2003 MERCEDES-BENZ C320 WAGON power steering

276 Practical hintsWhat to do if …Display
Possible cause
Suggested solution
<
DRIVER’S SEAT BELT
FASTEN SEAT BELT!
The display reminds you and your pas-
sengers to fasten seat belts.

Fasten the seat belts.
_
STEERING WHEEL ADJUST
LOCK!
The steering column is not properly
locked.

Lock the steering column properly
(page 37).
POWER STEERING FLUID
VISIT WORKSHOP!
The steering gear oil level is too low.
There is a danger of steering gear dam-
age.

Have the system checked by an au-
thorized Mercedes-Benz Center.
Warning!
G
If the level of steering gear oil in reservoir is
too low, the steering power assistance could
fail. Much greater effort will then be needed
to turn the steering wheel.
Do not add steering oil without checking the
steering system.
Do not drive the vehicle. Have the system
checked at your authorized Mercedes-Benz
Center as soon as possible.
S203 MY03_A.book Page 276 Tuesday, January 28, 2003 2:22 PM

311 Practical hints
Towing the vehicle
!To be certain to avoid a possibility of
damage to the drive train, however, we
recommend the drive shaft be discon-
nected at the rear axle drive flange
(vehicles with 4MATIC*: disconnected
at the front and rear axle drive flanges)
for any towing beyond a short tow to a
nearby garage.
Warning!
G
If circumstances require towing the vehicle
with all wheels on the ground, always tow
with a tow bar if:

the engine will not run


there is a malfunction in the power
supply or in the vehicle’s electrical
system
as that will be necessary to adequately
control the towed vehicle.
Prior to towing the vehicle with all wheels on
the ground, make certain that the key is in
starter switch position2.
If the key is left in starter switch position0
for an extended period of time, it can no
longer be turned in the switch. In this case,
the steering is locked. To unlock, remove
key from starter switch and reinsert.
iTo signal turns while being towed with
the hazard warning flasher in use, turn
key in starter switch to position2 and
activate the combination switch for the
left or right turn signal in the usual
manner – only the selected turn signal
will operate.
Upon canceling the turn signal, the
hazard warning flasher will operate
again.
S203 MY03_A.book Page 311 Tuesday, January 28, 2003 2:22 PM

321 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
C240, C320
1Idler pulley
2Automatic belt tensioner
3Power steering pump
4Air conditioner compressor
5Crankshaft
6Coolant pump, fan
7Generator (alternator)
S203 MY03_A.book Page 321 Tuesday, January 28, 2003 2:22 PM

328 Technical dataFuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.Capacities
Vehicle components and their respective lubricants must match. Therefore use only
brands tested and recommended by us.
Please refer to the Factory Approved Service Products pamphlet, or inquire at
your Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
C 240
C 320
C 240 4MATIC
C 320 4MATIC
7.9 US qt (7.5 l)
7.9 US qt (7.5 l)
7.4 US qt (7.0 l)
7.4 US qt (7.0 l)
Recommended engine oils
Automatic transmission
8.5 US qt (8.0 l)
MB Automatic Transmission Oil
1
1MB part no. 001 989 21 03 10Manual transmission
1.3 US qt (1.2 l)
MB Manual Transmission Oil
2
2MB part no. 001 989 26 03 10Rear axle
1.2 US qt (1.1 l)
Hypoid gear oil SAE 85 W 90
Front axle
C 240 4MATIC
C 320 4MATIC
0.5 US qt (0.46 l)
Hypoid gear oil SAE 85 W 90
Transfer case
C 240 4MATIC
C 320 4MATIC
approx. 0.62 US qt (0.59 l)
MB Automatic Transmission Oil
1
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid (Pentosin CHF 11S)
Front wheel hubs
approx. 2.1 oz (60 g) each
High temperature roller bearing grease
Brake system
0.5 US qt (0.5 l)
MB Brake Fluid (DOT 4+)
Cooling system
approx. 6.8 US qt (6.4 l)
MB 325.0 Anticorrosion/Antifreeze Agent
S203 MY03_A.book Page 328 Tuesday, January 28, 2003 2:22 PM

