2003 MERCEDES-BENZ ML320 Wheel bolt wrench

237 Practical hints
Where will I find ...?
Vehicle tool kit
The vehicle tool kit is stored in the cargo
area behind the right trim panel.
Turn handles1 90° in direction of ar-
rows.

Fold down the panel2.3Screw
4Vehicle jack with tool kit

Turn screw3 counterclockwise.

Remove vehicle jack.
Vehicles with CD-changer*
(page 238).
The jack is exclusively designed for lifting
the vehicle during a wheel change. Always
lower the vehicle on sufficient capacity
jackstands before working under the vehi-
cle.1Vehicle jack
2Wheel bolt wrench
3Screwdriver
4Interchangeable slot
Screwdriver3 is placed inside the wheel-
bolt wrench handle.

241 Practical hints
Where will I find ...?
4Wheel bolt
5Spare wheel
Unscrew the three wheel bolts using
the wrench (
page 237).

Take out the spare wheel.

Remove the electric air pump from its
holder (
page 238).
iAfter using the spare wheel, have it de-
flate at an authorized Mercedes-Benz
Light Truck Center. Store the deflated
spare wheel in its holder and tighten
the three wheel bolts with a tightening
torque of 37 ft.lb. (50 Nm).

256 Practical hintsFlat tire

On wheel to be changed, loosen but do
not yet remove the wheel bolts (ap-
proximately one full turn with wrench).
The jack take-up brackets are located di-
rectly behind the front wheel housings and
in front of the rear wheel housings.1Take-up bracket
2Jack

Place jack on firm ground.

Position jack2 under the take-up
bracket1 so that it is always vertical
(plumb-line) as seen from the side,
even if the vehicle is parked on an in-
cline.

Jack up the vehicle until the wheel is a
maximum of 1.2 in (3 cm) from the
ground. Never start engine while vehi-
cle is raised.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface. Make sure that the jack
arm is fully seated in the jack take-up brack-
et. Always lower the vehicle onto sufficient
capacity jackstands before working under
the vehicle.
!Do not position the jack on the body of
the vehicle, as this may cause damage
to the vehicle.

296 Technical termsRON
(R
esearch O
ctane N
umber)
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the ->MON (Motor Octane Number)
and RON (Research Octane Number) is
posted at the pump, also known as AN-
TI-KNOCK INDEX.
Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being moved out of positionP
without key turned and brake pedal de-
pressed.
SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and airbags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.Tele Aid System*
(T
elematic A
larm I
dentification on
D
emand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.
The Tele Aid system is operational pro-
viding that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.
Telematics*
A combination of the terms “telecom-
munications” and “informatics”.
Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.Tire speed rating
Part of tire designation; indicates the
speed range for which a tire is ap-
proved.
Traction
Force exerted by the vehicle on the
road via the tires.
Transfer case
Speed of rotation/torque converter
that works together with the ->auto-
matic transmission. In the LOW mode
off-road position, the transfer case de-
creases the output rotational speed of
the ->automatic transmission by ap-
proximately half. This results in a corre-
sponding increase of torque on the
drive axles.
The vehicle then has nearly double the
driving force but drives only approxi-
mately half as fast.

317 Index
Tilt
Head restraint 36
Time
Setting hours 112
Setting minutes 112
Tire inflation pressure
Checking 201, 211
Tire speed rating 184, 296
Tire traction 183
Tires 209, 279, 291
Direction of rotation 210
Driving instructions 182
Retreads 209
Rims and tires 279
Rotating 212
Service life 210
Temperature 211
Temperature grades 292
Tread depth 213
Wear pattern 212
Winter 213
Tools 237
Vehicle jack 237
Vehicles with CD-changer* 238
Wheel bolt wrench 237Tow-away alarm 29, 79
Arming 79
Disarming 79
Disarming for transport 79
Towing
Trailer 192
Towing a trailer 194
Automatic transmission 117
Towing eyes
Front 269
Rear 269
Towing the vehicle 267
Stranded vehicle 270
Tracking services
For stolen vehicle 168
Traction 291, 296
Trailer
Attaching 194
Loading 193
Towing 194
Trailer hitches 192
Trailer towing 192
Attaching a trailer 194
Checking weights 193
Electrical connections 192
Hitches 192Loading 193
Parking 196
Weights and ratings 193
Trailer weights and ratings 193
Transfer case 296
Transmission control – LOW RANGE
mode 118
Switching off 118
Switching on 118
Transmission selector lever 245
Unlocking manually 245
Tread depth (tires) 213
Treadwear 291
Trip computer
Average fuel consumption 175
Compass 173
Distance remaining 175
Selecting functions 172
Setting date 172
Stop watch 175
Switching on 172
Trip computer* 29, 172
Country 176
Language 176
Trip odometer
Resetting 112

319 Index
Vehicle lighting
Checking 201
Vehicle tool kit 237
Vehicle with CD-changer* 238
Vehicle washing 219
VIN (Vehicle Identification Number) 276,
297
Voice control system* 297
W
Warning indicators
Parktronic* 150
Warning sounds
Drivers seat belts 60
Parking brake 46
Warranty coverage 275
Washer fluid see Windshield washer fluid
Washing the vehicle 217
Wear pattern (tires) 212
Weights 283
Wheel bolt wrench 237
Wheel change
Tightening torque 258
Wheels
Rotating 212
Tires and wheels 209Window curtain airbags 59
Windows see Side windows
Windshield
Defogging 128
Refilling washer fluid 208
Replacing wiper blades 254
Washer fluid 208, 290
Washer system 290
Windshield washer fluid 290
Filler neck 208
Mixing ratio 290
Refilling 208
Wiping with 48
Windshield washer system 290
Windshield wipers 47, 122
Intermittent 47
Interval wiping 122
Normal wiper speed 47
Rain sensor* 122
Rear window wiper/washer 48
Replacing wiper blades 254
Simultaneous wiping and washing 48
Single wipe 48
Switching on 47
Wiping with windshield washer fluid 48Winter driving 213
Block heater 214
Snow chains 214
Tires 213
Winter tires 280
Winter driving instructions 184
Winter tires 213, 280
Wiper blades
Cleaning 220
Installing 254
Removing 254
Replacing 254
Wiper switch 47
Wiper/washer
Rear window 48
Wiping
And washing simultaneously 48
Intermittent 47, 122
With windshield washer fluid 48
Wiping and washing simultaneously 48
X
Xenon headlamps
Bi-Xenon 293