2003 NISSAN PATHFINDER manual transmission

ing and driving” section for exhaust gas (carbon
monoxide).
Underbody:
The underbody is frequently exposed to corro-
sive substances such as those used on icy roads
or to control dust. It is very important to remove
these substances, otherwise rust will form on the
floor pan, frame, fuel lines and around the ex-
haust system. At the end of winter, the under-
body should be thoroughly flushed with plain
water, being careful to clean those areas where
mud and dirt may accumulate. For additional
information, see “Cleaning exterior” in the “7.
Appearance and care” section.
Fluid leaks:
Check under the vehicle for fuel, oil, water or
other fluid leaks after the vehicle has been
parked for a while. Water dripping from the air
conditioner after use is normal. If you should
notice any leaks or if gasoline fumes are evident,
check for the cause and have it corrected imme-
diately.When performing any inspection or maintenance
work on your vehicle, always take care to prevent
serious accidental injury to yourself or damage to
the vehicle. The following are general precau-
tions which should be closely observed.
WARNING

Park the vehicle on a level surface,
apply the parking brake securely and
block the wheels to prevent the ve-
hicle from moving. For a manual
transmission, move the shift lever to
Neutral. For an automatic transmis-
sion, move the selector lever to the P
(Park) position.

Be sure the ignition key is in the OFF
or LOCK position when performing
any replacement or repair.

If you must work with the engine
running, keep your hands, clothing,
hair and tools away from moving fans
belts and any other moving parts.

It is advisable to secure or remove
any loose clothing and any jewelry,such as rings, watches, etc. before
working on your vehicle.

Always wear eye protection when-
ever you work on your vehicle.

If you must run the engine in an
enclosed space such as a garage, be
sure there is proper ventilation for
exhaust gases to escape.

Never get under the vehicle while it is
supported only by a jack. If it is nec-
essary to work under the vehicle,
support it with safety stands.

Keep smoking materials, flame and
sparks away from fuel and battery.

Your vehicle is equipped with an au-
tomatic engine cooling fan. It may
come on at any time without warning,
even if the ignition key is in the OFF
position and the engine is not run-
ning. To avoid injury, always discon-
nect the negative battery cable be-
fore working near the fan.

On gasoline engine models with theMAINTENANCE PRECAUTIONS
Maintenance and do-it-yourself
8-5


03.1.28/R50-D/V5


multiport fuel injection (MFI) system,
the fuel filter or fuel lines should be
serviced by a NISSAN dealer because
the fuel lines are under high pressure
even when the engine is off.
CAUTION

Do not work under the engine hood
while it is hot. Turn off the engine and
wait until it cools down.

Never connect or disconnect either
the battery or any transistorized
component connector while the igni-
tion key is on.

Never leave the engine or the auto-
matic transmission related compo-
nent harness connector discon-
nected while the ignition key is on.

Avoid direct contact with used engine
oil and coolant. Improperly disposed
engine oil, engine coolant, and/or
other vehicle fluids can hurt the envi-ronment. Always conform to local
regulations for disposal of vehicle
fluid.
This section gives instructions regarding only
those items which are relatively easy for an
owner to perform. More involved service should
be done by your NISSAN dealer.
A genuine NISSAN Service Manual is also avail-
able. See “Owner’s Manual/Service Manual or-
der information” in the “9. Technical and con-
sumer information” section.
You should be aware that incomplete or im-
proper servicing may result in operating difficul-
ties or excessive emissions, and could affect
your warranty coverage.If in doubt about any
servicing, have it done by your NISSAN
dealer.8-6
Maintenance and do-it-yourself


