2003 HONDA INSIGHT transmission

µ
µ If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do this:
With the f ront wheels on the ground,
it is best to tow the vehicle no farther
than 50 miles (80 km), and keep the
speedbelow35mph(55km/h).
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
Therearetwowaystotowyour
vehicle:
The tow
truck uses two pivoting arms that go
under the tires (f ront) and lif t them
of f the ground. The other two tires
remain on the ground. The operator
loads your vehicle on the back of a
truck. Start the engine.
Shif t to the D position and hold f or
5 seconds, then to N.
Turn of f the engine.
Release the parking brake.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.Wheel-lif t Equipment
Flat -bed Equipment
T his is an
acceptable way to tow your
vehicle. T his is the best way to
transport your vehicle.
Emergency T owing
374
Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine, your vehicle must be
transported with the f ront wheels of f
the ground.

The engine number is stamped into
the engine block.
The transmission number is on a
label on top of the transmission.
The IMA Motor Number is stamped
on the motor housing.
Identif ication Numbers
T echnical Inf ormation
379
ENGINE NUMBER
TRANSMISSION NUMBER IMA MOTOR NUMBER

Î
Î
Î
Î
Specif ications
380
Dimensions
Weights
Seating CapacitiesCapacities
Engine 172.3 in (4,377 mm)
66.7 in (1,695 mm)
56.2 in (1,427 mm)
100.4 in (2,550 mm)
58.3 in (1,481 mm)
58.0 in (1,472 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb. 3.4 US qt (3.2
)
3.2 US qt (3.0)
4.0 US qt (3.8)
Total
Front
Rear 5
2
3
Excluding the oil remaining in the engine Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 0.116 US gal (0.44
)
2.6 US qt (2.5
)
4.76 US qt (4.50)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid (CVTF)
Windshield
washer
reservoir
Type
BorexStroke
Displacement
Compression ratio
Spark plugs 10.8 : 1
82 cu-in (1,339 cm
)
2.87 x 3.15 in (73.0 x 80.0 mm) 3.0 US qt (2.8
)
5.5 US qt (5.2)
10.6 US gal (40
)
1.165 US gal (4.41)
1.295 US gal (4.90)
Water cooled 4-stroke SOHC i-VTEC gasoline engine with Hybrid Electric Motor
DILFR6J11
Front
Rear
Approx.
1:
2: Change
Total
Change
Including filter
Without filter
Total
Change
Total
U.S. Vehicles
Canada Vehicles
(NGK)
1
2

CONT INUED
BatteryCharging System ...........................
Indicator .63, 364
............................
Jump Starting .358
..............................
Maintenance .344
............................
Specif ications .381
..............................
Bef ore Driving .243
....................................
Belts,Seat .9,21
...........................
Beverage Holder .154
.......
Bluetooth
HandsFreeLink. 225
Brakes ...........
Anti-lock System (ABS) . 287
.............
Break-in, New Linings . 244
....................
Bulb Replacement .330
...........................................
Fluid .319
...................
Pad Wear Indicator . 286
.......................................
Parking .151
...........
System Indicator . 63,64,366
....................................
Accessories .254
ACCESSORY (Ignition Key .....................................
Position) .131
.............
Accessory Power Socket . 155
................
Active Head Restraints . 144
....................
Additives, Engine Oil . 311
.............................
Airbag (SRS) .10, 25
...
Airbags, Additional Information . 25
...
Additional Safety Precautions . 37
..........
AdvancedAirbagSystem . 30
.............................
Airbag Service .36
How the Passenger Airbag Of f ......................
Indicator Works .35
How the Side Airbag Of f ......................
Indicator Works .34
..
How the SRS Indicator Works . 34
How Your Front Airbags .........................................
Work .28
...
How Your Side Airbags Work . 32
How Your Side Curtain Airbags .........................................
Work .33
........................
SRS Components .25
..............
Air Conditioning System . 162
.......................
Air Pressure, Tires .339 ................................
Ambient Meter .72
......................................
Antif reeze .315
Anti-lock Brakes (ABS) ...............................
Indicator .64, 287
...................................
Operation .287
..............
Anti-thef t, Audio System . 219
Anti-thef t Steering Column ............................................
Lock .131
..........................................
Armrest .146
................................
Audio System .168
.......................
Auto Door Locking .109
...................
Auto Door Unlocking . 110
................................
Auto Idle Stop .281
...
Automatic Seat Belt Tensioners . 23
.............
Automatic Speed Control . 222
.
Automatic Transmission (CVT) . 271
..........................
Capacity,Fluid .380
...............
Checking Fluid Level . 318
Paddle Shif ters in the ..............................
D Position .276
Paddle Shif ters in the ...............................
S Position .279
.....
Recommended Shif t Points . 280
.......................................
Shif ting .272
Shif t Lever Position ...............................
Indicators .271 ................
Shif t Lever Positions . 273
....................
Shif t Lock Release . 275
......................
Auxiliary Input Jack .218
Index
A
B
INDEX
I

