2003 MERCEDES-BENZ ML320 climate control

219 Operation
Vehicle care
Paintwork, painted body components
Mercedes-Benz approved Paint Care
should be applied when water drops on the
paint surface do not “bead up”, normally
every 3 to 5 months, depending on climate
and washing detergent used.
Mercedes-Benz approved Paint Cleaner
should be applied if the paint surface
shows signs of dirt embedding (i.e. loss of
gloss).
Do not apply any of these products or wax
if your vehicle is parked in the sun or if the
hood is still hot.
Use the appropriate MB-Touch-Up Stick
for quick and provisional repairs of minor
paint damage (i.e. chips from stones, vehi-
cle doors, etc.).Engine cleaning
Prior to cleaning the engine compartment,
make sure to protect electrical compo-
nents and connectors from the intrusion of
water and cleaning agents.
Corrosion protection, such as MB Anticor-
rosion Wax should be applied to the engine
compartment after every engine cleaning.
Before applying, all control linkage bush-
ings and joints should be lubricated. The
poly-V-belt and all pulleys should be pro-
tected from any wax.
Vehicle washing
Do not use hot water or wash your vehicle
in direct sunlight. Use only a mild car wash
detergent, such as Mercedes-Benz ap-
proved Car Shampoo.Thoroughly spray the vehicle with a dif-
fused jet of water. Direct only a very weak
spray towards the ventilation intake. Use
plenty of water and rinse the sponge and
chamois frequently.
Rinse with clear water and thoroughly dry
with a chamois. Do not allow cleaning
agents to dry on the finish.
Due to the width of the vehicle, fold in out-
side mirrors prior to running the vehicle
through an automatic car wash to prevent
damage to the mirrors.
In the winter, thoroughly remove all traces
of road salt as soon as possible.
When washing the underbody, do not for-
get to clean the inner sides of the wheels.

291 Technical data
Consumer information
Consumer information
This has been prepared as required of all
manufacturers of passenger cars under Ti-
tle 49, Code of U.S. Federal Regulations,
Part 575 pursuant to the “National Traffic
and Motor Vehicle Safety Act of 1966”.Uniform tire quality grading
Quality grades can be found, where appli-
cable, on the tire sidewall between tread
shoulder and maximum section width. For
example:
All passenger car tires must conform to
federal safety requirements in addition to
these grades.Tread wear
The tread wear grade is a comparative rat-
ing based on the wear rate of the tire when
tested under controlled conditions on a
specified government test course. For ex-
ample, a tire graded 150 would wear one
a nd one-ha lf (1 ½ ) tim es as wel l on the gov-
ernment course as a tire graded 100. The
relative performance of tires depends
upon the actual conditions of their use,
however, and may depart significantly
from the norm due to variations in driving
habits, service practices and differences in
road characteristics and climate.Traction
The traction grades, from highest to lowest
are AA, A, B, and C. Those grades repre-
sent the tire’s ability to stop on wet pave-
ment as measured under controlled
conditions on specified government test
surfaces of asphalt and concrete. A tire
marked C may have poor traction perfor-
mance.Tread wear
Traction
Temperature
200
AA
A
Warning!
G
The traction grade assigned to this tire is
based on straightahead braking traction
tests, and does not include acceleration,
cornering, hydroplaning, or peak traction
characteristics.

299 Index
A
ABS 25, 71, 293
ABS control 71
LOW RANGE mode 72
Malfunction indicator lamp 225
Warning lamp 225
Accelerator position, automatic
transmission 117
Accident
In case of 49
Activating
Air circulation mode 130
Air recirculation mode 129
Anti-theft alarm system 78
Automatic climate control 125
ESP 77
Exterior headlamps 46
Hazard warning flasher 106
Headlamps 46
High beams 102
Ignition 33
Immobilizer 51, 78
Rear passenger compartment
ventilation and climate control 131
Rear window defroster 131
Rear window wiper 48Residual heat 130
Seat heater 91
Tow-away alarm 80
Warning indicators (Parktronic*) 151
Windshield wipers 48
Activating automatic central locking 89
Adding
Coolant 206
Engine oil 204, 205
Additional turn signals 247
Adjustable steering column
Indicator lamp 229
Adjusting 34
Backrest tilt 36, 37
Exterior rear view mirror 38
Head restraint height 36, 37
Head restraint tilt 36, 37
Headlamp aim 253
Instrument cluster illumination 110
Manual seat 35
Mirrors 38
Power seats 37
Seat cushion tilt 37
Seat fore and aft 35
Seat fore and aft adjustment 37
Seat height 35, 36Seats 34
Steering wheel 37
Adjusting air distribution
Automatic climate control 127
Adjusting air volume
Automatic climate control 127
Air conditioner (cooling)
Turning on 129
Air conditioning
Cooling 129
Air conditioning refrigerant 286
Air outlets
Automatic climate control 132
Air pressure see Tire inflation pressure 211
Air pump 238
Air recirculation mode 128
Activating 129
Deactivating 129
AIRBAG OFF
Warning lamp 232
Airbags 55
BabySmart
TM airbag deactivation
system 293
BabySmartTM deactivation system 65
Children 56
Front 59

