2003 MERCEDES-BENZ CL600 warning light

304 Practical hintsReplacing bulbsReplacing bulbs for front lamps
1Housing cover for high beam flasher
bulb, parking and standing lamp2Electrical connector for high beam
flasher housing bulb
3Parking and standing lamp
4Bulb socket for turn signal lamp
5Low beam and high beam (Bi-Xenon)
housing cover
High beam flasher bulb

Switch off the lights.

Open the hood (
page 237).

Press ends of housing cover1 tab to-
gether and remove cover.

Press connector2 downward.

Remove connector2 with the bulb.

Insert the new bulb so that the base lo-
cates in the recess on the holder.

From below, press connector2 with
bulb upward onto the reflector.

Align housing cover1 and click into
place.
Front turn signal bulb

Switch off the lights.

Open the hood (
page 237).

Twist bulb socket4 counterclockwise
and pull out.

Push bulb into socket, turn counter-
clockwise and remove.

Insert new bulb in socket, push in and
twist clockwise.

Reinsert bulb socket in lamp and twist
clockwise.
Warning!
G
Do not remove the cover for the Bi-Xenon
headlamp. Because of high voltage in xenon
lamps, it is dangerous to replace the bulb or
repair the lamp and its components. We rec-
ommend that you have such work done by a
qualified technician at an authorized Mer-
cedes-Benz Center.

311 Practical hints
Flat tire
Removing the wheel
1Alignment bolt
Unscrew upper-most wheel bolt and re-
move.

Replace this wheel bolt with alignment
bolt1 supplied in the tool kit.

Remove the remaining bolts.

Remove the wheel.Mounting the new wheel

Clean contact surfaces of wheel and
wheel hub.

Guide the spare wheel onto the align-
ment bolt and push it on.

Insert wheel bolts and tighten them
slightly.

Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.
!Do not place wheel bolts in sand or dirt.
This could result in damage to the bolt
and wheel hub threads.
!To avoid paint damage, place wheel flat
against hub and hold it there while in-
stalling first wheel bolt.Warning!
G
Always replace wheel bolts that are dam-
aged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be re-
paired immediately. Do not continue to drive
under these circumstances! Contact an au-
thorized Mercedes-Benz Center or call
Roadside Assistance.
Incorrect mounting bolts or improperly
tightened mounting bolts can cause the
wheel to come off. This could cause an acci-
dent. Make sure you are using the correct
mounting bolts.
Warning!
G
Use only genuine equipment
Mercedes-Benz wheel bolts. They are identi-
fied by the Mercedes star. Other wheel bolts
may come loose.
Do not tighten the wheel bolts when the ve-
hicle is raised. Otherwise the vehicle could
tip over.

317 Practical hints
Jump starting
The battery is located on the right side of
the trunk under the battery cover
(page 313).

Make sure that the two vehicles do not
touch.

Turn off all electrical consumers.

Apply parking brake.

Shift gear selector lever to positionP.

Open the trunk lid.

Remove battery cover.

Connect positive terminals 1 and3 of
the batteries with the jumper cable.
Clamp cable to charged battery3 first.1Positive terminal of discharged battery
2Negative terminal of discharged bat-
tery
3Positive terminal of charged battery
4Negative terminal of charged battery

Start engine of the vehicle with the
charged battery and run at idle speed.

Connect negative terminals 2 and4 of
the batteries with the jumper cable.
Clamp cable to charged battery4 first.

Start the engine of the disabled vehi-
cle.
You can now turn on the electrical con-
sumers. Do not turn on the lights under
any circumstances.

Remove the jumper cables first from
negative terminals2 and4 and then
from positive terminals1 and3.
You can now turn on the lights.

Have the battery checked at the near-
est authorized Mercedes-Benz Center.
Warning!
G
Keep flames or sparks away from battery.
Do not smoke.
Observe all safety instructions and precau-
tions when handling automotive batteries
(page 243).
!Never invert the terminal connections.
!Do not tow-start the vehicle.