03.1.28/R50-D/V5


Capacity (Approximate)
Recommended specifications
US
measureImp
measureLiter
Manual transmission— — — API GL-4 Viscosity SAE 75W-85
Differential gear oil (exc. LSD)— — — API GL-5 Viscosity SAE 80W-90*1
Limited-slip differential (LSD) gear oil — — —Only LSD gear oil:
API GL-5 and SAE 80W-90*1 approved for Nissan LSD*2
Automatic transmission fluid
Refill to the proper oil level according to the instructions
in the “8. Maintenance and do-it-yourself” section.Nissan Matic “D” (Continental U.S. and Alaska) or Canada NISSAN
Automatic Transmission Fluid.*6
Power steering fluidGenuine Nissan PSF or equivalent*5
All-mode 4WD transfer fluidNissan Matic “D” (Continental U.S. and Alaska) or Canada NISSAN
Automatic Transmission Fluid.*6
Transfer fluidNissan Matic “D” (Continental U.S. and Alaska) or Canada NISSAN
Automatic Transmission Fluid.*6 or API GL-4 Viscosity SAE 75W-90
Brake and clutch fluidGenuine Nissan Brake Fluid*4 or equivalent
DOT 3 (U.S. F.M.V.S.S. No. 116)
Propeller shaft grease— — — NLGI No. 2 (Lithium soap base)
Multi-purpose grease— — — NLGI No. 2 (Lithium soap base)
Air conditioning system refrigerant— — — HFC-134a (R-134a)*4
Air conditioning system lubricants———Nissan A/C System Oil Type S or exact equivalent*4
*1: For hot areas, viscosity SAE 90 is suitable for ambient temperatures above 0°C (32°F).
*2: Contact your NISSAN dealer for a list of approved oils.
*3: Available in mainland U.S. through your NISSAN dealer.
*4: See “Vehicle identification” later in this section for air conditioner specification label.
*5: For Canada, NISSAN Automatic Transmission Fluid (ATF), DEXRON
TMIII/MERCON
TMor equivalent ATF may also be used.
*6: Dexron
TMIII/Mercon
TM
or equivalent may also be used. Outside the continental U.S. and Alaska contact an authorized NISSAN dealer for more information regarding
suitable fluids, including recommended brand(s) of DEXRON
TMIII/MERCON
TMAutomatic Transmission Fluid.
Technical and consumer information
9-3


03.1.28/R50-D/V5


Cigarette lighter and ashtray .................................. 2-29
Circuit breaker, Fusible link .................................... 8-27
Cleaning exterior and interior .......................... 7-2, 7-3
Clock ............................................................................ 2-27
Clutch
Fluid........................................................................ 8-19
Cold weather driving ................................................ 5-37
Compact Disc (CD) changer operation .............. 4-26
Compact Disc (CD) player (See audio
system) ......................................................................... 4-19
Compact spare tire ................................................... 8-39
Compass display ......................................................... 2-7
Console box................................................................ 2-33
Controls
Heater and air conditioner controls.................. 4-2
Steering wheel audio controls ........................ 4-28
Coolant
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant ................................. 8-10
Checking engine coolant level........................... 8-9
Corrosion protection ................................................... 7-4
Cover, Tonneau cover .............................................. 2-36
Cruise control............................................................. 5-18
Cup holders ................................................................ 2-31
D
Daytime running light system ................................. 2-23
Defogger switch, Glass hatch and outside mirror
defogger switch ......................................................... 2-20
Determining vehicle payload capacity.................. 9-15
Dimensions and weights ......................................... 9-11
Door open warning light .......................................... 2-11Drive belts ................................................................... 8-22
Drive positioner, Automatic..................................... 3-17
Driving
Cold weather driving ......................................... 5-37
Driving with automatic transmission ..... 5-7, 5-11
Driving with manual transmission .......... 5-8, 5-15
On-pavement and offroad driving ..................... 5-4
Precautions when starting and driving ............ 5-2
Safety precautions ................................................ 5-5
E
Economy, Fuel............................................................ 5-20
Electric sunroof .......................................................... 2-40
Emission control information label ........................ 9-14
Emission control system warranty......................... 9-22
Engine
Before starting the engine................................ 5-10
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant ................................. 8-10
Changing engine oil ........................................... 8-14
Changing engine oil filter ................................. 8-15
Checking engine coolant level........................... 8-9
Checking engine oil level ................................. 8-13
Coolant temperature gauge ............................... 2-4
Engine block heater ........................................... 5-39
Engine compartment check locations.............. 8-7
Engine cooling system ......................................... 8-9
Engine oil .............................................................. 8-13
Engine oil and oil filter recommendation......... 9-6
Engine oil viscosity ............................................... 9-6
Engine serial number ......................................... 9-13
Engine specifications ........................................... 9-9If your vehicle overheats ................................... 6-11
Starting the engine............................................. 5-10
Exhaust gas (Carbon monoxide).............................. 5-2
F
4WD shift switch operations ................................. 5-28
F.M.V.S.S. certification label................................... 9-13
Filter, Air cleaner housing filter .............................. 8-23
Flashers (See hazard warning flasher switch) ... 2-25
Flat tire............................................................................ 6-2
Floor mat cleaning ....................................................... 7-4
Fluid
Automatic transmission fluid (ATF) ................ 8-16
Brake and clutch fluid ....................................... 8-19
Brake fluid............................................................. 8-19
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Engine coolant ....................................................... 8-9
Engine oil .............................................................. 8-13
Power steering fluid ........................................... 8-18
Window washer fluid ......................................... 8-20
FM-AM radio with cassette player and Compact
Disc (CD) player........................................................ 4-16
FM-AM-SATELLITE radio with cassette player and
Compact Disc (CD) player/CD changer............. 4-23
Fog light switch ......................................................... 2-24
Four wheel drive (4WD) .............................. 5-21, 5-25
Front air bag system (See supplemental restraint
system) ......................................................................... 1-16
Front fog light switch ............................................... 2-24
Front manual seat adjustment .................................. 1-2
Front power seat adjustment .................................... 1-4


