2003 MERCEDES-BENZ C240 Opening hood

108 Controls in detailInstrument clusterCoolant temperature display
Turn the SmartKey in the starter switch to
position1 or2.

Call up the trip odometer and main
odometer by pressing button
è

or
ÿ
on the multifunction steering
wheel (page 112).

Press button
j
or
k
until the
coolant temperature display appears.During severe operating conditions and
stop-and-go city traffic, the coolant tem-
perature may rise close to 248°F (120°C).
The engine should not be operated with
the coolant temperature above 248°F
(120°C). Doing so may cause serious en-
gine damage which is not covered by the
Mercedes-Benz Limited Warranty.
Warning!
G


Driving when your engine is badly over-
heated can cause some fluids which
may have leaked into the engine com-
partment to catch fire. You could be se-
riously burned.


Steam from an overheated engine can
cause serious burns and can occur just
by opening the engine hood. Stay away
from the engine if you see or hear steam
coming from it.
Turn off the engine, get out of the vehicle
and do not stand near the vehicle until it
cools down.
iExcessive coolant temperatures trigger
a warning in the multifunction display.

232 OperationDriving instructions
Coolant temperature
During severe operating conditions and
stop-and-go city traffic, the coolant tem-
perature may rise close to approx. 248°F
(120°C).
The engine should not be operated with
the coolant temperature over 248°F
(120°C). Doing so may cause serious en-
gine damage which is not covered by the
Mercedes-Benz Limited Warranty.
Warning!
G
Inhalation of exhaust gas is hazardous to
your health. All exhaust gas contains carbon
monoxide, and inhaling it can cause uncon-
sciousness and lead to death.
Do not run the engine in confined areas
(such as a garage) which are not properly
ventilated. If you think that exhaust gas
fumes are entering the vehicle while driving,
have the cause determined and corrected
immediately. If you must drive under these
conditions, drive only with at least one win-
dow fully open at all times.
Warning!
G


Driving when your engine is badly over-
heated can cause some fluids, which
may have leaked into the engine com-
partment, to catch fire. You could be se-
riously burned.


Steam from an overheated engine can
cause serious burns and can occur just
by opening the engine hood. Stay away
f r o m t h e e n g i n e i f y o u s e e o r h e a r s t e a m
coming from it.
Turn off the engine, get out of the vehicle
and do not stand near the vehicle until it
cools down.

234 OperationAt the gas station
Check regularly and before a long trip
1Coolant level
More information on the coolant level
can be found in the “Operation” section
(
page 238).
2Brake fluid (fuse box cover removed)
More information on brake fluid can be
found in the “Technical data” section
(page 332).
Removing fuse box cover
(page 312).
3Windshield washer and headlamp
cleaning system*
For more information on refilling the
reservoir, see the “Operation” section
(page 241).Engine oil level
More information on engine oil can be
found in the “Operation” section
(
page 236).
Opening hood (
page 235).
Coolant
For normal replenishing, use water (pota-
ble water quality). More information on
coolant can be found in the “Operation”
section (
page 238).
Vehicle lighting
Check function and cleanliness. For more
information on replacing light bulbs, see
the “Practical hints” section (
page 290).
Exterior lamp switch (
page 101).
Tire inflation pressure
More information on tire inflation pressure
can be found in the “Operation” section
(
page 243).
iUse only premium unleaded gasoline
with a minimum Posted Octane Rating
of 91 (average of 96 RON / 86 MON).
Information on gasoline quality can
normally be found on the fuel pump.
More information on gasoline can be
found in the Factory Approved Service
Products pamphlet.
Flexible Fuel Vehicles (MY 2003
Mercedes-Benz C 320 models, except
those equipped with manual transmis-
sion or 4MATIC*):
More information on Flexible Fuel Vehi-
cles can be found in the “Technical da-
ta” section (
page 334).
iLeaving the engine running and the fuel
cap open can cause the
?
lamp to
illuminate.
See also “Practical hints” section
(
page 259).

235 Operation
Engine compartment
Engine compartment
Hood
Opening
1Hood release
Pull lever1 downwards.
The hood is unlocked and handle2 will
extend out of the radiator grill. 2Handle for opening the hood

Pull handle2 to its stop out of radiator
grill.

Pull up on the hood (do not pull up on
the handle) and then release it.
The hood will be automatically held
open at shoulder height by gas-filled
struts.
Warning!
G
Do not pull the release lever while the vehi-
cle is in motion. Otherwise the hood could
be forced open by passing air flow.
!To avoid damage to the windshield wip-
ers or hood, never open the hood if the
wiper arms are folded forward away
from the windshield.
Warning!
G
To help prevent personal injury, stay clear of
moving parts when the hood is open and the
engine is running. Make sure the hood is
properly closed before driving. When closing
the hood, use extreme caution not to catch
hands or fingers.
The radiator fan may continue to run for ap-
proximately 30 seconds or even restart af-
ter the engine has been turned off. Stay
clear of fan blades.Warning!
G
If you see flames or smoke coming from the
engine compartment, or if the coolant tem-
perature gauge indicates that the engine is
overheated, do not open the hood. Move
away from vehicle and do not open the hood
until the engine has cooled. If necessary,
call the fire department.

