2003 MERCEDES-BENZ C230 COUPE air conditioning

157 Controls in detail
Automatic climate control* (Canada only)
Air conditioning
The air conditioning is operational while
the engine is running and cools the interior
air to the temperature set by the operator.
Deactivating
It is possible to deactivate the air condi-
tioning (cooling) function of the automatic
climate control system. The air in the vehi-
cle will then no longer be cooled or dehu-
midified.
Press buttonAC
OFF
(page 151).
The indicator lamp on the
buttonAC
OFF
lights up.Activating
Moist air can fog up the windows. You can
dehumidify the air with the air condition-
ing.

PressAC
OFF
again (
page 151).
The indicator lamp on the
buttonAC
OFF
goes out.
The air conditioning system uses the refrig-
erant R134a. This refrigerant is free of
CFCs which are harmful to the ozone layer.
Warning!
G
Any accumulation of snow and ice should be
removed from the rear window before driv-
ing. Visibility could otherwise be impaired,
endangering you and others.!If the rear window defroster switches
off too soon and the indicator lamp
starts blinking, this means that too
many electrical consumers are operat-
ing simultaneously and there is insuffi-
cient voltage in the battery. The system
responds automatically by deactivating
the rear window defroster.
As soon as the battery has sufficient
voltage, the rear window defroster au-
tomatically turns itself back on.
iCondensation may drip out from under-
neath the vehicle. This is normal and
not an indication of a malfunction.
!If the air conditioning cannot be turned
on again, this indicates that the air con-
ditioning system is losing refrigerant.
The compressor has turned itself off.
Have the air conditioning system
checked at the nearest authorized
Mercedes-Benz Center.

309 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
C230Kompressor
1Power steering pump
2Idler pulley
3Mechanical loader
4Automatic belt tensioner
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)
C320
1Idler pulley
2Automatic belt tensioner
3Power steering pump
4Air conditioning compressor
5Crankshaft
6Coolant pump
7Generator (alternator)

318 Technical dataFuels, coolants, lubricants etc.
Model
Capacity
Fuels, coolants, lubricants etc.
Fuel tank
including a reserve of
16.4 US gal (62.0 l)
2.1 US gal (8.0 l)
Premium unleaded gasoline:
Posted Octane 91 (Avg. of 96 RON / 86 MON)
Air conditioning system
R-134a refrigerant and special PAG lubricant oil (never R-12)
Windshield washer and
headlamp cleaning sys-
tem:
Without headlamp clean-
ing system
With headlamp cleaning
system
3.2 US qt (3 l)
6.4 US qt (6 l)
MB Windshield Washer Concentrate
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and commercially available pre-
mixed windshield washer solvent/antifreeze for temperatures below freezing. Follow suggested mixing ratios (
page 324).

319 Technical data
Fuels, coolants, lubricants etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils recommended by
Mercedes-Benz. Information on recom-
mended brands is available in the Factory
Approved Service Products pamphlet, or at
your authorized Mercedes-Benz Center.
Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may be harmful to the engine opera-
tion.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air condition-
ing system.
Never use R-12 (CFC) or mineral-based lu-
bricating oil, otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.
Therefore, the brake fluid must be re-
placed every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Center will pro-
vide you with additional information.

333 Index
A
ABS 23, 73, 327
ABS control 74
Malfunction indicator lamp 247
Messages in display 253
Warning lamp 247
Accelerator position, automatic transmis-
sion 137
Accident
In case of 50
Activating
Air conditioning (cooling) 148, 157
Air recirculation mode 146, 154
Anti-theft alarm system 78
Automatic climate control 151
Central locking (control system) 122
Climate control 143
Defrost 146, 154
Easy-entry/exit feature 123
ESP 77
Exterior headlamps 47
Exterior lamps 97
Hazard warning flasher 99
Headlamps 47
High beams 99
Ignition 31Immobilizer 53, 78
Rear fog lamp 97
Rear window defroster 147, 156
Residual heat 158
Seat heater* 92
Tow-away alarm 79
Windshield wipers 48
Adding
Coolant 230
Engine oil 228
Additional turn signals 280
Adjustable air outlets, rear passenger com-
partment 149, 158
Adjusting 32
Air distribution 145, 153
Air volume 145, 153
Backrest tilt 33, 35
Exterior rear view mirror 40
Head restraint height 33, 35, 37
Head restraint tilt 34, 35
Head restraints 37
Inside rear view mirror 39
Instrument cluster illumination 102
Manual seat 33
Mirrors 39
Rear seat head restraints 36Seat cushion tilt 33, 35
Seat fore and aft adjustment 33, 34
Seat height 33, 35
Seats 32
Steering column height 39
Steering column length 39
Steering wheel 37
Air conditioner (cooling)
Turning off 148, 157
Turning on 148, 157
Air conditioner refrigerant 319
Air distribution
Adjusting 145, 153
Air outlets, rear passenger compartment
Adjustable 149, 158
Air pressure see Tire inflation pressure 234
Air recirculation mode 146, 154
Activating 146, 154
Deactivating 147, 155
Air volume
Adjusting 145, 153
AIRBAG OFF indicator lamp 251
Airbags 57
BabySmart
TM airbag deactivation
system 327
BabySmartTM deactivation system 67

337 Index
Cockpit 20, 327
Cockpit management and data system
(COMAND*) 328
Collapsible tire 328
COMAND* 328
COMAND* see separate operating
instructions
Combination switch 99
High beam flasher 48, 99
Turn signals 47
Windshield wipers 48
Consumer information 325
Control and operation of
radio transmitters 222
Control system 105, 328
AUDIO menu 110
Convenience submenu 123
Display digital speedometer 110
Functions 106, 109
Instrument cluster submenu 116
Lighting submenu 119
Malfunction memory menu 112
Menus 108, 109, 329
Multifunction display 105
Multifunction steering wheel 106
NAV menu 112Selecting radio system 111
Settings menu 114
Standard display menu 110
Submenus 107, 109
TEL* menu 126
Trip computer menu 125
Vehicle submenu 122
Convenience submenu 123
Activating easy-entry/exit feature 123
Setting key dependency 124
Setting parking position for exterior
rear view mirror 124
Coolant 229, 321
Adding 230
Anticorrosion/antifreeze quantity 322
Capacities 317
Checking level 229
Messages in display 257, 258
Temperature 223
Temperature gauge 102
Warning lamp 258
Coolant level
Checking 225, 229
Cruise control 189, 328
Canceling 190
Driving downhill 190Driving uphill 190
Fine adjustment 191
Saving current speed 190
Setting speeds 191
Cruise control lever 189
Cup holder
Cleaning 243
In front seat armrest 196
Customer Assistance Center (CAC) 327
D
Daytime running lamp mode 98
Setting 119
Deactivating
Air conditioning (cooling) 148
Air recirculation mode 147, 155
Alarm 79
Anti-theft alarm system 79
Automatic climate control 151
Central locking (control system) 122
Climate control 143
Cruise control 190
Defrost 146, 154
Engine with the key 53
ESP 76
Exterior lamps 97
Exterior lamps delayed shut-off 120