300 Index
Passenger 59
Safety guidelines 57
Side impact 59
Window curtain 59
Alarm
Audible 70, 79
Canceling 79
Visual 78
Alarm system
Anti-theft 78
Anticorrosion/antifreeze 288
Antiglare
Automatic 119
Antilock brake system (ABS) 293
Anti-theft alarm system
Arming 78
Canceling alarm 79
Disarming 79
Anti-theft systems
Anti-theft alarm system 78
Immobilizer 78
Tow-away alarm, glass breakage
sensor 79
Aquaplaning see Hydroplaning 183Armrest
Storage compartment in front of 153
Storage spaces 153
Armrest in rear seat bench 155
Ashtray
Front center console 156
Rear center console 157
At the gas station 200
ATF (automatic transmission fluid) 206
Attaching a trailer 194
Automatic antiglare for rear
view mirror 119
Automatic central locking
Activating 89
Deactivating 89
Automatic climate control 124
Adjusting air distribution 127
Adjusting air volume 127
Air conditioning 129
Air outlets 132
Air recirculation mode 128
Basic setting 127
Changing basic setting 127
Defrosting 128Economy mode 125
Rear passenger compartment 131
Rear window defroster 131
Residual heat utilization 130
Residual ventilation 130
Switching off 127
Switching on 126
Automatic headlamp mode 103
Automatic interior lighting control
Activating 107
Deactivating 107
Automatic locking when driving 89
Automatic transmission 113
Accelerator position 117
Emergency operation (Limp Home
Mode) 117
Gear ranges 114
Gear selector lever position 115
Gear shifting malfunctions 117
Kickdown 117
Manual shifting 113
One-touch gearshifting 113
Selector lever position 113
Towing a trailer 117
Transmission fluid 206

303 Index
Compass 173
Calibrating 174
Setting compass zone 174
Compass zone 174
Consumer information 291
Control and operation of radio
transmitters 197
Coolant 206, 287
Adding 206
Anticorrosion/antifreeze quantity 288
Checking level 206
Indicator lamp 230
Temperature 199
Temperature gauge 111
Coolant level
Checking 201, 206
Crossing obstacles 190
Cruise control 146, 293
Canceling 147
Driving downhill 147
Driving uphill 147
Fine adjustment 148
LOW RANGE mode 148
Saving current speed 147
Setting speeds 148Cruise control lever 146
Cup holder 154
Cleaning 221
In front seat armrest 155
In instrument panel 154
In rear centerconsole 155
Customer Assistance Center (CAC) 293
D
Daytime running lamp mode 103
Deactivating
Air conditioning (cooling) 129
Air recirculation mode 129
Alarm 79
Anti-theft alarm system 79
Automatic climate control 125, 127
Cruise control 147
Defrost 128
Engine 51
ESP 76
Front fog lamps, rear fog lamp 105
Hazard warning flasher 106
Headlamps 51
Immobilizer 78
Rear passenger compartment
ventilation and climate control 131Rear window defroster 131
Residual heat 130
Seat heater 91
Tow-away alarm 80
Tow-away alarm (vehicles with trip
computer*) 80
Tow-away alarm (vehicles without trip
computer) 81
Deactivating automatic central locking 89
Deep water see Standing water 185
Defogging
Windshield 128
Defrosting 128
Difficulties
While driving see Problems while
driving 49
With starting 45
Direction of rotation (tires) 210
Discharged battery
Jump starting 264
Disconnecting
Vehicle battery 261
Display
Engine oil level 204
Display in the speedometer 111

