2003 MERCEDES-BENZ SL500 inflation pressure

305 Practical hints
Flat tire

Drive the vehicle back and forth very
slowly approximately 30 ft (10 m).
This distributes the TIREFIT sealant ma-
terial inside the tire.

Take the electric air pump out of the
trunk.
1Flap
2Air hose with pressure gauge and vent
screw
3Union nut
4Electrical plug

Open flap 1 on air pump.

Pull out electrical plug 4 and air hose
with the pressure gauge 2.

Screw the air hose 2 onto the tire valve.

Insert electrical plug 4 into vehicle ci-
gar lighter socket.

Turn the key in the ignition to position
1 (
page 29).
or

Press the KEYLESS-GO* start/stop
button on the selector lever once. Do
not depress brake pedal.

Press I on the electric air pump switch.
The electric air pump should now
switch on and inflate the tire.
After 5 minutes, the pressure gauge must
display at least 26 psi (1.8 bar). The air
hose and the union nut can become hot
during inflation. Please exercise appropri-
ate caution.

If this tire pressure is not attained, turn
off the electric air pump, detach the air
hose from the tire valve, and again
drive vehicle back and forth very slowly
approximately 30 ft (10 m).
This serves to better distribute the
TIREFIT sealant material inside the tire.

Inflate the tire again.
Warning!
G
Observe safety instructions on air pump la-
bel.

310 Practical hintsFlat tireAfter 5 minutes, the pressure gauge must
display at least 26 psi (1.8 bar). The air
hose can become hot during inflation.
Please exercise appropriate caution.
If this tire pressure is not attained, turn
off the electric air pump, detach the fill-
er hose from the tire valve, and drive
vehicle back and forth very slowly ap-
proximately 30 ft (10 m).
This serves to better distribute the
TIREFIT sealant material inside the tire.

Unscrew the air pump’s air hose5 from
flange6 of the TIREFIT container.

Inflate the tire again.

After attaining a tire pressure of 26 psi
(1.8 bar), press0 on electric air pump
switch8.
The electric air pump should now be
switched off.

Turn the key in the ignition to
position0 (
page 29).
or

Press the KEYLESS-GO* start/stop
button (
page 30) on the selector le-
ver once. Do not depress brake pedal.

Detach the electric air pump.
The air hose may still be hot. Please ex-
ercise appropriate caution.

Store the electrical plug and the air
hose behind the flap and place the air
pump back in the trunk.

Close the trunk lid.

Drive away immediately.
The TIREFIT sealant will distribute itself
evenly inside the tire.
Warning!
G
If a tire pressure of 26 psi (1.8 bar) is not at-
tained, tire is too severely damaged for
TIREFIT to provide a reliable tire repair.
In this case, TIREFIT cannot properly seal
the tire.
Do not drive the vehicle.
Contact the nearest Mercedes-Benz Center
or call Roadside Assistance.
Warning!
G
Do not exceed vehicle speed of
50 mph (80 km / h). A TIREFIT repair is not
designed to operate at higher speeds.
The sticker must be attached on the instru-
ment cluster where it will be easily seen by
the driver.
Vehicle handling characteristics may
change. Adapt your driving accordingly.

311 Practical hints
Flat tire

After driving vehicle for an initial
10 minutes, check tire pressure using
the pressure gauge on the air pump.

Visit an authorized Mercedes-Benz
Center as soon as possible to obtain a
new TIREFIT kit.

Bring used TIREFIT materials to an au-
thorized Mercedes-Benz Center for
proper disposal.