347 Technical terms
ABC
(A
ctive B
ody C
ontrol)
Active, computer-controlled system
that hydraulically adjusts the suspen-
sion at all four wheels in response to
various driving situations.
ABS
(A
ntilock B
rake S
ystem)
Prevents the wheels from locking up
during braking so that the vehicle can
continue to be steered.
Alignment bolt
Metal pin with thread. The centering
pin is an aid used when changing a tire
to align the wheel with the wheel hub.BabySmart
TM
airbag deactivation
system
This system detects if a special system
compatible child restraint seat is in-
stalled on the front passenger seat. The
system will automatically deactivate
the passenger front airbag when such a
seat is properly installed (PASSENGER
AIRBAG OFF indicator lamp in the cen-
ter console lights up). See your autho-
rized Mercedes-Benz Center for
availability.
BabySmart
TM
compatible child seats
Special restraint system for children.
The sensor system for the passenger
seat prevents deployment of the pas-
senger side airbag if a BabySmart
TM
compatible child seat is installed.
BAS
(B
rake A
ssist S
ystem)
System for potentially reducing braking
distances in emergency braking situa-
tions. The system is activated when it
senses an emergency based on how
fast the brake is applied.Bi-Xenon headlamps
Headlamps which use an electric arc as
the light source and produce a more in-
tense light than filament headlamps.
Bi-Xenon headlamps produce low
beam and high beam.
CAC
(C
ustomer A
ssistance C
enter)
Mercedes-Benz customer service cen-
ter, which can help you with any ques-
tions about your vehicle and provide
assistance in the event of a break-
down.
CAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control ve-
hicle functions such as door locking or
windshield wiping.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the passen-
ger compartment needed for vehicle
operation and monitoring.

358 IndexCoolant 242
Adding 243
Checking level 242
Messages in display 277, 278
Temperature 234
Temperature gauge 115
Warning lamp 278
Coolant level 236
Checking 242
Courtesy lighting 113
Cruise control 176, 348
Canceling 177
Driving downhill 177
Driving uphill 177
Fine adjustment 178
Lever 183
Saving current speed 177
Setting speeds 178
Cruise control lever 176
Cup holder
Cleaning 260
Closing 204
In front seat armrest 202
In rear seat armrest 203
Opening 204
Customer Assistance Center (CAC) 347D
Daytime running lamp mode 110
Setting 136
Deactivating
Air conditioner (cooling) 166
Air recirculation mode 164
Alarm 77
Anti-theft alarm system 77
Automatic climate control 166
Central locking (control system) 139
Cruise control 177
Defrost 162
Distance warning function* 188
Distronic* 186
Engine with KEYLESS-GO* 51
Engine with the key 51
ESP 75
Exterior lamps 109
Hazard warning flasher 111
Headlamps 50
Immobilizer 76
Interior lighting delayed
switch-off 138
Rear window defroster 165
Residual heat 167
Seat heater 103, 104Seat ventilation* 102
Tow-away alarm 78
Deactivating steering wheel gearshift
control 150
Deceleration
With Distronic* 182
Deep water see Standing water 231
Defrosting 162
Delayed switch-off
Interior lighting 138
Dialing
A number (telephone) 126
Difficulties
While driving see Problems while
driving 48
With starting 44
Digital speedometer 122
Direction of rotation (tires) 247
Discharged battery
Jump starting 316
Disconnecting
Vehicle battery 314

364 IndexKEYLESS-GO* card 83
Central locking 84
Changing the batteries 299
Checking the batteries 82, 85
Checking vehicle lock status 86
Factory setting 84
Locking the vehicle 86
Loss of 87
Messages in display 276
Reprogramming 84
Restoring to factory setting 81
Turning off the engine 51
Unlocking 83
Unlocking with 32
Keys 80
Kickdown 148, 349
Kilometers/miles in speedometer 134
Km/h or mph in speedometer 134
L
Lamp bulbs, exterior 302
Lamps, exterior
Front 302
Light sensor 285
Messages in display 287
Rear 303Lamps, indicator and warning
ABS 265
Battery (SmartKey) 81
Brakes 267
CHECK ENGINE 268
Coolant 277
Distronic*
DTR* 181, 265
Engine diagnostics 268
ESP 75, 264
Fuel reserve 268
Instrument cluster 264–268
PASSENGER AIRBAG OFF 65, 269
Seat belts 266
Service indicator 254
SRS 55
Tow-away alarm 78
Turn signals 23
Language
Multifunction display 135
Setting 135
LATCH child seat anchors 68
LATCH child seat mounts 68
Layout of poly-V-belt drive 329
Leather upholstery
Cleaning 261Lever
For cruise control 183
License plate lamps
Replacing bulbs 303, 306
Light alloy wheels
Cleaning 260
Light sensor 285
Lighter see Cigarette lighter 207
Lighting 108
Automatic headlamp mode 109
Combination switch 111
Daytime running lamp mode 110
Exterior lamp switch 108
Front fog lamps 110
High beam flasher 111
High beams 111
Instrument cluster illumination 114
Interior 112
Locator lighting 110
Low beam 108
Manual headlamp mode 109
Night security illumination 110
Parking lamps 108
Rear fog lamp 110
Settings (control system) 135
Limiting the gear range 145