304 IndexDisplay messages
Error 235
Service indicator (FSS) 235
StArt 235
Displays
Service indicator 215
Distance remaining 175
Door entry lamps 107
Door unlock
With Tele Aid* 167
Doors
Opening from inside vehicle 86
Opening from outside 85
Downhill driving
Cruise control 147
Downshifting 113
Drink holder see Cup holder 155
Drinking and driving 179
Driving 40, 45
Abroad 197
General instructions 179
In winter 184
Problems 49
Safety systems 71
Through standing water 185
Driving abroad 197Driving instructions 179
Towing a trailer 194
Driving off 181
Driving safety systems
4-ETS 73
ABS 71
BAS 73
ESP 75
Driving systems 146
Cruise control 146
Driving safety systems 71
EBP 74
Parktronic* 149
Driving through water 189
E
Easy entry/exit feature* 95
EBP 74
Indicator lamp 229
Economy mode
Automatic climate control 125
Electric air pump 238
Electrical connections
Trailer 192
Electrical fuses 271
Electrical outlet 158Electrical system
Technical data 281
Electronic Brake Proportioning see EBP
Electronic Stability Program see ESP 25,
75
Electronic stability program see ESP 294
Electronic Traction System see 4-ETS 25
Emergency call system
Requirements 160
Emergency call system* 160
Emergency calls
Initiating an emergency call 163
With Tele Aid* 161
Emergency operation (Limp Home
Mode) 117
Emergency operations
Closing sliding/pop-up roof 246
Locking the vehicle 243
Opening sliding/pop-up roof 246
Remote door unlock 167
Unlocking the vehicle 242
Emergency tensioning device
see ETD 62, 294
Emission control 198
Emission control label 276

312 IndexPower windows
Blocking of rear door window
operation 69
Side windows 134
Synchronizing 136
Practical hints
First aid kit 236
Fuses 271
Lamps in instrument cluster 224
Spare wheel 239
Towing the vehicle 267
Vehicle jack 238
Vehicle tool kit 237
Premium unleaded gasoline 286
Problems
While driving 49
With vehicle 18
Product information 9
R
Radio transmitters, control and
operation 197
Rain sensor 122, 123
Rapid seat heating
Switching off 91
Switching on 91
Reading lamp 29Reading lamps 108
Rear automatic climate control 131
Adjusting air volume and air distribu-
tion manually 132
Automatic mode 132
Rear bench seat
Foldable 93
Rear door window
Blocking operation 69
Rear fog lamp 248
Bulb 248
Switching off 106
Switching on 105
Rear lamp bulbs
Replacing 251
Rear parking lamp
Replacing bulbs 251
Rear passenger compartment ventilation
and climate control
Activating 131
Deactivating 131
Rear passenger compartment ventilation
and rear automatic climate control 131
Rear quarter windows 136
Opening 136Rear quarter windows*
Closing 136
Rear seats 93
Easy entry/exit feature* 95
Enlarging cargo area 93
Folding down backrest 93
Folding up 94
Folding up backrest 94
Fore and aft 93
Lowering 94
Third row* 96
Rear standing lamp
Replacing bulbs 251
Rear towing eyes 269
Rear view mirror automatic antiglare 119
Rear view mirrors see Mirrors
Rear window defroster 131
Activating 131
Deactivating 131
Rear window wiper 123
Rain sensor* 123
Rear window wiper/washer 48
Reconnecting
Vehicle battery 262
Refrigerant
Air conditioning 286

316 IndexSwitching off
Automatic climate control 127
ESP 76
Front fog lamps 106
Hazard warning flasher 106
Headlamps 51
Rapid seat heating 91
Rear fog lamp 106
Transmission control – LOW RANGE
mode 118
Switching on
Automatic climate control 126
ESP 77
Front fog lamps 105
Front fog lamps, rear fog lamp 105
Hazard warning flasher 106
Headlamps 46
High beams 102
Rapid seat heating 91
Seat heating 91
Transmission control – LOW RANGE
mode 118
Trip computer 172
Windshield wipers 47Synchronizing
Power windows 136
Remote control 244
Sliding/pop-up roof 138
T
Tachometer 26, 112
Displaying gear range 114
Tail lamps 251
Cleaning 220
Replacing bulbs 248
Tar stains 218
Technical data 286
Brake fluid 286
Coolants 287
Electrical system 281
Engine 278
Engine oil 286
Engine oil additives 286
Fuel requirements 287
Gasoline additives 287
Main dimensions 282
Premium unleaded gasoline 286
Rims and tires 279
Weights 283
Windshield and headlamp washer sys-
tem 290Tele Aid
Information 165
Initiating an emergency call manually
163
Roadside assistance 163
Tele Aid System 160
Tele Aid System* 296
Tele Aid* 159
Emergency calls 161
Remote door unlock 167
Stolen vehicle tracking services 168
System self-check 160
Upgrade signals 166
Telematics* 296
Telephone* 158
Temperature
Grades of tires 292
Tires 211
Third row seats* 96
Folding down single seat 96
Installing single seat 98
Removing single seat 98
Storing single seat 97
Tie-down rings (Cargo compartment) 140
Tightening torque 296
Tightening torque (Wheel bolts) 258