2003 MERCEDES-BENZ CLK-CLASS transmission

254 Engine compartment
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index
Automatic transmission fluid level
The transmission has a permanent fill of automatic
transmission fluid.
Regular automatic transmission fluid level checks and
changes are not required. For this reason the dipstick is
omitted.
If you notice fluid leaks or gear shifting malfunctions,
have your authorized Mercedes-Benz Center check the
transmission fluid level.Coolant level
To check the coolant level, the vehicle must be parked
on level ground and the engine stopped.
Check coolant level only when coolant is cold.
The coolant level should reach the black top part of the
reservoir.
P20.30-2032-26
J_C208_II.book Seite 254 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com

273 Towing
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index We recommend that the vehicle be transported using
flat bed equipment. This method is preferable to other
types of towing.
The vehicle may be towed with all wheels on the ground
and the selector lever in position “N” for distances up to
30 miles (50 km) and at a speed not to exceed 30 mph
(50 km/h). The electronic key must be in steering lock
position 2.
To be certain to avoid a possibility of damage to the
transmission, however, we recommend the drive shaft
be disconnected at the rear axle drive flange for any
towing beyond a short tow to a nearby garage.
Do not tow with sling-type equipment. Towing with
sling-type equipment over bumpy roads will damage
radiator and supports.
Use wheel lift, dolly, or flat bed equipment, with
electronic key in steering lock turned to position 0.Note:
To signal turns while being towed with hazard warning
flasher in use, turn electronic key in steering lock to
position 2 and activate combination switch for left or
right turn signal in usual manner – only the selected
turn signal will operate.
Upon canceling the turn signal, the hazard warning
flasher will operate again.
Caution!
If the vehicle is towed with the front axle raised, the
engine must be shut off (electronic key in steering lock
position 0 or 1). Otherwise, the ESP will immediately be
engaged an d will app ly t he r ear wheel b rakes . Swi tch o f f
the tow-away alarm (see page 44) as well as the ESP (see
page 220).
Wa r n i n g !
With the engine not running, there is no power
assistance for the braking and steering systems. In
this case, it is important to keep in mind that a
considerably higher degree of effort is necessary to
brake and steer the vehicle.
J_C208_II.book Seite 273 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com

274 Towing
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hintsCar care Index
Transmission selector lever, manually unlocking
In the case of power failure the transmission selector
lever can be manually unlocked, e.g. to tow the vehicle.To do so, insert a pin (1), e.g. ball point pen, into the
covered opening below the position “D” of the shift
pattern. While pushing the pin down, move selector
lever from position “P”.
After removal of the pin from the opening, the cover will
not close fully. Only after moving the selector lever to
positions “D+” and “D–” does the cover return to its
closed position.
J_C208_II.book Seite 274 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com

305 Fuels, coolants, lubricants etc. - capacities
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index Fuels, coolants, lubricants etc. – capacities
Vehicle components and their respective lubricants must match. Therefore use only brands tested and recommended
by us. Please refer to the Factory Approved Service Products pamphlet, or inquire at your Mercedes-Benz Center.
Model Capacity Fuels, coolants, lubricants etc.
Engine with oil filter CLK 430
CLK 55 AMG8.5 US qt (8.0 l)
8.0 US qt (7.5 l)Recommended engine oils
Automatic transmission 9.6 US qt (9.1 l) Automatic transmission fluid
Rear axle 1.4 US qt (1.3 l) Hypoid gear oil SAE 90, 85 W 90
Power steering approx. 1.1 US qt (1.0 l) MB Power steering fluid
Front wheel hubs approx. 2.1 oz (60 g) each High temperature roller bearing grease
Brake system approx. 0.5 US qt (0.5 l) MB Brake fluid (DOT 4)
Windshield/headlamp
washer systemapprox. 7.4 US qt (7.0 l) MB Windshield washer concentrate “S”
1
Cooling system approx. 11.7 US qt (11.1 l) MB Anticorrosion/antifreeze1 Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and
commercially available premixed windshield washer solvent/antifreeze for temperatures below freezing. Follow suggested mixing ratios, see
Windshield/headlamp washer system on page 256.
J_C208_II.book Seite 305 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com