Index
.............................
Braking System .285
.................
Break-in, New Vehicle . 244
Brightness Control, ...............................
Instruments .124
Bulb Replacement ..........................
Back-up Lights .327
..............................
Brake Lights .330
........
Front Side Marker Lights . 326
.........
Front Turn Signal Lights . 325
.................................
Headlights .321
..........................
Parking Lights .324
..........
Rear Turn Signal Lights . 327
............................
Specif ications .381
..............................
Bulbs, Halogen .321 ...............
DANGER, Explanation of . iv
...................................
Dashboard .3, 60
..............
Daytime Running Lights . 123
............
Def ects, Reporting Saf ety . 396
..............
Def ogger, Rear Window . 126
......
Def rosting the Windows . 165,166
....................................
Dimensions .380
.............
Dimming the Headlights . 120
Dipstick ..........
Automatic Transmission . 318
..................................
Engine Oil .249
........................
Directional Signals .120
Disc Brake Pad Wear ...................................
Indicators .286
............................
Disc Player .173, 188
.....................
Disposal of Used Oil .314
..........................
Cargo Area Light .160
............................
Capacities Chart .380
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo .256
.............
CAUTION, Explanation of . iv
..................................
Ceiling Light .159
..............................
Center Pockets .157
...................................
Center Tray .156
........................
Certif ication Label .378 ............................................
Chains .342
....................
Changing a Flat Tire .349
Changing Oil ........................................
How to .312
......................................
When to .299
...
Charging System Indicator . 63,364
............
Checklist, Bef ore Driving . 262
.....................................
Child Saf ety .38
Child Seats .............
LATCH Anchor System . 47
.............................
Lower Anchor .47
............................
Tether Anchor .51
................
Childproof Door Locks . 134
.............................
Climate Control .162
.........................
Clock, Setting the .220
........................
CO in the Exhaust .387
............
Cold Weather, Starting in . 263
..............................
Compact Spare .348
.................
Console Compartment . 155
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .315
....................................
Checking .250
.........................
Proper Solution .315
...............
Temperature Indicator . 67Crankcase Emissions Control
........................................
System .387
............
Cruise Control Operation . 222
.........................
Customer Service .394
C D
II

