2003 PONTIAC GRAND AM trailer

Automatic Transaxle Fluid
It is not necessary to check the transaxle fluid level. A
transaxle fluid leak is the only reason for fluid loss.
If a leak occurs, take the vehicle to the dealership
service department and have it repaired as soon as
possible. You may also have your fluid level checked by
your dealer or service center when you have your oil
changed.
Change both the fluid and filter every
50,000 miles
(83 000 km) if the vehicle is mainly driven under one or
more of these conditions:
In heavy city traffic where the outside temperature
In hilly or mountainous terrain.
When doing frequent trailer towing.
0 Uses such as found in taxi, police or delivery
regularly reaches
90°F (32°C) or
higher.
service. If
you do not use your vehicle under any of these
conditions, the fluid and filter do not require changing.
Notice: We recommend you use only fluid labeled
DEXRON@-Ill, because fluid with that label
is
made especially for your automatic transaxle.
Damage caused by fluid other than DEXRON@-Ill is
not covered
by your new vehicle warranty.
Manual Transaxle Fluid
It is not necessary to check the transaxle fluid level. A
transaxle fluid leak is the only reason for fluid loss.
If a leak occurs, take the vehicle to the dealership
service department and have it repaired as soon as
possible. You may also have your fluid level checked by
your dealer or service center when you have your oil
changed. See
Part D: Recommended Fluids and
Lubricants
on page 6-15 for the proper fluid to use.
5-22

If No Steam Is Coming From Your
Engine
An overheat warning, along with a low coolant light, can indicate a serious problem. See
Low Coolant Warning
Light on page
3-30.
If you get an engine overheat warning with no low
coolant light, but see or hear no steam, the problem may
not be too serious. Sometimes the engine can get a
little too hot when you:
Climb a long hill on a hot day.
Stop after high-speed driving.
Idle for long periods in traffic.
Tow a trailer. If
you get the overheat warning with no sign
of steam,
try this for a minute or
so:
1. In heavy traffic, let the engine idle in NEUTRAL (N)
while stopped. If it is safe to do so, pull off the road,
shift to PARK
(P) or NEUTRAL (N) and let the
engine idle.
2. Turn on your heater to full hot at the highest fan
speed and open the window as necessary.
If you no longer have the overheat warning, you can
drive. Just to be safe, drive slower for about
10 minutes.
If the warning doesn’t come back on, you can drive
normally.
If the warning continues, pull over, stop, and park your
vehicle right away.
If there’s still no sign of steam, you can idle the engine
for three minutes while you’re parked. If you still
have the warning,
turn off the engine and get everyone
out
of the vehicle until it cools down.
You may decide not to lift the hood but to get service
help right away.
5-28

50,000 Miles (83 000 km)
Change automatic transaxle fluid and filter if the
vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery
service.
u do not use your vehicle under any of these
conditions, the fluid and filter do not require changing.
52,500 Miles (87 500 km)
L3 Rotate tires. See Tire inspection and Rotation on
page 5-55
for proper rotation pattern and additional
information.
(See footnote +.)
If yo
60,000 Miles (100 000 km)
B Rotate tires. See Tire Inspection and Rotation on
page 5-55
for proper rotation pattern and additional
information.
(See footnote +.)
Control Service.
0 Replace engine air cleaner filter. An Emission
67,500 Miles (1 12 500 km)
0 Rotate tires. See Tire Inspection and Rotation on
page 5-55
for proper rotation pattern and additional
information.
(See footnote +.)
75,000 Miles (125 000 km)
Ll Inspect engine air cleaner filter if you are driving in
dusty conditions. Replace filter
if necessary. An
Emission Control Service. (See footnote
f.)
0 Rotate tires. See Tire Inspection and Rotation on
page 5-55
for proper rotation pattern and additional
information.
(See footnote +.)
6-7

82,500 Miles (137 500 km)
0 Rotate tires. See Tire inspection and Rotation on
page
5-55 for proper rotation pattern and additional
information.
(See footnote +.)
90,000 Miles (150 000 km)
0 Replace engine air cleaner filter. An Emission
Control Service.
U Rotate tires. See Tire Inspection and Rotation on
page
5-55 for proper rotation pattern and additional
information.
(See footnote +.)
97,500 Miles (162 500 km)
0 Rotate tires. See Tire lnspection and Rotation on
page 5-55 for proper rotation pattern and additional
information.
(See footnote +.)
100,000 Miles (166 000 km)
0 Inspect spark plug wires (except 2.2L Code F
L4 engine). An Emission Control Service.
0 Change automatic transaxle fluid and filter if the
vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
40°F (32°C) or
higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery
service.
if you do not use your vehicle under any of these
conditions, the fluid and filter do not require changing.
150,000 Miles (240 000 km)
U Drain, flush and refill cooling system (or every
60 months since last service, whichever occurs first).
See
Engine Coolant on page 5-23 for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service.
0 Inspect engine accessory drive belt. An Emission
Control Service.
U Replace spark plugs. An Emission Control Service.
6-8

