2003 MERCEDES-BENZ ML320 ABS

253 Practical hints
Replacing bulbs

Insert reflector from the left so that it
engages on the right.

Position tabs of cover in slots and rein-
stall cover until properly seated.
Adjusting headlamp aim
VVertical centerline
HHeadlamp mounting high, measured
from the center Correct headlamp adjustment is extremely
important. To check and readjust a head-
lamp, follow the steps described:

Park the vehicle on a level surface
25 feet (7.6 m) from a vertical test
screen or wall.

Switch the headlamps on
(page 102).
If the beam does not show a beam pattern
as indicated in the figure left, then follow
the steps below:

Open hood (
page 202).
2Headlamp vertical adjustment screw
3Headlamp vertical adjustment screw

Always turn adjustment screws2
and3 simultaneously for vertical ad-
justment until the headlamp is adjust-
ed as shown1. Turn clockwise for
upward movement and counterclock-
wise for downward movement.
Graduations:
screw2:0.50° pitch
screw3:0.67° pitch
The left and right headlamps must be ad-
justed individually.
iHigh beam adjustments simultaneous-
ly aim the low beam.
Vehicle should have a normal trunk
load.
iIf it is not possible to obtain a proper
headlamp adjustment, have the system
checked at your authorized
Mercedes-Benz Light Truck Center.

286 Technical dataFuels, coolants, lubricants etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils recommended by
Mercedes-Benz. Information on recom-
mended brands is available in the Factory
Approved Service Products pamphlet, or at
your authorized Mercedes-Benz Light
Truck Center.Engine oil additives
Do not blend oil additives with engine oil.
They may be harmful to the engine opera-
tion.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air condition-
ing system.Never use R-12 (CFC) or mineral-based lu-
bricating oil, otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.
Therefore, the brake fluid must be re-
placed every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Center will pro-
vide you with additional information.
Premium unleaded gasoline
!To maintain the engine’s durability and
performance, premium unleaded gaso-
l i n e m u s t b e u s e d . I f p r e m i u m u n l e a d e d
is not available and low octane fuel is
used, follow these precautions:

Have the fuel tank only partially
filled with unleaded regular and fill
up with premium unleaded as soon
as possible.


Avoid full throttle driving and abrupt
acceleration.


Do not exceed an engine speed of
3000 rpm if the vehicle is loaded
with a light load such as two per-
sons and no luggage.


Do not exceed 2/3 of maximum ac-
celerator pedal position if the vehi-
cle is fully loaded or operating in
mountainous terrain.

293 Technical terms
ABS
(A
ntilock B
rake S
ystem)
Prevents the wheels from locking up
during braking so that the vehicle can
continue to be steered.
BabySmart
TM
airbag deactivation
system
This system detects if a special system
compatible child restraint seat is in-
stalled on the front passenger seat. The
system will automatically deactivate
the passenger front airbag when such a
seat is properly installed (indicator
lamp
7
in the instrument cluster
lights up). See your authorized
Mercedes-Benz Light Truck Center for
availability.
BabySmartTM
compatible child seats
Special restraint system for children.
The sensor system for the passenger
seat prevents deployment of the pas-
senger front airbag if a BabySmart
TM
compatible child seat is installed.BAS
(B
rake A
ssist S
ystem)
System for potentially reducing braking
distances in emergency braking situa-
tions. The system is activated when it
senses an emergency based on how
fast the brake is applied.
Bi-Xenon headlamps*
Headlamps which use an electric arc as
the light source and produce a more in-
tense light than filament headlamps.
Bi-Xenon headlamps produce low
beam and high beam.
CAC
(C
ustomer A
ssistance C
enter)
Mercedes-Benz customer service cen-
ter, which can help you with any ques-
tions about your vehicle and provide
assistance in the event of a break-
down.CAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control ve-
hicle functions such as door locking or
windshield wiping.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the passen-
ger compartment needed for vehicle
operation and monitoring.
Cruise control
Driving convenience system for auto-
matically maintaining the vehicle speed
set by the driver.
Engine number
The number set by the manufacturer
and placed on the cylinder block to
uniquely identify each engine pro-
duced.

