2003 MERCEDES-BENZ E500 check engine

346 Practical hintsJump starting
Jump starting
If the battery is discharged, the engine can
be started with jumper cables and the bat-
tery of another vehicle. Observe the follow-
ing:

Jump starting should only be performed
when the engine and catalytic convert-
er are cold.


Do not start the engine if the battery is
frozen. Let the battery thaw out first.


Only jump start from batteries with the
same voltage rating.


Use only jumper cables with sufficient
cross-section, insulated terminal
clamps and polarity reversal protec-
tion.
Warning!
G
Failure to follow these directions will cause
damage to the electronic components, and
can lead to a battery explosion and severe
injury or death.
Never lean over batteries while connecting
or jump starting, you might get injured.
Battery fluid contains sulfuric acid. Do not
allow this fluid to come in contact with eyes,
skin or clothing. In case it does, immediately
flush affected area with water, and seek
medical help if necessary.
A battery will also produce hydrogen gas,
which is flammable and very explosive. Keep
flames or sparks away from battery, avoid
improper connection of jumper cables,
smoking etc.
Read all instructions before proceeding.
iJumper cables with polarity reversal
protection are available at any autho-
rized Mercedes-Benz Center.
!Jump starting may only be performed
on the main battery installed in the
trunk.
Avoid repeated and lengthy starting at-
tempts.
Do not attempt to start the engine us-
ing a battery quick charge unit.
If the engine does not run after several
unsuccessful starting attempts, have it
checked at the nearest authorized
Mercedes-Benz Center.
Excessive unburned fuel generated by
repeated failed starting attempts may
damage the catalytic converter.
Make sure the jumper cables do not
have loose or missing insulation.
Make sure the cable clamps do not
touch any other metal part while the
other end is still attached to a battery.

347 Practical hints
Jump starting
The battery is located in the trunk on the
right hand side underneath the luggage
box (
page 325). Only jump start the ve-
hicle from the battery in the trunk.

Make sure that the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift selector lever to positionP.1Positive terminal of charged battery
2Positive terminal of discharged battery
3Vehicle ground
4Negative terminal of charged battery

Connect positive terminals1 and2 of
the batteries with the jumper cables.
Clamp cable to charged battery1 first.

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect negative terminal4 of the
charged battery and vehicle ground3
(lock ring of the trunk lid lock) in the
trunk with the jumper cable. Clamp ca-
ble to charged battery4 first.

Start the engine of the disabled vehi-
cle.
Now you can again turn on the electrical
consumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
vehicle ground3 and negative
terminal4 and then from positive
terminals1 and2.

Have the battery checked at the next
authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 266).
iThe message
Malfunction - electric
consumers switched off
may appear
in the instrument cluster. It will disap-
pear as soon as the battery is suffi-
ciently charged.
!Vehicles with automatic transmission:
Do not tow-start the vehicle.

371 Technical data
Fuels, coolants, lubricants etc.
If the coolant level is low, water and MB
Anticorrosion /Antifreeze should be used
to bring it up to the proper level (have cool-
ing system checked for signs of leakage).
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz
Center.Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz 325.0 Anticorrosion/Anti-
freeze Agent.
Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Center for service.
Anticorrosion/antifreeze quantityModel
Approx. freeze protection– 35°F (– 37°C)
– 49°F (– 45°C)
E320
5.3 US qt (5.0 l)
5.9 US qt (5.5 l)
E500
6.0 US qt (5.65 l)
6.6 US qt (6.2 l)

382 IndexAIRMATIC DC (Dual Control) 209
Alarm
Audible 72, 82
Canceling 82
Visual 82
Alarm system
Anti-theft 82
Alignment bolt (vehicle tool kit) 340, 375
Antiglare
Automatic 157
Antilock brake system (ABS) 375
Anti-theft alarm system
Arming 82
Canceling alarm 82
Disarming 82
Anti-theft systems 81
Anti-theft alarm system 82
Immobilizer 81
Tow-away alarm 82
Ashtray 231
AUDIO menu 126
Selecting radio station 127
Automatic antiglare for rear view
mirror 157Automatic central locking
Activating/deactivating (control
system) 142
Automatic climate control
Temperature sensor 27
Automatic climate control* 172
Adjusting air distribution 177
Adjusting air volume 166, 177
Air recirculation mode 178
Defrosting 178
Rear window defroster 169, 180
Residual heat utilization 182
Residual ventilation 182
Setting the temperature 176
Automatic headlamp mode 113
Automatic lighting control
Activating 116
Deactivating 116
Automatic locking when driving 99
Automatic transmission 151
Accelerator position 156
Emergency operation (Limp Home
Mode) 156
Gear ranges 153Gear selector lever position 154
Gear shifting malfunctions 156
Kickdown 156
One-touch gearshifting 152
Program mode selector switch 155
Selector lever position 151
Starting the engine 43
Winter program mode 155
B
BabySmart
TM
Compatible child seats 375
Self-test 68
BabySmart
TM airbag deactivation
system 67, 375
Backrest
Folding forward 220
Folding rearward 221
BAS 74, 375
Messages in display 297, 298
Batteries, SmartKey
Changing 329
Check lamp 87
Checking 88