Replace your TIREFIT container every
four years. Replacement containers are
available at your authorized
Mercedes-Benz Center.
Warning!
G
If tire pressure has fallen below
20 psi (1.3 bar) do not continue to drive the
vehicle.
Park your vehicle safely away from the road-
way and contact the nearest authorized
Mercedes-Benz Center or Roadside Assis-
tance.
I f ti re pre s su re is a t l ea s t 2 0 ps i (1 .3 bar ), in -
flate tire to correct pressure (see label on
fuel filler flap), and drive vehicle to nearest
tire repair facility to have tire repaired or re-
placed.
Recommended duration of use:
300 miles (500 km) at 50 mph (80 km / h)
with the recommended tire pressure.
Warning!
G
Follow recommend inflation pressures.
Do not overinflate tires. Overinflating tires
can result in sudden deflation (blowout) be-
cause they are more likely to become punc-
tured or damaged by road debris, potholes
etc.
Do not underinflate tires. Underinflated tires
wear unevenly, adversely affect handling
and fuel economy, and are more likely to fail
from being overheated.
Do not overload the tires by exceeding the
specified vehicle capacity weight (as indicat-
ed by the label on the pillar in the driver’s
door opening). Overloading the tires can
overheat them, possibly causing a blowout.
Warning!
G
Do not exceed vehicle speed of 50 mph
(80 km/h). A TIREFIT repair is not designed
to operate at higher speeds.
The sticker must be attached on the instru-
ment cluster where it will be easily seen by
the driver.
Vehicle handling characteristics may
change. Adapt your driving accordingly.

317 Practical hints
Flat tire

Press 0 on the electric air pump switch.

Turn the key in the ignition to
position0.
or

Press KEYLESS-GO* start/stop button
on the selector lever twice without de-
pressing the brake pedal.
The electric air pump should now be
switched off.

If the tire pressure is above 36 psi
(2.5 bar), release excess tire pressure
using the vent screw.

Detach the electric air pump.

Stow the electrical plug and the air
hose behind the flap and place the air
pump back in the trunk.
!Do not operate the air pump longer
than eight minutes without interrup-
tion. Otherwise it may overheat.
You may operate the air pump again af-
ter it has cooled off.
Warning!
G
Follow recommend inflation pressures.
Do not overinflate tires. Overinflating tires
can result in sudden deflation (blowout) be-
cause they are more likely to become punc-
tured or damaged by road debris, potholes
etc.
Do not underinflate tires. Underinflated tires
wear unevenly, adversely affect handling
and fuel economy, and are more likely to fail
from being overheated.
iThe flat tire may be transported in the
trunk when the retractable hardtop is
lowered. Use the protective sheet pro-
vided with the spare wheel. Do not ac-
tivate the tire inflation pressure
monitor until the deflated tire has been
removed from the vehicle.

337 Technical data
Rims and tires
Rims and tires
Only use tires and rims which have been
specifically developed for your vehicle and
tested and approved by Mercedes-Benz.
Other tires and rims can have detrimental
effects, such as

poor handling characteristics


increased noise


increased fuel consumption
Same size tires
!Moreover, tires and rims not approved
by Mercedes-Benz may, under load,
exhibit dimensional variations and dif-
ferent tire deformation characteristics
that could cause them to come into
contact with the vehicle body or axle
parts. Damage to the tires or the vehi-
cle may be the result.
iFurther information on tires and rims is
available at any authorized
Mercedes-Benz Center. A tire inflation
pressure table is located on the fuel fill-
er cap of the vehicle. The tire pressure
should be checked regularly and
should only be adjusted on cold tires.
Follow tire manufacturer’s mainte-
nance recommendation included with
vehicle.
SL 500
SL 55 AMG
Rims (light alloy)
81/2J x17
81/2 J x18
Wheel offset
1.38 in (35 mm)
1.18 in (30 mm)
Summer tires (radial-ply tires)
255/45 R17 98W
–
Winter tires (radial-ply tires)
255/45 R17 98V M+S
255/40 R18 95V M+S

357 Index
A
ABC 183, 351
Messages in display 258
Oil level 230
Setting vehicle level 184
ABC switch 24
ABS 68, 351
Malfunction indicator lamp 21, 251
Messages in display 259
Warning lamp 70, 251
ABS/ESP
Warning lamp 250
ABS/ESP warning lamp 21
Activating
Air circulation mode 152
Air conditioning (cooling) 155
Anti-theft alarm system 76
Central locking (control system) 128
Distance warning function* 180
Distronic* 175
Easy-entry/exit feature 129
Electric air pump 316
ESP 72
Exterior lamps 102
Hazard warning flasher 105
High beams 104Ignition 29
Immobilizer 48, 75
Parktronic* 189
Rear window defroster 153
Residual heat 154
Seat heater 97, 98
Seat ventilation* 96
Steering wheel gearshift control
(SL 55 AMG Kompressor) 143
Tow-away alarm 77
Windshield wipers 44
Active Body Control (ABC) switch 24
Adjusting
Air distribution 151
Air volume 150
Backrest tilt 33
Exterior rear view mirrors 35
Head restraint height 33
Head restraint tilt 34
Inside rear view mirror 35
Lumbar support 93
Mirrors 35
Multicontour backrest* 93
Seat cushion depth 33
Seat cushion tilt 33
Seat height 33Seat in the lumbar region 94
Seat in the shoulder region 94
Seats 32
Steering wheel 34
Air conditioner (cooling)
Turning off 155
Turning on 155
Air conditioner refrigerant 343
Air pressure see Tire inflation pressure
Air pump, electric 289
Turning on 316
Air recirculation mode 152
Air volume adjustment 150
Airbags 53
Children 54
Front 57
Head-thorax 57, 58
Kneebag 57
Passenger 57
Alarm
Audible 67, 75
Canceling 76
Visual 75
Alignment bolt 351
Alignment bolt (vehicle tool kit) 288, 314
Anticorrosion/antifreeze 342, 346