299 Index
A
ABS 25, 71, 293
ABS control 71
LOW RANGE mode 72
Malfunction indicator lamp 225
Warning lamp 225
Accelerator position, automatic
transmission 117
Accident
In case of 49
Activating
Air circulation mode 130
Air recirculation mode 129
Anti-theft alarm system 78
Automatic climate control 125
ESP 77
Exterior headlamps 46
Hazard warning flasher 106
Headlamps 46
High beams 102
Ignition 33
Immobilizer 51, 78
Rear passenger compartment
ventilation and climate control 131
Rear window defroster 131
Rear window wiper 48Residual heat 130
Seat heater 91
Tow-away alarm 80
Warning indicators (Parktronic*) 151
Windshield wipers 48
Activating automatic central locking 89
Adding
Coolant 206
Engine oil 204, 205
Additional turn signals 247
Adjustable steering column
Indicator lamp 229
Adjusting 34
Backrest tilt 36, 37
Exterior rear view mirror 38
Head restraint height 36, 37
Head restraint tilt 36, 37
Headlamp aim 253
Instrument cluster illumination 110
Manual seat 35
Mirrors 38
Power seats 37
Seat cushion tilt 37
Seat fore and aft 35
Seat fore and aft adjustment 37
Seat height 35, 36Seats 34
Steering wheel 37
Adjusting air distribution
Automatic climate control 127
Adjusting air volume
Automatic climate control 127
Air conditioner (cooling)
Turning on 129
Air conditioning
Cooling 129
Air conditioning refrigerant 286
Air outlets
Automatic climate control 132
Air pressure see Tire inflation pressure 211
Air pump 238
Air recirculation mode 128
Activating 129
Deactivating 129
AIRBAG OFF
Warning lamp 232
Airbags 55
BabySmart
TM airbag deactivation
system 293
BabySmartTM deactivation system 65
Children 56
Front 59

300 Index
Passenger 59
Safety guidelines 57
Side impact 59
Window curtain 59
Alarm
Audible 70, 79
Canceling 79
Visual 78
Alarm system
Anti-theft 78
Anticorrosion/antifreeze 288
Antiglare
Automatic 119
Antilock brake system (ABS) 293
Anti-theft alarm system
Arming 78
Canceling alarm 79
Disarming 79
Anti-theft systems
Anti-theft alarm system 78
Immobilizer 78
Tow-away alarm, glass breakage
sensor 79
Aquaplaning see Hydroplaning 183Armrest
Storage compartment in front of 153
Storage spaces 153
Armrest in rear seat bench 155
Ashtray
Front center console 156
Rear center console 157
At the gas station 200
ATF (automatic transmission fluid) 206
Attaching a trailer 194
Automatic antiglare for rear
view mirror 119
Automatic central locking
Activating 89
Deactivating 89
Automatic climate control 124
Adjusting air distribution 127
Adjusting air volume 127
Air conditioning 129
Air outlets 132
Air recirculation mode 128
Basic setting 127
Changing basic setting 127
Defrosting 128Economy mode 125
Rear passenger compartment 131
Rear window defroster 131
Residual heat utilization 130
Residual ventilation 130
Switching off 127
Switching on 126
Automatic headlamp mode 103
Automatic interior lighting control
Activating 107
Deactivating 107
Automatic locking when driving 89
Automatic transmission 113
Accelerator position 117
Emergency operation (Limp Home
Mode) 117
Gear ranges 114
Gear selector lever position 115
Gear shifting malfunctions 117
Kickdown 117
Manual shifting 113
One-touch gearshifting 113
Selector lever position 113
Towing a trailer 117
Transmission fluid 206

304 IndexDisplay messages
Error 235
Service indicator (FSS) 235
StArt 235
Displays
Service indicator 215
Distance remaining 175
Door entry lamps 107
Door unlock
With Tele Aid* 167
Doors
Opening from inside vehicle 86
Opening from outside 85
Downhill driving
Cruise control 147
Downshifting 113
Drink holder see Cup holder 155
Drinking and driving 179
Driving 40, 45
Abroad 197
General instructions 179
In winter 184
Problems 49
Safety systems 71
Through standing water 185
Driving abroad 197Driving instructions 179
Towing a trailer 194
Driving off 181
Driving safety systems
4-ETS 73
ABS 71
BAS 73
ESP 75
Driving systems 146
Cruise control 146
Driving safety systems 71
EBP 74
Parktronic* 149
Driving through water 189
E
Easy entry/exit feature* 95
EBP 74
Indicator lamp 229
Economy mode
Automatic climate control 125
Electric air pump 238
Electrical connections
Trailer 192
Electrical fuses 271
Electrical outlet 158Electrical system
Technical data 281
Electronic Brake Proportioning see EBP
Electronic Stability Program see ESP 25,
75
Electronic stability program see ESP 294
Electronic Traction System see 4-ETS 25
Emergency call system
Requirements 160
Emergency call system* 160
Emergency calls
Initiating an emergency call 163
With Tele Aid* 161
Emergency operation (Limp Home
Mode) 117
Emergency operations
Closing sliding/pop-up roof 246
Locking the vehicle 243
Opening sliding/pop-up roof 246
Remote door unlock 167
Unlocking the vehicle 242
Emergency tensioning device
see ETD 62, 294
Emission control 198
Emission control label 276

