2003 HONDA PILOT air condition

The following chart shows the
recommended cold tire pressures f or
most normal driving conditions and
speeds. Tire pressures f or high
speed driving are the same as f or
normal driving.
Thecompactsparetirepressureis:
If you check the pressure when the
tires are hot (the vehicle has been
driven several miles), you will see
readings 4 to 6 psi (30 to 40 kPa, 0.3
to 0.4 kgf/cm ) higher than the cold
reading. This is normal. Do not let
air out to match the specified cold
pressure. The tire will be
underinf lated.
Youshouldgetyourowntire
pressure gauge and use it whenever
you check your tire pressures. This
will make it easier f or you to tell if a
pressure loss is due to a tire problem
and not due to a variation between
gauges.
Use a gauge to measure the air
pressure at least once a month. Even
tires that are in good condition may
lose one to two psi (10 to 20 kPa, 0.1
to 0.2 kgf /cm ) per month.
Remember to check the spare tire at
thesametimeyoucheckallthe
other tires.
Check the pressure in the tires when
they are cold. This means the vehicle
has been parked f or at least three
hours. If you have to drive the
vehicle bef ore checking the tire
pressure, the tires can still be
considered ‘‘cold’’ if you drive less
than 1 mile (1.6 km).
Tire Size Cold Tire Pressure
for Normal Driving
CONT INUED
Recommended T ire Pressures f orNormal Driving
Tires
Maint enance309
P235/70R16 104S 32 psi (220 kPa , 2.2
kgf/cm
)
60 psi (420 kPa , 4.2 kgf/cm)

However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the
vehicle begins to slow down, and you
will have to press harder on the
pedal. The distance needed to stop
will be much longer. If it comes on at any other time, it
indicates a problem with the vehicle’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
f luid level is low, take the vehicle to
your dealer and have the brake
system inspected f or leaks or worn
brake pads.Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed, and repaired as
soon as possible. (See
on page .)
If you must drive the vehicle a short
distance in this condition, drive
slowly and cautiously.
The Brake System Indicator comes
on when you turn the ignition ON
(II). If the parking brake is not set, it
goes of f af ter you start the engine. If
the parking brake is set, it goes of f
when you f ully release the parking
brake with the engine running. 295
358Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed351
BRAKE SYSTEM INDICATOR
U. S. indicator shown

ÎÎ
Î
Î
µµ Î Î
Î
Î
Specif ications
T echnical Inf ormation362
Capacities
Dimensions
Weights
Air Conditioning Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid
Rear
differential
fluid
Windshield
washer
reservoir
1.74 US gal (6.6
, 1.45 Imp gal)
2.25 US gal (8.5, 1.87 Imp gal)
5.1 US qt (4.8
, 4.2 Imp qt)
4.5 US qt (4.3
, 3.8 Imp qt)
5.8 US qt (5.5
, 4.8 Imp qt)
3.2 US qt (3.0, 2.6 Imp qt)
8.2 US qt (7.8, 6.9 Imp qt)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
, 0.13 Imp gal)
Excluding the oil remaining in the engine. 19.3 US gal (73
, 16.1 Imp gal)
2.79 US qt (2.64
,2.32Impqt)
188.0 in (4,775 mm)
76.3 in (1,938 mm)
70.6 in (1,793 mm)
4.8 US qt (4.5
, 4.0 Imp qt)
66.3 in (1,685 mm)
66.5 in (1,690 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating
Gross combined weight
rating (GCWR)
See the tire information label atta-
ched to the driver’s doorjamb.
9,700 lbs (4,400 kg)
Refrigerant type
Charge quantity
Lubricant type HFC-134a (R-134a)
24.7 26.5 oz (700 750 g) ND-OIL8
106.3 in (2,700 mm)
Approx.
Front
Rear
1:
2:
Equipped with transmission fluid cooler and power steering fluid
cooler. Change
Total
Change
Including
filter
Without
filter
Total
Change
Total
Change
The GCWR must be reduced 2 percent for every 1,000 feet (305
meters) of elevation.
1:
2:
2 1
2
1

ÎÎ
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a Positive
Crankcase Ventilation System. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The Positive Crank- case Ventilation valve routes them
from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The Onboard Ref ueling Vapor
Recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
272
The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
T echnical Inf ormation
Emissions Cont rols
368

The exhaust emissions controls
include f our systems: PGM-FI,
Ignition Timing Control, Exhaust
Gas Recirculation and Three Way
Catalytic Converter. These four
systems work together to control the
engine’s combustion and minimize
the amount of HC, CO, and NOx that
comes out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual f or more informa-
tion.
The PGM-FI System uses sequential
multiport f uel injection.
It has three subsystems: Air Intake,
Engine Control, and Fuel Control.
The Powertrain Control Module
(PCM) uses various sensors to
determine how much air is going
into the engine. It then controls how
much f uel to inject under all operat-
ing conditions. This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO and NOx produced.
The Exhaust Gas Recirculation
(EGR) system takes some of the
exhaust gas and routes it back into
the intake manif old. Adding exhaust
gas to the air/f uel mixture reduces
the amount of NOx produced when
the f uel is burned.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), dinitrogen
(N ), and water vapor.
The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
genuine Honda replacement parts or
their equivalent f or repairs. Using
lowerqualitypartsmayincreasethe
emissions f rom your vehicle.
2
2
Exhaust Emissions Controls Replacement Parts
PGM-FI Syst emIgnit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em
Three Way Catalytic Converter
T echnical Inf ormation
Emissions Cont rols
369