386 IndexDoors
Message in display 323
Opening from inside vehicle 93
Opening from outside 87, 91
Downhill driving
Cruise control 195
Downshifting 152
Driving
General instructions 40
Problems 48
Safety systems 73
With Distronic* 206
Driving hints
SBC brake system 79
Driving safety systems
ABS 73
BAS 74
ESP 75, 376
SBC brake system 77
Driving systems 194
AIRMATIC DC 209
Cruise control 194
Distronic* 197
Driving safety systems 73
Vehicle level control 209
DTR see Distronic* 376Dual control
AIRMATIC DC 209
E
Easy-entry/exit
Message in display 310
Easy-entry/exit feature* 102
Activating 143
Interrupting movement 102, 143
Electrical fuses 352
Electrical system 363
Electronic Stability Program see ESP 75,
376
Emergency call system* 235
Emergency calls
Initiating an emergency call 237
With Tele Aid* 236
Emergency operation (Limp Home
Mode) 156
Emergency operations
Releasing trunk lid from inside 97
Remote door unlock 241
Sliding/pop-up roof* or panorama slid-
ing/pop-up roof* 331
Unlocking the vehicle 327Emergency tensioning device 377
Emergency tensioning device see
ETD 377
Ending
A call (telephone) 149
Engine 360
Starting 43
Starting with KEYLESS-GO* 44
Starting with the key 44
Turning off with the key 52
Engine number 376
Engine oil
Adding 263
Additives 368
Checking level 262
Display messages 299, 300
Filler neck 263
Messages in display 264, 300
Viscosity 376
ESP 75, 376
Switching off 76
Switching on 77
Warning lamp 288
ETD 377
Safety guidelines 59
Exterior lamp switch 112

389 Index
Key, Mechanical 327
Key, SmartKey
Battery check lamp 87
Checking the batteries 88
Factory setting 87
Global locking 87
Global unlocking 87
Loss of 89
Positions in starter switch 31
Remote controls 86
Restoring to factory setting 87
Selective setting 87
Starting the engine 44
Turning off the engine 52
Unlocking the trunk lid 88
Unlocking with 30
Key, SmartKey with KEYLESS-GO*
Turning off the engine 53
KEYLESS-GO*
Activating ignition with 33
Closing side windows 92
Closing sliding/pop-up roof* 92
Factory setting 91
Global locking 91
Global unlocking 91
Important notes 90Locking the vehicle 92
Remote controls 89
Starting the engine 44
Turning off engine 53
Unlocking with 32
Unlocking, trunk lid 92
KEYLESS-GO* card
Messages in display 309
Keys 86
Kickdown 156, 377
Kilometers/miles in speedometer 134
Km/h or mph in speedometer 134
L
Lamp bulbs, exterior 332
Lamps, exterior
Front 332
Light sensor 313
Messages in display 313–??
Replacing bulbs for rear 333, 336
Lamps, indicator and warning
ABS 289
Airbag Off 61
Battery (SmartKey) 87
Brakes 291
Coolant 292
DTR* 199ESP 288
SBC 77
Seat belts 293
SRS 56
Language
Multifunction display 135
Setting 135
Layout of poly-V-belt drive 359
Level control system
AIRMATIC DC 209
Lever
Cruise control 201
License plate lamps 333
Messages in display 316
Replacing bulbs 336
Light sensor 313
Lighter see Cigarette lighter 232
Lighting 112
Automatic headlamp mode 113
Combination switch 115
Daytime running lamp mode 114
Door entry lamps 117
Exterior lamp switch 112
Front fog lamps 114
High beams 115
Instrument cluster illumination 118

396 IndexSteering column
Height adjustment 38
Length adjustment 38
Steering gear oil
Message in display 318
Steering wheel
Adjusting 37
Electrical adjustment 38
Height adjustment 38
Stolen vehicle
Tracking services 242
Stopping
Sliding/pop-up roof* 188
Windows 185
Storage compartments
Glove box 226
Storing (Memory function*)
Positions into memory 110
Submenus
Convenience 143
For settings 123
In control system 125
Instrument cluster 134, 136
Lighting 138
Resetting functions in Control
system 131Selecting 131
Settings menu 131
Vehicle 142
Sun visors 158
Supplemental Restraint System
(SRS) 379
Suspension tuning
For regular driving style 212
For sporty driving style 212
Switching off
Automatic central locking (control
system) 142
Engine 51
ESP 76
Hazard warning flasher 115
Headlamps 51
Switching on
Automatic central locking (control
system) 142
ESP 77
Front fog lamps 114
Hazard warning flasher 115
Headlamps 46
High beams 115
Rear fog lamp 114
Windshield wipers 47Symbol (Distronic*)
Distance warning function* 129
Synchronizing
Power windows 186
Sliding/pop-up roof* 189
T
Tachometer 120
Overspeed range 120
Tail lamps 333, 336
Tele Aid System 379
Tele Aid* 234
Emergency calls 236
Info services 242
Information 239
Initiating an emergency call
manually 237
Remote door unlock 241
Roadside assistance 238
SOS button 237
Stolen vehicle tracking services 242
System self-check 235
Tele Aid System 235
Upgrade signals 240
Telematics* 379
Telephone* 24, 233
Answering a call 148