2003 MERCEDES-BENZ SL500 open engine compartment

Contents
Retractable hardtop........................... 159
Opening and closing the retractable
hardtop ........................................ 159
Driving systems ................................. 168
Cruise control .............................. 168
Distronic* .................................... 171
Active Body Control (ABC) ........... 183
Parktronic system* ...................... 186
Useful features .................................. 190
Interior storage spaces ................ 190
Ashtray......................................... 196
Cigarette lighter ........................... 197
Heated steering wheel* (Canada
only–model SL 500) ..................... 197
Easy-Pack load assist in the trunk 198
Electrical outlet ............................ 199
Telephone* .................................. 199
Tele Aid ........................................ 200
Garage door opener ..................... 208Operation......................................... 213
The first 1000 miles (1500 km) ......... 214
Driving instructions............................ 215
Drive sensibly – save fuel............. 215
Drinking and driving ..................... 215Pedals ........................................... 215
Power assistance .......................... 216
Brakes........................................... 216
Driving off ..................................... 218
Parking.......................................... 218
Tires .............................................. 219
Hydroplaning................................. 219
Tire traction .................................. 220
Tire speed rating ........................... 220
Winter driving instructions ............ 221
Standing water.............................. 222
Passenger compartment ............... 222
Driving abroad .............................. 222
Control and operation of radio trans-
mitters .......................................... 222
Catalytic converter........................ 223
Emission control ........................... 224
Coolant temperature..................... 224
At the gas station ............................... 225
Check regularly and before a
long trip ........................................ 226Engine compartment .......................... 227
Hood ............................................. 227
Engine oil ...................................... 228
Transmission fluid level ................ 230
Oil level in the ABC system ........... 230
Coolant ......................................... 230
Battery .......................................... 232
Windshield washer system and
headlamp cleaning system ........... 233
Tires and wheels ................................ 234
Important guidelines ..................... 234
Life of tires ................................... 235
Direction of rotation ..................... 235
Checking tire inflation pressure .... 235
Rotating wheels ............................ 238
Winter driving ..................................... 239
Winter tires ................................... 239
Block heater (Canada only) ........... 240
Snow chains ................................. 240
Maintenance ...................................... 241
Clearing the service indicator ....... 241
Service term exceeded ................. 241
Calling up the service indicator .... 242
Resetting the service indicator ..... 242
Vehicle care ....................................... 243
Cleaning and care of the vehicle ... 243

227 Operation
Engine compartment
Engine compartment
Hood
Opening
1Hood release

Pull lever1 downwards.
The hood is unlocked.
2Lever for opening the hood

Push lever2 on the hood upwards.

Pull up on the hood and then release it.
The hood will be automatically held
open at shoulder height by gas-filled
struts.
Warning!
G
Do not pull the release lever while the vehi-
cle is in motion. Otherwise the hood could
be forced open by passing air flow.
!To avoid damage to the windshield wip-
ers or hood, never open the hood if the
wiper arms are folded forward away
from the windshield.
Warning!
G
To help prevent personal injury, stay clear of
moving parts when the hood is open and the
engine is running. Make sure the hood is
properly closed before driving. When closing
the hood, use extreme caution not to catch
hands or fingers.
The radiator fan may continue to run for ap-
proximately 30 seconds or may even restart
after the engine has been turned off. Stay
clear of fan blades.

228 OperationEngine compartment
Closing
Let the hood drop from a height of ap-
proximately 1
1/2ft (50 cm).
The hood will lock audibly.

Check to make sure that the hood is
fully closed.
If you can raise the hood at a point
above the headlamps, then it is not
properly closed. Open it again and let it
drop with somewhat greater force.
Engine oil
The amount of oil your engine needs will
depend on a number of factors, including
driving style. Higher oil consumption can
occur when

the vehicle is new


the vehicle is driven frequently at high-
er engine speeds
Engine oil consumption checks should only
be made after the vehicle break-in period.
Checking engine oil level
When checking the oil level the vehicle
must


be parked on level ground


be at normal operating temperature


have been stationary for at least five
minutes with the engine turned off
Warning!
G
If you see flames or smoke coming from the
engine compartment, or if the coolant tem-
perature gauge indicates that the engine is
overheated, do not open the hood. Move
away from the vehicle and do not open the
hood until the engine has cooled. If neces-
sary, call the fire department.Warning!
G
The engine is equipped with a transistorized
ignition system. Because of the high voltage
it is dangerous to touch any components (ig-
nition coils, spark plug sockets, diagnostic
socket) of the ignition system

with the engine running


while starting the engine


if ignition is “on” and the engine is
turned manually
Warning!
G
Be careful that you do not close the hood on
anyone.

231 Operation
Engine compartment
1Coolant expansion tank
Using a rag, turn the cap slowly approx-
imately one half turn to the left to re-
lease any excess pressure.

Continue turning the cap to the left and
remove it.
The coolant level is correct if the level


for cold coolant: is up to the upper
mark on the bracing rib of the coolant
expansion tank (translucent)


for warm coolant: is approx. 0.6 in
(1.5 cm) higher

Add coolant as required.

Replace and tighten cap.
More information on coolant can be found
in the “Technical data” section
(
page 345).
Warning!
G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.