308 IndexInterior lighting 107
Activating automatic control 107
Deactivating automatic control 107
Manual operation 108
Reading lamps 108
Interior storage spaces 152
Armrest 153
Cup holder 155
Glove box 152
Storage compartment in front of
armrest 153
Storage compartment under front
passenger seat* 152
Intermittent wiping 122
J
Jack 237, 238
Jump starting 264
K
Key
Global locking 85
Global unlocking 85
Loss of 86
Positions in steering lock 33
Remote control with folding key 84
Unlocking liftgate 85Unlocking the driver’s door, fuel filler
flap 85
Key positions in steering lock 33
Key, Mechanical 242
Key, Remote control
Unlocking with 32
Kickdown 117, 294
L
Labels, identification 276
Lamp bulbs, exterior 247
Lamps, exterior
Front 247
Rear 248
Lamps, indicator and warning
4-ETS 224, 226
ABS 225
Adjustable steering column 229
AIRBAG OFF 59, 232
BAS 73, 225, 226
Battery indicator lamp 233
Brake pad wear 234
Brakes 228
CHECK ENGINE 232
Coolant 230
EBP 229Engine diagnostics 232
ESP 224, 225, 226
Front fog lamps 229
Fuel reserve 233
Instrument cluster ??–233
Low engine oil level 229
LOW RANGE 226
Low washer system fluid level 234
Seat belts 234
Service indicator 215
SRS 54, 227
Turn signals 25
LATCH child seat anchors 68
LATCH child seat mounts 68
Layout of poly-V-belt drive 277
Leather upholstery
Cleaning 222
Lever
For cruise control 146
License plate lamps
Replacing bulbs 248, 252
Liftgate
Closing 88
Opening 85, 87
Opening from inside 87
Opening from outside 87

309 Index
Light alloy wheels
Cleaning 221
Lighter
Rear center console 157
Lighter see cigarette lighter 156
Lighting 102
Automatic headlamp mode 103
Cargo compartment 109
Combination switch 102
Daytime running lamp mode 103
Door entry lamps 107
Front fog lamps 105
High beam flasher 102
High beams 102
Instrument cluster illumination 110
Interior 107
Locator lighting 105
Low beam 102
Night security illumination 104
Parking lamps 102
Limiting the gear range 114
Limp Home Mode 117
Line of fall 294
Loading 139
Cargo area cover blind* 143
Cargo floor plates 144Cargo tie-down rings 140
Hooks 140
Instructions 139, 140
Partition net* 141
Roof rack 145
Split rear bench seat 93
Trailer 193
Locator lighting 105
Lock button 294
Locking 84
Automatic while driving 89
Centrally from inside 90
Fuel filler flap 200
Global 85
Vehicle in an emergency 243
Locking knobs 32
Loss of keys 86
Loss of Service and Warranty Information
Booklet 275
Low beam headlamps
Replacing bulbs 247, 249
Switching on 46
Low engine oil level
Indicator lamp 229
LOW RANGE - 4-ETS 74
LOW RANGE - ABS 72LOW RANGE - ESP 76
LOW RANGE mode 118
Low washer system fluid level
Indicator lamp 234
Lowering
Vehicle 258
M
Main dimensions 282
Maintenance 12
Display messages 235
Manual operations
Fuel filler flap 244
Interior lighting control 108
Locking the vehicle 243
Sliding/pop-up roof 246
Unlocking the driver’s door 242
Unlocking transmission selector
lever 245
Manual seat
Adjusting 35
Adjusting backrest tilt 36
Adjusting head restraint height 36
Adjusting head restraint tilt 36
Seat fore and aft adjustment 35
Seat height 35