370 Index
Locator lighting 125
Miles/kilometers in
speedometer 123
Multifunction display language 123
Night security illumination 125
Radio station 116
Speedometer display mode 123
Station selection mode 128
Suspension tuning 183
Temperature (interior) 149
Temperature indicator 122
Time display mode 122
Tire inflation pressure 129
Units
Speedometer 123
Temperature 122
Tire inflation pressure 129
Vehicle level control 184
Setting speed
Cruise control 169, 170
Distronic* 176, 177Settings
Calling up Distronic* 117, 174
Convenience functions 129
Factory (electronic key) 81
Individual (electronic key) 81
Resetting all (control system) 120
Settings menu
Individual vehicle settings 119
Submenus 120
Shifting
into optimal gear range 138
Shifting gears
On steering wheel (SL 55 AMG) 142
Shoulder support
Seat adjustment 94
Side air vents 23
Side marker lamps 296, 299
Side windows 157
Automatic opening 158
Closing 158
Closing (KEYLESS-GO*) 88
Opening 158
Opening fully 158
Stopping 158
Synchronizing power windows 158SL 500
Spare wheel 338
Tires 338
SL 55 AMG Kompressor
Tires 338
SL 55 AMG Kompressor
MANUAL shift program mode 142
Steering wheel gearshift control 143
Snow chains 240
Spare fuses 288, 329
Spare tire see Spare wheel 302
Spare wheel* 289, 312
Inflating tire 316
Tire inflation pressure 316
Speed settings
Cruise control 170
Distronic* 177
Speedometer 21
Setting units 123
Sporty driving style 183
SRS 355
Indicator lamp 252
Standing lamps 102, 296
Replacing bulbs 299
Standing water
Driving instructions 222

372 IndexTele Aid 200
Emergency calls 202
Information 205
Initiating an emergency call
manually 203
Messages in display 263
Roadside assistance 204
SOS button 25, 203
Tele Aid system 201
Tele Aid System 355
Telephone* 22, 199
Answering a call 134
Dialing 135
Ending a call 135
Hands-free microphone 25
Loading phone book* 135
Messages in display 270
Operating 133
Redialing 136
Signal strength 134
Telephones and two-way radios 223Temperature
Outside temperature indicator 109
Sensor 25
Setting interior temperature 149
Setting units in display 122
Tires 236
Tightening torque 318, 355
Tilt
Head restraint 34
Time display mode
Setting 122
Tire inflation pressure 305, 310
Checking 226, 235
Setting units 129
Tire speed rating 220, 355
Tire traction 220
TIREFIT 355
TIREFIT kit 289, 302, 308
TIREFIT kit 1
Instructions for use 302
TIREFIT kit 2
Instructions for use 308Tires 234, 348
Direction of rotation 235
Driving instructions 219
Messages in display 281
Retreads 234
Rims and tires 337
Rotating 238
Service life 235
SL 500 338
SL 55 AMG Kompressor 338
Temperature 236, 349
Tread depth 239
Wear pattern 238
Winter 239
Tools 288
Tow-away alarm 24, 77
Arming 77
Disarming 77
Disarming for transport 77
Tow-away alarm switch 24
Towing eye bolt (vehicle tool kit) 288
Installing 327
Towing the vehicle 325
Traction 141, 355
Transmission see Automatic transmission
Fluid level 230