DAB Radio .................................................... 3-70
Daytime Running Lamps (DRL)
......................... 3-13
Defensive Driving
............................................. 4-2
Defogging and Defrosting
................................. 3-1 9
Delayed Headlamps ........................................ 3-1 5
Delayed Locking ............................................... 2-8
Dinghy Towing
................................................ 4-33
Doing Your Own Service Work
........................... 5-3
Dolly Towing
.................................................. 4-34
Dome Lamp
................................................... 3-16
Door
Delayed Locking
........................................... 2-8
Power Door Locks
......................................... 2-8
Programmable Automatic Door Locks
............... 2-8
Rear Security Locks
..................................... 2-10
Position, Safety Belt
..................................... 1-14
Six-Way Power Seat
...................................... 1-3
At Night
..................................................... 4-17
City
........................................................... 4-21
Defensive
..................................................... 4-2
Drunken
....................................................... 4-2
Freeway
..................................................... 4-22
Hill and Mountain Roads
.............................. 4-25
In Rain and on Wet Roads
........................... 4-19
Winter
........................................................ 4-26
Locks
.......................................................... 2-7
Driver
Driving Driving
On Grades
.......................................... 4-42
Driving on Snow or Ice
.................................... 4-27
Driving Through Deep Standing Water
............... 4-20
Driving with
a Trailer ....................................... 4-40
Driving
Through Flowing Water
......................... 4-21
E
Easy Entry Seat ............................................... 1-6
Electrical System
Add-on Equipment
...................................... 5-81
Fuses and Circuit Breakers ........................... 5-81
Power Windows and Other Power Options
...... 5-81
Windshield Wiper Fuses
............................... 5-81
Emergency Trunk Release Handle
..................... 2-14
Emissions Inspection and Maintenance
Programs
................................................... 3-33
Engine
Air Cleaner/Filter
......................................... 5-21
Battery
....................................................... 5-42
Change Engine Oil Light
............................... 3-35
Check and Service Engine Soon Light
............ 3-31
Coolant
...................................................... 5-23
Coolant Heater
............................................ 2-22
Coolant Temperature Gage
........................... 3-30
Cooling System Inspection
............................ 6-14
Engine Compartment Overview
...................... 5-12
4

Engine (cont.) Exhaust
..................................................... 2-33
Oil
............................................................. 5-15
Overheating
................................................ 5-26
Starting
...................................................... 2-1 9
Engine Compartment Fuse Block ...................... 5-84
Engine Coolant Level Check
.............................. 6-9
Engine Cooling When Trailer Towing
.................. 4-43
Engine Oil Additives
........................................ 5-19
Engine Oil Level Check
..................................... 6-9
Engine Oil Scheduled Maintenance
..................... 6-5
Enhanced Traction System Active Light
................................................ 3-29
Warning Light
............................................. 3-28
Enhanced Traction System (ETS)
........................ 4-9
Entry/Exit Lighting
........................................... 3-1 6
Express-Down Window
.................................... 2-1 6
Extender, Safety Belt
....................................... 1-31
Exterior Lamps
............................................... 3-13
F
r-L-:- /r ...... rdulwualpct LI-IL r 7n .................................................
Filter Engine Air Cleaner
...................................... 5-21
Finding a PTY Station
(RDS, XMTM and DAB)
......................... 3.48. 3-59
Finding a Station
............................ 3.40, 3.45. 3-57
Finish Care
.................................................... 5-76
Finish Damage ............................................... 5-77 Fixed Mast Antenna
........................................ 3-72
Flash-to-Pass
................................................... 3-8
Flat Tire
........................................................ 5-61
Flat Tire, Changing
......................................... 5-62
FI
u id
Automatic Transaxle ..................................... 5-22
Manual Transaxle
........................................ 5-22
Power Steering
........................................... 5-36
Windshield Washer
...................................... 5-37
FM Stereo
..................................................... 3-70
Fog Lamps
.................................................... 3-15
Folding the Seatback
........................................ 1-8
Following Distance
.......................................... 4-41
Footnotes
........................................................ 6-5
Fuel
............................................................... 5-5
Additives
...................................................... 5-6
California Fuel
.............................................. 5-6
Filling a Portable Fuel Container
..................... 5-9
Filling Your Tank
........................................... 5-7
Fuels in Foreign Countries
.............................. 5-7
Gasoline Octane
........................................... 5-5
Gasoline Specifications
.................................. 5-5
System Inspection
....................................... 6-13
Fuses and Circuit Breakers ........................... 5-81
Windshield Wiper ......................................... 5-81
Gage
......................................................... 3-37
Fuses 5