03.1.28/R50-D/V5

10-2

Front window open/close with key ......................... 3-3
Fuel
Capacities and recommended fuel/
lubricants ................................................................. 9-2
filler cap................................................................. 3-13
filler lid ................................................................... 3-13
Fuel economy ...................................................... 5-20
Fuel octane rating ................................................. 9-4
Fuel recommendation ........................................... 9-4
Gauge ...................................................................... 2-5
Fuses ............................................................................ 8-27
Fusible links ................................................................ 8-27
G
Garage door opener, HomeLink
Universal
Transceiver .................................................................. 2-44
Gas cap ....................................................................... 3-13
Gauge ............................................................................. 2-3
Engine coolant temperature gauge .................. 2-4
Fuel gauge .............................................................. 2-5
Odometer ................................................................ 2-3
Speedometer .......................................................... 2-3
Tachometer ............................................................. 2-4
General maintenance .................................................. 8-2
Glass hatch and outside mirror defogger
switch ........................................................................... 2-20
Glass hatch lock........................................................ 3-11
Glass hatch opener .................................................. 3-11
Glove box .................................................................... 2-32
Glove box lock ........................................................... 2-32H
Hazard warning flasher switch............................... 2-25
Head restraints ............................................................. 1-9
Headlights
Bulbreplacement ............................................... 8-31
Headlight switch ................................................. 2-21
Heated seats .............................................................. 2-26
Heater
Engine coolant heater ....................................... 5-39
Heater and air conditioner controls.................. 4-2
Heater operation.................................................... 4-4
Heater and air conditioner (Automatic — Type A)
(if so equipped) ..................................................... 4-8
Heater and air conditioner (Automatic — Type B)
(if so equipped) ................................................... 4-10
HomeLink
Universal Transceiver ......................... 2-44
Hood, release ............................................................... 3-9
Hook, Luggage hook ................................................ 2-34
Horn .............................................................................. 2-25
How to stop alarm, Vehicle security .................... 2-17
I
Ignition switch ............................................................... 5-7
Automatic transmission models ............. 5-7, 5-11
Key positions .......................................................... 5-9
Manual transmission models .................. 5-8, 5-15
Immobilizer system .................................................... 2-18
Indicator lights............................................................ 2-14
Inside mirror ................................................................ 3-16
Inspection/maintenance (I/M) test ........................ 9-23
Instrument panel........................................................... 2-2Interior lights ............................................................... 2-42
J
Jump starting................................................................. 6-9
K
Keyless entry (See remote keyless entry
system) ........................................................................... 3-5
Keys................................................................................. 3-2
L
Label, Air conditioner specification label ............ 9-14
Label, Emission control information label............ 9-14
Label, F.M.V.S.S. certification label ...................... 9-13
Labels
Air bag warning labels ...................................... 1-21
Engine serial number ......................................... 9-13
Vehicle identification number (VIN)................ 9-12
LATCH (Lower Anchors and Tether For Children)
system (if so equipped) ........................................... 1-41
Light
Air bag warning light ......................................... 1-21
Bulbreplacement ............................................... 8-30
Fog light switch................................................... 2-24
Front fog light switch......................................... 2-24
Headlight switch ................................................. 2-21
Headlights Bulbreplacement .......................... 8-31
Interior lights ........................................................ 2-42
Personal lights ..................................................... 2-43
Replacement ........................................................ 8-30