CONT INUED
...
Accessories and Modif ications . 223
................................
Accessories .223
...
Additional Safety Precaution . 224
............................
Modif ications .224
ACCESSORY (Ignition Key .......................................
Position) .82
............
Accessory Power Sockets . 110
....................
Additives, Engine Oil . 284
...............................
Airbag (SRS) .9, 50
.....................
Air Cleaner Element .297
......
Air Conditioning System . 118,130
..............................
Maintenance .306
.....................
Rear A/C Control .135
.................................
Usage .118, 130
...............
Air Outlets (Vents) . 120,128
.......................
Air Pressure, Tires .308
.......................
Alcohol in Gasoline .366
.......
Aluminum Wheels, Cleaning . 327
......................................
Antif reeze .287
Anti-lock Brakes (ABS) ....................
Indicator Light .63, 243
...................................
Operation .242
..............
Anti-thef t, Audio System . 153
.
Anti-thef t Steering Column Lock . 81..........................
Appearance Care .325
................
Audio System . 137,153,168
...
Automatic Seat Belt Tensioners . 48
...
Automatic Lighting Off Feature . 73
.............
Automatic Speed Control . 207
..............
Automatic Transmission . 233
..........................
Capacity, Fluid .362
...............
Checking Fluid Level . 293
.......................................
Shif ting .234
.
Shif t Lever Position Indicator . 233
................
Shif t Lever Positions . 234
....................
Shif t Lock Release . 236
Battery Charging System ...........................
Indicator .62, 348
............................
Jump Starting .343
..............................
Maintenance .302
............................
Specif ications .363
..............................
Bef ore Driving .215
....................................
Belts,Seat .8,46
.........................
Beverage Holders .105
.................................
Body Repairs .332 Brakes
...........
Anti-lock System (ABS) . 242
.............
Break-in, New Linings . 216
...........................................
Fluid .295
....................
Bulb Replacement .320
.......................................
Parking .104
.................
System Indicator . 63,351
........................
Wear Indicators .241
.............................
Braking System .241
.................
Break-in, New Vehicle . 216
..
Brightness Control, Instruments . 73
........................
Brights, Headlights .72
Bulb Replacement ..........................
Back-up Lights .321
..............................
Brake Lights .320
......................
Cargo Area Light .323
................
Front Parking Lights . 318
........
Front Side Marker Lights . 319
.................................
Headlights .317
..............
Individual Map Lights . 322
...................
License Plate Light . 321
.................................
Rear Bulbs .320
............................
Specif ications .363
............
Turn Signal Lights . 318,320
..............................
Bulbs, Halogen .317
Index
A
B
I

CONT INUED
..........
DOT Tire Quality Grading . 364
.....................................
Drive Belts .307
...........
Driver and Passenger Safety . 5
...........................................
Driving .229
....................................
Economy .222
.........................
In Bad Weather .245
................
In Foreign Countries . 367
..................
Dust and Pollen Filter . 307
...................................
DVD Player .190
..............................
Economy, Fuel .222
............
Emergencies on the Road . 333
.............
Battery, Jump Starting . 343
...........
Brake System Indicator . 351
................
Changing a Flat Tire . 335
.....
Charging System Indicator . 348
..................
Checking the Fuses . 353
.....
Low Oil Pressure Indicator . 347
...
Malf unction Indicator Lamp . 349
..................
Overheated Engine . 345
.........................
Emergency Brake .104
......................
Emergency Flashers .76
......................
Emergency Towing .358
.......................
Emissions Controls .368 Engine
....
Coolant Temperature Gauge . 68
.................................
Drive Belts .307
Malf unction Indicator ................................
Lamp .62, 349
........
Oil Pressure Indicator . 62,347
..............
Oil, What Kind to Use . 283
...............................
Overheating .345
............................
Specif ications .363
............................
Speed Limiter .236
.......................................
Starting .232
......................
Ethanol in Gasoline .366
.
Evaporative Emissions Controls . 368
...............................
Exhaust Fumes .56
Exhaust Gas Recirculation ........................................
System .369
Expectant Mothers, Use of Seat ........................................
Belts by .19
..................
Exterior, Cleaning the . 326
............................
Fabric, Cleaning .329
..........................
Fan, Interior .118, 131
Features, Comfort and ..............................
Convenience .117 ....................
Filling the Fuel Tank . 217
Filters ...............................................
Air .297
.......................
Air Conditioning .306
...............................................
Oil .285
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 335
Fluids ..........
Automatic Transmission . 293
..........................................
Brake .295
..........................
Power Steering .296
..................
Windshield Washer . 292
FM Stereo Radio ...................................
Reception .176
...................
Folding the Third Seat . 95
.....
Foreign Countries, Driving in . 367
..........................
Four-way Flashers .76
.................................................
Fuel .216
......................
Fill Door and Cap .217
...........................................
Gauge .68
................
Octane Requirement . 216
...............................
Oxygenated .366
........................
Reserve Indicator .65
........................
Tank, Filling the .217
.....................
Fuses, Checking the .353
Index
E
F
III