370 IndexS
Safety
Occupant 54
Safety belts see Seat belts 40
Safety defects
Reporting 18
Safety systems
Driving 71
Saving current speed 177
Screwdriver (vehicle tool kit) 295
Seat belt force limiter 63
Seat belts 60
Cleaning 261
Fastening 40
Proper use of 42, 62
Safety guidelines 58
Warning lamp 266
Seat cushion depth
Adjusting 99
Seat heater
Switching off 103
Switching on 103
Seat ventilation*
Switching off 102
Switching on 102Seats 96
Adjusting 34
Adjusting lumbar support 99
Adjusting shoulder support 99
Easy entry/exit feature 96
Heater 103
Massage function 100
Multicontour seat* 99
Securing cargo
Cargo tie-down hooks 198
Selector lever
Message in display 280
Position 143
Self-test
BabySmart
TM airbag deactivation
system 66
Tele Aid 210
Service
Calling up the service indicator 255
Major service (Service B) 254
Minor service (Service A) 254
Overdue 254
Types 254
When due 254
Service (maintenance) 254
Service and warranty information 10Service indicator 254
Calling up 255
Clearing 254, 255
Service life (tires) 247
Service System see FSS 254
Setting
Convenience functions 140
Cruise control 177
Daytime running lamp mode 136
Distronic* time interval 186
Exterior rear view mirror parking
position 142
Following distance in Distronic* 186
Higher speed in cruise control 178
Higher speed in Distronic* 184
Individual vehicle settings 131
Interior lighting delayed
switch-off 138
Lamps and lighting (control
system) 135
Language, multifunction display 135
Locator lighting 136
Lower speed in cruise control 178
Lower speed in Distronic* 185
Miles/kilometers in
speedometer 134

375 Index
Useful features 199
Ashtrays 206
Cigarette lighter 207
Garage door opener 217
Interior storage spaces 199
Tele Aid 209
Telephone* 208
V
Vehicle
Individual settings 131, 133
Locking 25
Locking in an emergency 298
Lowering 312
Proper use of 16
Service battery 313
Towing 318
Unlocking 25
Unlocking in an emergency 297
Vehicle battery 313
Vehicle care 256
Cup holder 260
Distronic* system sensor cover 259
Engine cleaning 257
Gear selector lever 260
Hard plastic trim items 260
Headlamps 258Instrument cluster 260
Leather upholstery 261
Light alloy wheels 260
Ornamental moldings 258
Paintwork 257
Parktronic* system sensor 259
Plastic and rubber parts 261
Power washer 257
Seat belts 261
Steering wheel 260
Tail lamps 258
Tar stains 257
Turn signals 258
Vehicle washing 258
Window cleaning 260
Wiper blades 259
Vehicle level 191
Changing 192
Setting 192
Automatic 192
Manual 192
Vehicle lighting
Checking 236
Vehicle lock status
Checking (KEYLESS-GO*) 86Vehicle tool kit 295
Alignment bolt 295
Fuse chart 295
Fuse extractor 295
Hex-socket wrench 295
Open-end wrench 295
Screwdriver 295
Spare fuses 295
Universal pliers 295
Wheel wrench 295
Vehicle washing 258
VIN (Vehicle Identification Number) 351
Voice control system* 351
Hands-free microphone 27
W
Warning indicators
Parktronic* 195
Warning lamps see Lamps, indicator and
warning
Warning sounds
Distance warning function* 187
Distronic* 181
Drivers seat belts 60
Parking brake 45
Warranty coverage 327
Washing the vehicle 256