239 Operation
Engine compartment
1Coolant expansion tank
Using a rag, turn the cap slowly approx-
imately one half turn to the left to re-
lease any excess pressure.

Continue turning the cap to the left and
remove it.The coolant level is correct if the level


for cold coolant: reaches the black
top part of the reservoir


for warm coolant: is approx. 0.6 in
(1.5 cm) higher

Add coolant as required.

Replace and tighten cap.
More information on coolant can be found
in the “Technical data” section
(
page 336).
Warning!
G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.


Do not remove pressure cap on coolant
reservoir if engine temperature is
above 194°F (90°C). Allow engine to
cool down before removing cap. The
coolant reservoir contains hot fluid and
is under pressure.


Using a rag, slowly open the cap approx-
imately
1/2 turn to relieve excess pres-
sure. If opened immediately, scalding
hot fluid and steam will be blown out un-
der pressure.


Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene gly-
col which may burn if it comes into con-
tact with hot engine parts.

267 Practical hints
What to do if …
During severe operating conditions and
stop-and-go city traffic, the coolant tem-
perature may rise close to 248°F (120°C).
Display
Possible cause
Suggested solution
Ï
COOLANT
STOP, ENGINE OFF!
The coolant is too hot.

Stop the vehicle and turn off the
engine.

Only start the engine again after the
message disappears. You could other-
wise damage the engine.
Warning!
G
Driving when your engine is badly overheat-
ed can cause some fluids which may have
leaked into the engine compartment to
catch fire. You could be seriously burned.
Steam from an overheated engine can cause
serious burns and can occur just by opening
the engine hood. Stay away from the engine
if you see or hear steam coming from it.
Turn off the engine, get out of the vehicle
and do not stand near the vehicle until it
cools down.
!The engine should not be operated with
the coolant temperature above 248°F
(120°C). Doing so may cause serious
engine damage which is not covered by
the Mercedes-Benz Limited Warranty.

353 Index
Driving
Driving abroad 230
General instructions 41, 223
Hydroplaning 227
In winter 228
Problems 49
Safety systems 73
Through standing water 229
Driving abroad 230
Driving instructions 223
Driving off 225
Driving safety systems
4MATIC 78
ABS 73
BAS 74
ESP 75
Driving systems 193
Cruise control 193
Driving safety systems 73
E
Easy-entry/exit feature* 93
Activating 129
Interrupting movement 93, 130
Electrical fuses 312
Electrical system
Technical data 326Electronic Stability Program
see ESP 23, 75, 342
Emergency call system* 210
Emergency calls
Initiating an emergency call 212
Telephone* 185
With Tele Aid* 211
Emergency operation
(Limp Home Mode) 143
Emergency operations
Closing sliding/pop-up roof* 289
Locking the vehicle 286
Opening sliding/pop-up roof* 289
Releasing trunk lid from inside 89
Remote door unlock 216
Unlocking the vehicle 285
Emergency tensioning device
see ETD 64, 342
Emission control 231
Emission control label 318
Ending
A call (telephone) 135
Engine 320
Compartment 235
Message in display 259Starting with automatic
transmission 44
Starting with manual
transmission 44
Starting with the key 44
Turning off with the key 53
Engine cleaning 250
Engine compartment 235
Fuse box in 312
Hood 235
Engine malfunction indicator
lamp 23, 259
Engine number 342
Engine oil 236, 332
Adding 237
Additives 332
Checking level 236
Consumption 236
Display messages 270
Filler neck 237
Messages in display 238, 270
Viscosity 342
Engine oil level see Oil level 234
ESP 23, 75, 342
Four wheel electronic traction
system with ESP 78

356 Index
Halogen-type
Replacing bulbs 292
Refilling washer fluid 241
Switching off 52
Switching on 47
Washer fluid 338
Headliner
Cleaning 252
Heated seats* 97
Height adjustment
Head restraints 33, 35, 37
Seat belts 43
Steering wheel 37
High beam flasher 47, 104
High beam headlamps
Messages in display 274
Replacing bulbs 290, 292
Switching on 104
High beam headlamps xenon type*
Replacing bulbs 293
High mounted brake lamp 291
Hood 235
Closing 236
Message in display 272
Opening 235
Hydroplaning 227I
Identification labels 318
Certification label 318
Vehicle identification
number (VIN) 318
Ignition 31
Switching on 44
Immobilizer 79
Activating 79
Deactivating 79
Indicator lamps
see Lamps, indicator and warning
Infant and child restraint systems 65
Installing 68
LATCH child seat anchors 69
Information
About service and warranty 10
Button for Tele Aid* 214
Inside rear view mirror
Adjusting 39
Antiglare 144
Installing
Infant and child restraint systems 68
Towing eye bolt 311
Wiper blades 296Instrument cluster 22, 107, 342
Cleaning 252
Coolant temperature display 108
Illumination 107
Lamps in 256–259
Multifunction display 111
Outside temperature indicator 110
Selecting language 124
Instrument lighting 107, 108
Instruments and controls see Cockpit 20
Integrated remote control
Canadian programming 219
Erasing memory 220
Hand-held transmitter 218
Operating 220
Rolling code programming 219
Interior lighting 105
Activating automatic control 105
Deactivating automatic control 105
Delayed shut-off 127
Manual operation 105
Interior storage spaces 203
Armrest 206
Cup holder 204, 205
Glove box 203