Do not remove pressure cap on coolant
reservoir if engine temperature is above
194°F (90°C). Allow engine to cool
down before removing cap. The coolant
reservoir contains hot fluid and is under
pressure.


Using a rag, slowly open the cap approx-
imately
1/2 turn to relieve excess pres-
sure. If opened immediately, scalding
hot fluid and steam will be blown out un-
der pressure.


Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene gly-
col which may burn if it comes into con-
tact with hot engine parts.

254 Practical hintsWhat to do if …Problem
Possible cause
Suggested solution
D
The red coolant warning lamp
lights up when the engine is run-
ning.
There is insufficient coolant in the reservoir.
If this warning lamp lights up frequently,
there is a leak in the cooling system.
If the coolant level is correct, the electric ra-
diator fan may be broken.

Immediately add coolant to prevent
engine from overheating
(page 230).

Have the cooling system checked.

If the coolant temperature is below
257 °F (125 °C), you can continue
driving to the nearest authorized
Mercedes-Benz Center.

Avoid high engine loads (e.g. driving
uphill) and stop-and-go driving.
D
The red coolant warning lamp
lights up while driving and you
hear a warning sound.
The coolant temperature has exceeded
257 °F (125 °C).

Stop as soon as possible and allow
the engine and coolant to cool down.
Warning!
G
Driving when your engine is badly overheat-
ed can cause some fluids which may have
leaked into the engine compartment to
catch fire. You could be seriously burned.
Steam from an overheated engine can cause
serious burns and can occur just by opening
the engine hood. Stay away from the engine
if you see or hear steam coming from it.
Turn off the engine, get out of the vehicle
and do not stand near the vehicle until it
cools down.

273 Practical hints
What to do if …
Left display
Right display
Possible cause
Possible solution
Ï
Coolant
Stop, engine off!
The coolant is too hot.
The poly-V-belt could be broken.

Stop the vehicle.

Only start the engine again after the message
disappears. You could otherwise damage the
engine.

Stop immediately and check the poly-V-belt.
If it is broken, do not drive any further.
Notify an authorized Mercedes-Benz Cen-
ter.
If it is in order, drive immediately to the
nearest authorized Mercedes-Benz Cen-
ter.
Warning!
G
Driving when your engine is badly overheat-
ed can cause some fluids which may have
leaked into the engine compartment to
catch fire. You could be seriously burned.
Steam from an overheated engine can cause
serious burns and can occur just by opening
the engine hood. Stay away from the engine
if you see or hear steam coming from it.
Turn off the engine, get out of the vehicle
and do not stand near the vehicle until it
cools down. The engine should not be oper-
ated with the coolant temperature above
266°F (130°C). Doing so may cause serious
engine damage which is not covered by the
Mercedes-Benz Limited Warranty.

329 Practical hintsFuses
Fuses
Main fuse box
The main fuse box is in the engine com-
partment on the driver’s side in front of the
bulkhead (wall separating the engine and
passenger compartments).
1Main fuse box
2Unlocking
3Locking
Opening
Move slide to position 3 and lift cover.Closing

Hook cover onto tabs and close.

Move slide to position 2.
Fuse chart
The fuse chart is found in the vehicle tool
kit in the trunk. The amperages of the fus-
es are also given there.
Spare fuses
Spare fuses are found in the vehicle tool kit
in the trunk.
Fuse extractor
The fuse extractor is found in the vehicle
tool kit in the trunk.
iOnly install fuses that have been tested
and approved by Mercedes-Benz and
that have the specified amperage rat-
ing.
Never attempt to repair or bridge a
blown fuse. Have the cause determined
and remedied by an authorized
Mercedes-Benz Center.
!The fuse box cover must be properly
positioned with the slide at the
‹
symbol to prevent moisture or dirt from
entering the fuse box and possibly im-
pairing fuse operation.

364 IndexI
Ignition 29, 31
Switching on 29
Immobilizer 75
Activating 48, 75
Deactivating 75
Indicator lamps see Lamps, indicator and
warning
Infant and child restraint systems 62
Instrument cluster 20, 108, 353
Select language 123
Instrument lighting 108
Interior lighting 106
Automatic control 106
Delayed switch-off 127
Manual operation 107
Interior lighting control 25
Interior storage spaces 190
Locking storage compartments 194
Unlocking storage
compartments 194, 291
Intermittent wiping 44
J
Jack 289K
Key
Opening retractable hardtop 163
Key dependent memory 130
Key positions 29
Key, electronic
Battery check lamp 81
Changing the batteries 293
Checking the batteries 82
Closing retractable hardtop 164
Factory setting 81
Global locking 81
Global unlocking 81
Individual setting 81
Messages in display 286
Positions in starter switch 29
Remote controls 80
Reprogramming 81
Starting the engine 40
Turning off the engine 48
Unlocking 28
Key, Mechanical 290
KEYLESS-GO* 353
Key positions 30
Starting the engine 40
Turning off the engine 49KEYLESS-GO* card 84
Changing the batteries 294
Checking the batteries 87
Checking vehicle lock status 87
Factory setting 86
Global locking 86
Global unlocking 86
Locking 88
Loss of 89
Messages in display 269
Reprogramming 86
Unlocking 30, 84
KEYLESS-GO* start/stop button 23, 30,
40
Keys 80
Loss of 84
Kickdown 142, 353
Kilometers/miles in speedometer 123
Kneebag 57