03.1.28/R50-D/V5

10-3

Readiness for inspection/maintenance (I/M) test (US
only) .............................................................................. 9-23
Rear door lock, Child safety rear door lock.......... 3-4
Rear power point....................................................... 2-28
Rear seat adjustment .................................................. 1-6
Rear window wiper and washer switch .............. 2-19
Registering your vehicle in another country ....... 9-12
Remote keyless entry system ................................... 3-5
Reporting safety defects (US only) ...................... 9-22
Rollover........................................................................... 5-5
S
Safety
Child seat belts ................................................... 1-25
Reporting safety defects (US only)................ 9-22
Towing safety....................................................... 9-19
Satellite radio reception........................................... 4-14
Seat
Belt warning light................................................ 2-13
Seat adjustment
Front manual seat adjustment............................ 1-2
Front power seat adjustment ............................. 1-4
Rear seat adjustment ........................................... 1-6
Seat belt(s)
Child safety .......................................................... 1-25
Infants and small children ................................. 1-26
Injured persons.................................................... 1-26
Larger children .................................................... 1-26
Pre-tensioner seat belt system ....................... 1-20
Precautions on seat belt usage ...................... 1-24
Pregnant women ................................................. 1-26
Seat belt cleaning ................................................. 7-4
Seat belt extenders ............................................ 1-32Seat belt hook ..................................................... 1-30
Seat belt maintenance ...................................... 1-32
Seat belts ............................................................. 1-23
Three-point type with retractor ....................... 1-26
Two-point type without retractor (rear center lap
belt) ........................................................................ 1-30
Seat(s)
Heated seats........................................................ 2-26
Seats ........................................................................ 1-2
Security system, vehicle security system ............ 2-16
Security systems (Nissan Vehicle Immobilizer
System), Engine start ............................................... 2-18
Security systems (See vehicle security
system) ......................................................................... 2-16
Servicing air conditioner .......................................... 4-12
Shift lock release ....................................................... 5-14
Shifting
Automatic transmission ............................ 5-7, 5-11
Manual transmission ................................. 5-8, 5-15
Shoulder belt height adjustment, For front
seats ............................................................................. 1-29
Spare tire carrier ....................................................... 3-10
Spark plugs................................................................. 8-23
Speedometer ................................................................ 2-3
Starting
Before starting the engine................................ 5-10
Jump starting .......................................................... 6-9
Precautions when starting and driving ............ 5-2
Push starting ........................................................ 6-11
Starting the engine............................................. 5-10
Steering
Power steering fluid ........................................... 8-18
Power steering system ...................................... 5-33
Steering wheel switch for audio controls..... 4-28Tilting steering wheel......................................... 3-15
Storage ........................................................................ 2-29
Sun shade ................................................................... 2-41
Sun visors ................................................................... 3-15
Sunglasses holder .................................................... 2-30
Sunroof ........................................................................ 2-40
Electric sunroof ................................................... 2-40
Supplemental air bag warning labels................... 1-21
Supplemental air bag warning light .......... 1-21, 2-13
Supplemental front air bag system....................... 1-16
Supplemental restraint system............................... 1-10
Precautions on supplemental restraint
system.................................................................... 1-10
Supplemental side air bag and curtain side-impact
air bag system (if so equipped) ............................ 1-18
Switch
4WD shift switch operations ........................... 5-28
Audio control ....................................................... 4-28
Fog light switch................................................... 2-24
Front fog light switch......................................... 2-24
Glass hatch and outside mirror defogger
switch..................................................................... 2-20
Hazard warning flasher switch ........................ 2-25
Headlight switch ................................................. 2-21
Ignition switch ........................................................ 5-7
Ignition switch automatic transmission
models .......................................................... 5-7, 5-11
Ignition switch manual transmission
models .......................................................... 5-8, 5-15
Overdrive switch ................................................. 5-14
Power door lock switch....................................... 3-4
Turn signal switch .............................................. 2-24


