2003 MERCEDES-BENZ C320 4MATIC air conditioning

319 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
C 230 Kompressor Sport
1Power steering pump
2Idler pulley
3Mechanical loader
4Automatic belt tensioner
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)
C240 / C320 (all models)
1Idler pulley
2Automatic belt tensioner
3Power steering pump
4Air conditioning compressor
5Crankshaft
6Coolant pump, fan
7Generator (alternator)
C32AMG
1Idler pulley
2Idler pulley
3Supercharger
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump, fan
9Generator (alternator)

331 Technical data
Fuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Air conditioning system
R-134a refrigerant and special PAG lubricant
oil (never R-12)
Windshield washer system:
Without headlamp
cleaning system
With headlamp
cl eaning system*
3.2 US qt (3.0 l)
6.4 US qt (6.0 l)
MB Windshield Washer Concentrate
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent/antifreeze for temperatures below freezing. Follow suggested mixing ratios (
page 338).

332 Technical dataFuels, coolants, lubricants etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils recommended by
Mercedes-Benz. Information on
recommended brands is available in the
Factory Approved Service Products pam-
phlet, or at your authorized Mercedes-Benz
Center.
Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may be harmful to the engine opera-
tion.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air condition-
ing system.
Never use R-12 (CFC) or mineral-based
lubricating oil, otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.
Therefore, the brake fluid must be
replaced every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will
provide you with additional information.

347 Index
A
ABS 23, 73, 341
ABS control 74
Malfunction indicator lamp 257
Messages in display 262
Warning lamp 257
Accelerator position, automatic
transmission 143
Accident
In case of 50
Activating
Air conditioning (cooling) 154, 163
Air recirculation mode 152, 160
Anti-theft alarm system 79
Automatic climate control* 157
Central locking (control system) 129
Charcoal filter 161
Climate control 149
Climate control system 153
Defrosting 151
Easy-entry/exit feature* 129
ESP 77
Exterior headlamps 47
Exterior lamps 102
Exterior rear view mirror
parking position* 145Hazard warning flasher 104
Headlamps 47
High beams 104
Ignition 31
Immobilizer 53, 79
Rear fog lamp 102
Rear window defroster 153, 162
Residual heat 163
Seat heater* 97
Tow-away alarm 80
Windshield wipers 48
Adding
Coolant 239
Engine oil 237
Additional turn signals 290
Adjustable air vents, rear passenger
compartment 155, 164
Adjusting 32
Air distribution 151, 159
Air volume 151, 159
Backrest tilt 33, 35
Exterior rear view mirror 39
Head restraint height 33, 35, 37
Head restraint tilt 34, 35, 36
Head restraints 36
Inside rear view mirror 39Instrument cluster illumination 107
Manual seat 33
Mirrors 39
Multicontour seat* 96
Power seat* 34
Rear seat head restraints 35
Seat belt height 43
Seat cushion depth 96
Seat cushion tilt 33, 35
Seat fore and aft adjustment 33, 34
Seat height 33, 35
Seats 32, 33
Steering column height 37, 38
Steering column length 37, 38
Steering wheel 37
Air conditioner (cooling)
Turning off 154, 163
Turning on 154, 163
Air conditioning refrigerant 332
Air distribution
Adjusting 151, 159
Air pressure
see Tire inflation pressure 243
Air recirculation mode 152, 160
Activating 152, 160
Deactivating 152, 161

362 IndexProblems
While driving 49
With vehicle 17
Product information 9
Program mode selector switch 344
Automatic transmission 142
Q
Quick search
Phone book* 136
R
Radio
Selecting stations 117
Station search 117
Station selection setting 128
Radio mode 171
Radio see Radio mode
Radio transmitters, control and
operation 230
Range (distance to empty)
Calling up 133
Rapid seat heating*
Switching on 97
Reading lamp 27
Rear bench seat
Foldable* 199Rear door window
Blocking operation 71
Rear fog lamp 291
Bulb 291
Switching on 103
Rear lamp bulbs
Replacing 295
Rear lamps see Tail lamps
Rear outer seats
Adjusting head restraint height 37
Rear passenger compartment
Adjustable air vents 155, 164
Rear seat head restraints
Adjusting 35
Adjusting tilt 36
Folding back 36
Folding back with switch 36
Installing 95
Outer seats 95
Placing upright 36
Removing 95
Rear view mirror automatic
antiglare* 144
Rear view mirrors see Mirrors
Rear window defroster 153, 162
Rear window sunshade* 147Reconnecting
Vehicle battery 305
Refrigerant
Air conditioning 332
Regular checks 234
Reinstalling vehicle battery 304
Remote control
Integrated 218
SmartKey 84
Remote door unlock
With Tele Aid* 216
Remote Vehicle Diagnostics 344
Removing
Minispare wheel 283
Spare wheel 281
Vehicle battery 304
Vehicle tool kit 279
Wheel 299
Wiper blade insert 296
Wiper blades 296
Replacing
Backup lamp bulbs 295
Brake lamp bulbs 295
Bulbs 290
Front lamp bulbs 292
Front turn signal bulbs 292, 293