345 Index
A
ABS 23, 73, 339
ABS control 74
Malfunction indicator lamp 255
Messages in display 261
Warning lamp 255
Accelerator position, automatic
transmission 140
Accident
In case of 50
Activating
Air circulation mode 148
Air conditioning (cooling) 150, 159
Air recirculation mode 148, 156
Anti-theft alarm system 79
Automatic climate control 153
Central locking (control system) 125
Climate control 145
Defrost 147, 156
Easy-entry/exit feature 126
ESP 77
Exterior headlamps 47
Exterior lamps 99
Exterior rear view mirror parking
position 142
Hazard warning flasher 101Headlamps 47
High beams 101
Ignition 31
Immobilizer 52, 79
Rear fog lamp 99
Rear window defroster 149, 158
Residual heat 159
Seat heater 94
Tow-away alarm 80
Windshield wipers 48
Adding
Coolant 238
Engine oil 236
Additional turn signals 292
Adjustable air vents, rear passenger
compartment 151, 160
Adjusting 32
Air distribution 147, 155
Air volume 147, 155
Backrest tilt 33, 35
Exterior rear view mirror 39
Head restraint height 33, 35, 36
Head restraint tilt 34, 35, 36
Head restraints 36
Inside rear view mirror 38
Instrument cluster illumination 104Manual seat 33
Mirrors 38
Multicontour seat* 93
Power seat 34
Rear seat head restraints 35
Seat cushion depth 93
Seat cushion tilt 33, 35
Seat fore and aft adjustment 33, 34
Seat height 33, 35
Seats 32
Steering column height 38
Steering column length 38
Steering wheel 37
Air conditioning (cooling)
Turning off 150, 159
Turning on 150, 159
Air conditioning refrigerant 330
Air distribution
Adjusting 147, 155
Air pressure see Tire inflation
pressure 242
Air recirculation mode 148, 156
Activating 148, 156
Deactivating 148, 157
Air vents, rear passenger compartment
Adjustable 151, 160
S203 MY03_A.book Page 345 Tuesday, January 28, 2003 2:22 PM

367 Index
In an emergency 285
Selective settings 85
Transmission selector lever
manually 289
Vehicle in an emergency 217
With the SmartKey 30
Upgrade signals
Tele Aid* 216
Uphill driving
Cruise control 191
Upshifting 136
Useful features 203
Ashtrays 207
Cigarette lighter 208
Electrical outlet 208
Garage door opener 218
Interior storage spaces 203
Tele Aid* 210
Telephone* 209
V
Vehicle
Individual settings 116, 117
Locking 25
Locking in an emergency 286
Lowering 304
Performance in cold weather 333Performance in hot weather 333
Proper use of 16
Service battery 305
Towing 310
Unlocking 25
Unlocking in an emergency 285
With flexible fuel 329, 332
Vehicle battery 305
Vehicle care 248
Cup holder 251
Engine cleaning 250
Gear selector lever 251
Hard plastic trim items 252
Headlamps 250
Instrument cluster 251
Leather upholstery 252
Light alloy wheels 251
MB Tex upholstery 252
Ornamental moldings 250
Paintwork 249
Plastic and rubber parts 252
Power washer 249
Seat belts 252
Steering wheel 251
Tail lamps 250
Tar stains 249Turn signals 250
Vehicle washing 250
Window cleaning 251
Wiper blades 251
Vehicle jack 280
Vehicle lighting
Checking 233
Vehicle tool kit 279
Alignment bolt 280
Spare fuses 280
Special fuse puller 280
Towing eye bolt 280
Vehicle jack 280
Wheel bolts 280
Wheel wrench 280
Vehicle washing 250
Ventilated storage compartment 150
Ventilation
Storage compartment 150
VIN (Vehicle Identification Number) 343,
320
Viscosity
Engine oil 340
Voice control system*
Hands-free microphone 27
S203 MY03_A.book Page 367 Tuesday, January 28, 2003 2:22 PM