2003 MERCEDES-BENZ CL55AMG torque

251 Operation
Tires and wheels
If you wish to cancel activation:
Press the
ç
button.
If the following message appears in the
multifunction display field:
REACTIVATE TIRE

PRES. MONITOR

or
TIRE PRES.

CHECK TIRES!


Check the tire inflation pressures and
correct them if necessary.

Reactivate the tire inflation pressure
monitor.
Rotating wheels
On vehicles with the same wheel size all
around, wheels can be rotated every 3000
to 6000 miles (5000 to 10 000 km), or
sooner if necessary, according to the de-
gree of tire wear. The same direction of tire
rotation must be retained.
Rotate the wheels before the characteris-
tic tire wear pattern becomes visible
(shoulder wear on front wheels and tread
center wear on rear wheels).
Thoroughly clean the inner side of the
wheels after each rotation. Check and en-
sure proper tire inflation pressure. It is
necessary to activate the tire inflation
pressure monitor*.Warning!
G
Rotate front and rear wheels only if they are
of the same size.
!If your vehicle is equipped with a tire in-
flation pressure monitor*, there are
electronic components built into the
wheel.
Do not use mounting tools in the area
of the valve as they could damage the
electronic components.
To prevent damage or incorrect instal-
lation, have the tires changed at an au-
thorized Mercedes-Benz Center.Warning!
G
Have the tightening torque checked after
changing a wheel. Wheels could become
loose if not tightened with a torque of
110 ft.lb. (150 Nm).
Use only genuine Mercedes-Benz wheel
bolts specified for your vehicle's rims.

312 Practical hintsFlat tireLowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.

Remove the jack.
1-5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of
110 ft lb (150 Nm).

Before storing the jack in the trunk, it
should be fully collapsed, with handle
folded in.

Place the wheel bolt wrench, alignment
bolt and jack back in the vehicle tool kit
in the trunk and close the covering lid.Replacing jack support tube cover

Slide tongue of cover under the upper
edge of the tube opening.

Applying even pressure, press cover
until it snaps into place. Be careful not
to damage the locking tabs or clamp
the plastic retaining strap.
Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
110 ft lb (150 Nm).
!You can also screw the faulty wheel
down into the spare wheel well in the
trunk.
Do not activate the tire inflation pres-
sure monitor* until the depressurized
tire is no longer in the vehicle.

330 Technical dataEngine
EngineModel
CL 500 (215.375)
1
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.
CL 55 AMG (215.374)
1
CL 600 (215.376)
1
Engine
113
113
275
Mode of operation
4-stroke engine, gasoline injec-
tion
4-stroke engine, gasoline injec-
tion
4-stroke engine, gasoline injec-
tion
No. of cylinders
8
8
12
Bore
3.82 in (97.00 mm)
3.82 in (97.00 mm)
3.23 in (82.00 mm)
Stroke
3.31 in (84.00 mm)
3.60 in (92.00 mm)
3.43 in (87.00 mm)
Total piston displacement
303.5 cu.in. (4966 cm
3)
331.8cu.in. (5439cm
3)
336.4 cu.in. (5513 cm
3)
Compression ratio
10:1
9:1
9:1
Output acc. to SAE J 1349
302 hp / 5500 rpm
(225 kW / 5500 rpm)
493 hp / 6100 rpm
(368 kW / 6100 rpm)
493 hp / 5000 rpm
(368 kW / 5000 rpm)
Maximum torque
acc. to SAE J 1349
339 ft.lb / 2700 rpm
(460 Nm / 2700 rpm)
517 ft.lb / 2750–4000 rpm
(700 Nm / 2750–4000 rpm)
590 ft.lb / 1800–3500 rpm
(800 Nm / 1800–3500 rpm)
Maximum engine speed
6000 rpm
6500 rpm
5950 rpm
Firing order
1-5-4-2-6-3-7-8
1-5-4-2-6-3-7-8
1-12-5-8-3-10-6-7-2-11-4-9
Poly-V-belt
7 ft 10 in (2390 mm)
Belt one: 4 ft 3 in (1289 mm)
Belt two: 8 ft 1 in (2462 mm)
7 ft 8 in (2335 mm)

334 Technical dataElectrical system
Electrical systemModel
CL 500
CL 55 AMG
CL 600
Generator (alternator)
14 V / 150 A
14 V / 180 A
14 V / 180 A
Starter motor
12 V / 1.7 kW
12 V / 1.8 kW
12 V / 1.7 kW
Battery
12 V / 95 Ah
12 V / 95 Ah
12 V / 95 Ah
Spark plugs
Bosch F 8 DPP332
NGK PFR 5 R-11
NGK ILFR 6 A
NGK NFR 6Q-G
Electrode gap
0.039 in (1.0 mm)
0.031 in (0.8 mm)
0.028 in (0.7 mm)
Tightening torque
15 – 22 ft.lb (20 – 30 Nm)
15 – 22 ft.lb (20 – 30 Nm)
15 – 22 ft.lb (20 – 30 Nm)