G
Gage Engine Coolant Temperature
......................... 3-30
Fuel
.......................................................... 3-37
Speedometer
.............................................. 3-24
Tachometer
................................................. 3-24
Octane
........................................................ 5-5
Specifications ............................................... 5-5
Glass Surfaces ............................................... 5-74
Glove Box
..................................................... 2-37
GM Mobility Program for Persons with
Disabilities
.................................................... 7-5
Gasoline
H
Hazard
Warning Flashers .......................
Head Restraints ...................................
Headlamp High/Low-Beam Changer ........
Headlamps ..........................................
Bulb Replacement .............................
Halogen Bulbs ..................................
Headlamps Off in Park (P) .....................
Headlamps On Reminder .......................
Highway Hypnosis .................................
Hill and Mountain Roads ........................
Hitches ................................................
Hood Front
Turn Signal and Parking Lamps
...
........... 3-4
........... 1-5
........... 3-7
......... 5-49
......... 5-49
......... 5-50
......... 5-49
......... 3-15
........... 3-7
......... 4-24
......... 4-25
......... 4-39 Hood
(cont.)
Checking Things Under
................................ 5-10
Release ..................................................... 5-10
Horn
............................................................... 3-5
How to Add Coolant to the Coolant
Surge Tank
................................................. 5-31
How
to Check ................................................ 5-54
How to Check and Add Fluid
............................ 5-23
How to Check Power Steering Fluid
.................. 5-37
How
to Use This Manual ...................................... ii
How to Wear Safety Belts Properly ................... 1-14
Hydraulic Clutch
............................................. 5-23
Hydraulic Clutch System Check
........................ 6-10
Hydroplaning .................................................. 4-20
I
If No Steam Is Coming From Your Engine .......... 5-28
If Steam Is Coming From Your Engine ............... 5-27
If the Light Is Flashing ..................................... 3-32
If the Light Is On Steady ................................. 3-32
If You Are Stuck in Sand, Mud, Ice or Snow ....... 4-31
If You Do Decide To Pull A Trailer ..................... 4-37
If You’re Caught in a Blizzard ........................... 4-29
Ignition Positions
............................................. 2-18
Ignition Transaxle Lock Check
.......................... 6-12
Indicators
....................................................... 3-22
Inflation
-- Tire Pressure .................................. 5-54
Infants
and Young Children, Restraints
............... 1-34
6

Light (cont.) Malfunction Indicator
.................................... 3-31
Oil Pressure
............................................... 3-34
Security
..................................................... 3-36
Service Vehicle Soon
................................... 3-36
Up-Shift
..................................................... 3-26
Loading Your Vehicle
....................................... 4-35
Lockout Protection
.......................................... 2-1 1
Locks Delayed Locking
........................................... 2-8
Door
........................................................... 2-7
Leaving Your Vehicle
.................................... 2-1 1
Lockout Protection
....................................... 2-1 1
Power Door
.................................................. 2-8
Programmable Automatic Door Locks
............... 2-8
Rear Door Security Locks
............................. 2-10
Loss of Control
............................................... 4-15
Low Coolant Warning Light
.............................. 3-30
Safety
Belt Reminder
................................... 3-25
Low Washer Fluid Warning Light
....................... 3-36
Maintenance. Normal Replacement Parts
......
Maintenance Schedule At Each Fuel Fill
...................................
At Least Once a Month ..........................
At Least Once a Year ............................
At Least Twice a Year ............................
Brake System Inspection ........................
..... 5-88
....... 6-9
....... 6-9
..... 6-10
..... 6-10
..... 6-14 Maintenance Schedule
(cont.)
Engine Cooling System Inspection
................. 6-14
Exhaust System Inspection
........................... 6-13
Fuel System Inspection
................................ 6-13
Introduction
.................................................. 6-2
Maintenance Requirements
............................. 6-2
Part A
- Scheduled Maintenance Services ......... 6-4
Part B
- Owner Checks and Services ............... 6-9
Part C
- Periodic Maintenance Inspections ...... 6-13
Part D
- Recommended Fluids and
Lubricants
............................................... 6-15
Part
E - Maintenance Record ........................ 6-16
Scheduled Maintenance
................................. 6-5
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
.......................... 6-13
Throttle System Inspection
............................ 6-14
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Making Turns
................................................. 4-41
Malfunction Indicator Light
................................ 3-31
Manual Seats
................................................... 1-2
Manual Transaxle
............................................ 2-20
Fluid
.......................................................... 5-22
Operation
................................................... 2-27
Manual Transaxle Check
.................................. 6-10
Manual Windows
............................................ 2-15
How
This Section is Organized
....................... 6-3
Maintenance When Trailer Towing
..................... 4-43
Matching Transmitterts) to Your Vehicle
............... 2-5
8