03.1.28/R50-D/V5

10-5

T
Tachometer.................................................................... 2-4
Temperature display .................................................... 2-6
Temperature gauge, Engine coolant temperature
gauge .............................................................................. 2-4
Theft (Nissan Vehicle Immobilizer System), Engine
start ............................................................................... 2-18
Three way catalyst ....................................................... 5-3
Tilting steering wheel ............................................... 3-15
Tire
Flat tire ..................................................................... 6-2
Uniform tire quality grading .............................. 9-21
Tires
Spare tire .............................................................. 8-39
Tire chains ............................................................ 8-36
Tire placard .......................................................... 9-14
Tire pressure ........................................................ 8-34
Tire rotation .......................................................... 8-37
Types of tires ....................................................... 8-35
wheel/tire size ...................................................... 9-11
Wheels and tires ................................................ 8-34
Tonneau cover ........................................................... 2-36
Top tether strap child restraints ............................ 1-44
Towing
Tow truck towing ................................................ 6-12
Towing a trailer.................................................... 9-17
Towing load/specification chart ...................... 9-19
Towing safety....................................................... 9-19
Trailer towing .............................................................. 9-17
Transceiver, HomeLinkUniversal
Transceiver .................................................................. 2-44
Transfer case shifting procedures............. 5-23, 5-25Transmission
Automatic transmission fluid (ATF) ................ 8-16
Driving with automatic transmission ..... 5-7, 5-11
Driving with manual transmission .......... 5-8, 5-15
Transmission selector lever lock release ...... 5-14
Transmitter (See remote keyless entry system) ... 3-5
Traveling or registering your vehicle in another
country ......................................................................... 9-12
Turn signal switch ..................................................... 2-24
U
Underbody cleaning .................................................... 7-3
Uniform tire quality grading .................................... 9-21
V
Vanity mirror light ...................................................... 2-43
Vehicle
Dimensions and weights................................... 9-11
Identification number (VIN)............................... 9-12
Loading information............................................ 9-15
Recovery (freeing a stuck vehicle) ................. 6-16
Security system ................................................... 2-16
Vehicle Dynamic Control (VDC) system (if so
equipped) .................................................................... 5-36
Ventilators ...................................................................... 4-2
W
Warning labels, Air bag warning labels .............. 1-21
Warning light
4WD warning light ............................................. 5-30Air bag warning light .............................. 1-21, 2-13
Anti-lock brake warning light ............................. 2-9
Automatic transmission park warning light .. 2-10
Brake warning light ............................................ 2-11
Door open warning light ................................... 2-11
Low fuel warning light ....................................... 2-12
Seat belt warning light and chime ................. 2-13
Warning lights .............................................................. 2-9
Warning, Hazard warning flasher switch ............ 2-25
Warning, Warning/indicator lights and audible
reminders ....................................................................... 2-9
Warranty, Emission control system warranty ..... 9-22
Washer switch
Rear window wiper and washer switch........ 2-19
Windshield wiper and washer switch ........... 2-19
Washing ......................................................................... 7-2
Waxing............................................................................ 7-2
Weights (See dimensions and weights) ............. 9-11
Wheel/tire size ........................................................... 9-11
Wheels and tires ....................................................... 8-34
Cleaning aluminum alloy wheels ....................... 7-3
Window washer fluid ............................................... 8-20
Window(s)
Cleaning................................................................... 7-3
Power windows................................................... 2-38
Windshield wiper and washer switch .................. 2-19
Wiper
Rear window wiper and washer switch........ 2-19
Windshield wiper and washer switch ........... 2-19
Wiper blades ....................................................... 8-24


03.1.28/R50-D/V5

10-6