350 Technical termsMON
(M
otor O
ctane N
umber)
The Motor Octane Number for gasoline
as determined by a standardized meth-
od. It is an indication of a gasoline's
ability to resist undesired detonation
(knocking). The average of both the
MON (Motor Octane Number) and
->RON (Research Octane Number) is
posted at the pump, also known as AN-
TI-KNOCK INDEX.
Multifunction display
Display field in the speedometer used
to present information provided by the
control system.
Multifunction steering wheel
Steering wheel with buttons for operat-
ing the control system.
Overspeed range
Engine speeds within the red marking
of the tachometer dial. Avoid this en-
gine speed range, as it may result in se-
rious engine damage that is not
covered by the Mercedes-Benz Limited
Warranty.Parktronic*
System which uses visual and acoustic
signals to assist the driver during park-
ing maneuvers.
Poly-V-belt drive
Drives engine-components (alternator,
AC compressor, etc.) from the engine.
Power train
Collective term designating all compo-
nents used to generate and transmit
motive power to the drive axles, includ-
ing:


Engine


Clutch/torque converter


Transmission


Transfer case


Drive shaft


Differential


Axle shafts/axlesProgram mode selector switch
Used to switch the automatic transmis-
sion between sport operationS and
comfort operationC.
CL 55 AMG with steering wheel gear-
shift control and manual shift program:
in addition toS andC (see above), you
can use theM for manual operation.
Remote Vehicle Diagnostics
Transmission of vehicle data and cur-
rent location to the Mercedes-Benz
Customer Assistance Center for sub-
scribers to Tele Aid service.
REST
(Residual engine heat utilization)
Feature that uses the engine heat
stored in the coolant to heat the vehi-
cle interior for a short time after the en-
gine has been turned off.
Restraint systems
Seat belts, belt tensioners, airbags and
child restraint systems. As indepen-
dent systems, their protective func-
tions complement one another.

351 Technical terms
RON
(R
esearch O
ctane N
umber)
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the ->MON (Motor Octane Number)
and RON (Research Octane Number) is
posted at the pump, also known as AN-
TI-KNOCK INDEX.
Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being inadvertently moved out
of positionP without key turned and
brake pedal depressed.
Speedshift
Steering wheel gearshift control and
manual shift program. In the manual
shift program mode you can change
the gears yourself on the steering
wheel or by using the selector lever. SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and airbags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.
Tele Aid System
(T
elematic A
larm I
dentification on D
e-
mand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.
The Tele Aid system is operational pro-
viding that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.Telematics
A combination of the terms “telecom-
munications” and “informatics”.
Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.
Tire speed rating
Part of tire designation; indicates the
speed range for which a tire is ap-
proved.
Traction
Force exerted by the vehicle on the
road via the tires.
VIN
(V
ehicle I
dentification N
umber)
The number set by the manufacturer
and placed on the body to uniquely
identify each vehicle produced.
Voice control system*
Voice control system for car phones,
portable cell phones and audio sys-
tems (radio, CD, etc.).

373 Index
Switching off
Automatic central locking (control
system) 139
Engine 51
ESP 75
Hazard warning flasher 111
Headlamps 50
Switching on
Automatic central locking (control
system) 139
ESP 75
Front fog lamps 110
Front lamps 108
Hazard warning flasher 111
Headlamps 46
High beams 111
Parking lamps 108
Rear fog lamp 110
Windshield wipers 47
Symbol (Distronic*)
Distance warning function* 128
Synchronizing
Power windows 172
Sliding/pop-up roof 175T
Tachometer 23, 115
Overspeed range 115
Tail lamps
Cleaning 258
Replacing bulbs 303, 305
Tar stains 257
Tele Aid 209
Emergency calls 211
Information 214
Initiating an emergency call
manually 212
Messages in display 293
Remote door unlock 216
Roadside Assistance 213
Stolen vehicle tracking services 217
System self-check 210
Upgrade signals 215
Tele Aid System 351
Telematics* 351
Telephone* 24, 208
Answering a call 126
Dialing a number from the phone
book 126
Ending a call 126
Hands-free microphone 27Loading phone book* 126
Messages in display 294
Operating 125
Redialing 127
Temperature
Display mode 134
Setting interior temperature 160
Setting units in display 134
Tires 248
Tie-down hooks (Trunk) 198
Tightening torque 351
Tightening torque (Wheel bolts) 312
Tire inflation pressure
Checking 236, 247
Tire speed rating 229, 351
Tire traction 229
Tires 246, 345
Direction of rotation 247
Driving instructions 228
Messages in display 291
Retreads 246
Service life 247
Temperature 248
Tread depth 252
Wear pattern 251
Winter 252

376 IndexWear pattern (tires) 251
Weights 336
Wheel change
Tightening torque 312
Wheels
Rotating 251
Tires and wheels 246
Window curtain airbags 59
Windows see Side windows
Windshield
Refilling washer fluid 244
Replacing wiper blades 307
Washer fluid 244, 344
Windshield washer 236
Windshield washer fluid
Message in display 294
Refilling 244, 344
Wiping with 47Windshield wipers 47, 154
Fast wiper speed 47
Intermittent wiping 47
Replacing wiper blades 307
Single wipe 47
Switching on 47
Wiping with windshield washer
fluid 47
Winter driving 252
Block heater* 253
Snow chains 253
Tires 252
Transmission program
mode 147, 149
Winter driving instructions 230
Winter tires 252Wiper blades
Cleaning 259
Installing 307
Replacing 307
Wiping
And washing simultaneously 47
Interval 47
With windshield washer fluid 47
Wrench, hex-socket (vehicle tool kit) 295
Wrench, open-end (vehicle tool kit) 295
Wrench, wheel (vehicle tool kit) 295
X
Xenon headlamps
Bi-Xenon 347