314 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
Basic setting .............................................................. 124
Defogging windows .................................................. 125
Defrosting ................................................................... 125
Display and controls ................................................. 124
Dust filter ................................................................... 128
Economy ..................................................................... 125
Rear window defroster ............................................. 126
Residual engine heat utilization (REST) ............... 127
Special settings ......................................................... 125
Automatic transmission ............................................... 193
Emergency Operation .............................................. 201
Fluid level ...................................................................254
Program mode selector switch ............................... 200
Selector lever position .............................................. 196
Transmission selector lever,
manually unlocking ............................................. 274
BBabySmart
TM airbag deactivation system ..................... 65
Self-test ......................................................................... 66
Backrest, front seat .......................................................... 54
BAS (Brake assist system) ............................................ 214
Malfunction indicator lamp ..................................... 229Battery ............................................................................ 268
Battery recycling ...................................................... 269
BATTERY/ALTERNATOR -
malfunction and warning messages ..................... 234
Block heater .................................................................... 211
BRAKE ASSIST - malfunction
and warning messages ............................................ 235
Brake assist system (BAS) ............................................ 214
Malfunction indicator lamp .................................... 229
Brake fluid .................................................... 204, 227, 307
Capacity ..................................................................... 305
BRAKE FLUID - malfunction
and warning messages ............................................ 236
BRAKE LINING WEAR - malfunction
and warning messages ............................................ 236
Brake pad wear .............................................................. 236
Brake warning lamp ..................................................... 227
Brake fluid low ......................................................... 227
Brakes .................................................... 202, 204, 214, 219
Bulbs
See Replacing bulbs ................................................. 275
J_C208_II.book Seite 314 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com

319 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
KKeys, changing battery ................................................. 283
Keys, vehicle ..................................................................... 24LLamps, exterior .............................................................. 275
Fog lamps ....................................................................116
Headlamp, adjusting ................................................280
Headlamps ...................... 116, 240, 241, 276, 280, 294
Low and high beam .......................................... 119, 277
Parking lamp ..................................................... 116, 277
Replacing bulbs ......................................................... 275
Side marker lamp, front ........................................... 279
Standing lamp ................................................... 116, 277
Taillamp assemblies ......................................... 116, 278
Turn signal lamp ............................................... 119, 277
Layout of poly-V-belt drive ............................................ 300
LIGHT SENSOR - malfunction
and warning messages ............................................ 241
Lighter ............................................................................. 159
LIGHTING SYSTEM - malfunction
and warning messages ............................................ 240
Limp home mode (Automatic transmission) ............. 201
Loading instructions ..................................................... 162Locking and unlocking .................................................... 29
Low engine coolant level warning .............................. 238
MMaintenance ................................................................... 177
Malfunction and indicator lamps
in the instrument cluster ........................................ 226
Malfunction and warning messages .......................... 232
ABS-SYSTEM ............................................................. 235
BATTERY/ALTERNATOR ......................................... 234
BRAKE ASSIST ......................................................... 235
BRAKE FLUID ........................................................... 236
BRAKE LINING WEAR ............................................ 236
COOLANT (coolant level) ........................................ 238
COOLANT TEMP.
(coolant temperature) ......................................... 239
DISPLAY DEFECTIVE
(engine control unit) ........................................... 233
DISPLAY DEFECTIVE
(several systems) ................................................. 233
ELEC. STABIL. PROGR. ............................................ 243
ENGINE FAN ............................................................. 237
ENGINE OIL LEVEL ................................................. 242
LIGHT SENSOR .......................................................... 241
LIGHTING SYSTEM .................................................. 240
J_C208_II.book Seite 319 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com

323 Index
Technical
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex TELE AID - malfunction and warning messages ...... 245
Telephone .......................................................................... 98
General notes ............................................................. 164
Incoming call ............................................................. 102
Redialing .................................................................... 100
Telephone book ........................................................... 98
Telephones and two-way radios ....................................176
Telescoping steering column
Adjusting ...................................................................... 79
Indicator lamp ...........................................................230
Telescoping steering column - malfunction
and warning messages ............................................ 241
The first 1 000 miles ..................................................... 177
Tire inflation pressure .................................................. 267
Tire traction .................................................................... 208
Tires ..................................................................................311
Driving instructions ................................................. 206
Rims and tires ...........................................................302
Rotating wheels ......................................................... 260
Tire inflation pressure ............................................. 267
Tire replacement ....................................................... 259
Winter driving instructions .................................... 209
Tool kit
See Vehicle tools ....................................................... 257Tow-away alarm ................................................................44
Towing the vehicle ........................................................ 272
Transmission .................................................................. 193
Transmission selector lever,
manually unlocking .................................................. 274
Traveling abroad ............................................................ 211
Trip computer ................................................................. 104
Trip odometer ................................................................... 89
Trunk .................................................................................37
Opening ........................................................................ 30
Release switch ............................................................. 40
Trunk lamp ....................................................................... 39
Trunk lid
Emergency release ................................................ 41, 42
Release switch ............................................................. 40
Turn signal failure ......................................................... 119
Turn signals .................................................................... 119
VVanity mirrors ................................................................ 153
Vehicle jack .................................................................... 258
Vehicle tools ................................................................... 257
J_C208_II.book Seite 323 Donnerstag, 31. Mai 2001 10:13 10
ProCarManuals.com