7.3 US qt (6.9 liters, 6.1 Imp qt)
Automatic transmission7.2 US qt (6.8 liters, 6.0 Imp qt)
Tire sizeP215/60R16 94H
Wheel size16 x 6 1
/2 JJ
PressureFrontLight load29 psi (200 kPa, 2.0 kg/cm 2
)
Full load29 psi (200 kPa, 2.0 kg/cm 2
)
RearLight load28 psi (190 kPa, 1.9 kg/cm 2
)
Full load36 psi (250 kPa, 2.5 kg/cm 2
)
Trailer towing41 psi (280 kPa, 2.8 kg/cm 2
)

14-4
Index
Stopping .................................................... 7-11
Exterior care ................................................... 10-2 F
Flat tires ................................................. 9-3, 9-5
Floor mat ........................................................ 6-15
Fluid level Automatic transmission ............................. 11-24
Brake ......................................................... 11-30
Clutch (MT vehicles) .................................. 11-31
Power steering ........................................... 11-29
Fog light switch ............................................... 3-21
Front differential gear oi l (AT vehicles) ........... 11-26
Front seatbelt pretensioners ........................... 1-27
Front seats ..................................................... 1-2 Fore and aft adjustment ............................. 1-3
Reclining .................................................... 1-4
Front-wheel drive warning light (AT vehicles) . 3-15
Fuel ................................................................ 7-2
Economy hints ........................................... 8-2
Filler lid and cap ........................................ 7-4
Gauge ........................................................ 3-7
Requirements ............................................ 7-2
Fuses ............................................................. 11-50
Fuses and circuits .......................................... 12-6 G
GAWR ............................................................. 8-16
Glove box ........................................................ 6-5
Gross axle weight rating .................................. 8-16
Gross vehicle weight rating ............................. 8-16
GVWR ............................................................. 8-16 H
Hazard warning flasher ................................... 3-5
Headlights ....................................................... 3-17
Headrest adjustment ....................................... 1-10
Headlight flasher ............................................. 3-18
Heater operation ............................................. 4-6
High beam indicator light ................................. 3-15
Hill holder ................................................ 7-29, 11-35
Horn ................................................................ 3-34 I
Ignition switch .................................................. 3-2
Illuminated entry .............................................. 2-8
Illumination brightness control ......................... 3-20
Indicator light ................................................... 3-9
Inside mirror .................................................... 3-29
Interior lights .................................................... 6-2

14-6
Index
P
Parking brake ......................................... 7-27, 11-37
Stroke ........................................................ 11-37
Parking light switch ......................................... 3-21
Parking your vehicle ....................................... 7-27
Periodic inspections ....................................... 8-5Power Door locking switches ................................ 2-5
Steering ..................................................... 7-20
Steering fluid level ..................................... 11-29
Windows .................................................... 2-21
R
Rear Combination lights ..................................... 11-61
Differential gear oil level ............................ 11-27
Gate ................................................... 2-24, 9-17
Seats ......................................................... 1-9
Viscous limited slip differential (LSD) ........ 7-20
Rear Window Defogger switch ......................................... 3-27
Wiper and washer switch ........................... 3-25
Remote keyless entry system ........................ 2-6
Replacing Air cleaner element .................................... 11-19
Battery (remote keyless entry) ................... 2-9
Bulbs ......................................................... 11-54 Transmitters ............................................... 2-10
Rocking the vehicle ......................................... 8-13
Roof rail and crossbar ..................................... 8-17 S
Seatbelts ......................................................... 1-12
Seatbelt Maintenance ............................................... 1-26
Pretensioners ............................................. 1-27
Safety tips ................................................... 1-12
Warning light and chime ............................. 3-9
Seats
Fabric ......................................................... 10-5
Heater ......................................................... 1-8
Seat height adjustment (driver’s side) ............. 1-5
Security system ............................................... 2-14
Selector lever (AT vehicles) ............................ 7-15
Self-leveling rear suspension .......................... 7-34
Shift lock release ............................................. 7-18
Shift position indicator ..................................... 3-15
Shopping bag hook ......................................... 6-18
Snow tires ....................................................... 8-12
Snowy and icy roads ....................................... 8-11
Spark plugs ..................................................... 11-20
Specifications .................................................. 12-2
Speedometer ................................................... 3-5
SRS airbags .................................................... 1-39