CONT INUED
Doors...................
Auto Door Locking . 109
...............
Auto Door Unlocking . 110
............
Childproof Door Locks . 134
............
Locking and Unlocking . 133
..........
DOT Tire Quality Grading . 382
...........
Driver and Passenger Safety . 5
...........................................
Driving .261
....................................
Economy .251
..................
Dust and Pollen Filter . 332 ...................................
Fan, Interior .164
.........................................
Features .161
....................
Filling the Fuel Tank . 245
Filters .........................
Dust and Pollen .332
...............................................
Oil .313
...........
Flashers, Hazard Warning . 125
...................
Flat Tire, Changing a . 349
.....................................
Floor Mats .331
Fluids ..........
Automatic Transmission . 318
..........................................
Brake .319
..................
Windshield Washer . 317
FM Stereo Radio ...................................
Reception .212
........................
Four-way Flashers .125
............................
Front Airbags .10, 25
........................
Eco Assist System .264
................
Ecological Drive Display . 81
................................
ECON Button .127
..................................
ECON Mode .127
..............................
Economy, Fuel .251
............
Emergencies on the Road . 347
.............
Battery, Jump Starting . 358
.....
Brake System Indicator . 63,366
................
Changing a Flat Tire . 349
Charging System ...........................
Indicator .63, 364
..................
Checking the Fuses . 369Low Oil Pressure
...........................
Indicator .62, 363
Malf unction Indicator ................................
Lamp .62, 365
..................
Overheated Engine . 360
.........................
Emergency Brake .151
....................
Emergency Flashers .125
...........
Emergency Hatch Opener . 140
......................
Emergency Towing .374
.......................
Emissions Controls .387
........................
Emissions Testing .390
Engine ............
Adding Engine Coolant . 315
Coolant Temperature ...................................
Indicator .67
.........................
If It Won’t Start .356
Malf unction Indicator ................................
Lamp .62, 365
.........................
Oil Lif e Display .299
........
Oil Pressure Indicator . 62,363
..............
Oil, What Kind to Use . 310
...............................
Overheating .360
............................
Specif ications .380
............................
Speed Limiter .274
.......................................
Starting .263
.
Evaporative Emissions Controls . 387...............................
Exhaust Fumes .56
Expectant Mothers, Use of Seat ........................................
Belts by .19
Index
F
E
INDEX
III

.................................................
Fuel .244
......................
Fill Door and Cap .245
...........................................
Gauge .73
................
Octane Requirement . 244
...............................
Oxygenated .244
........................
Reserve Indicator .70
........................
Tank, Filling the .245
.....................
Fuses, Checking the .369
...............
Gas Mileage, Improving . 251
.........................................
Gasoline .244
...............
Fuel Reserve Indicator . 70
...........................................
Gauge .73
................
Octane Requirement . 244
........................
Tank, Filling the .245
................
Gas Station Procedures . 245
Gauges .............................
Charge/Assist .74
...............................................
Fuel .73
............
Gearshif t Lever Positions . 271
..........
Automatic Transmission . 271
......................................
Glove Box .156 .............
Halogen Headlight Bulbs . 321
...........................
HandsFreeLink
. 225
..............................................
Hatch .139
......................................
Opening .139
............................
Open Indicator .68
............
Hazard Warning Flashers . 125
Headlights ........................................
Aiming .321
.........
Daytime Running Lights . 123
..................
High Beam Indicator . 69
......................
Reminder Beeper .121
........
Replacing Halogen Bulbs . 321
.................................
Turning on .121
............................
Head Restraints .142
.............................
Heated Mirrors .148
.............
High Altitude, Starting at . 263
...............
High-Low Beam Switch . 120
...............
Hill Start Assist System . 295
.......................
Hood, Opening the .248
....................................................
Horn .4
...
Identif ication Number, Vehicle . 378Ignition
............................................
Keys .129
.........................................
Switch .131
............
Timing Control System . 388
IMA System Power Flow ........................................
Monitor .84
......................
Immobilizer System .130
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 62
...
Indicators, Messages (MID) . 62,89
...............
ABS (Anti-lock Brake) . 64
..............................
Auto Idle Stop .66
Brake (Parking and Brake ............................
System) .63, 366
.............................
Cruise Control .69
.................................
Cruise Main .69
................
Door/Hatch Open . 12,68
DRL (Daytime Running ....................................
Lights) .123
.
EPS (Electric Power Steering) . 68
................................
ECON Mode .71
...................................
High Beam .69
....
High Temperature (Coolant) . 67
......................
IMA Battery Level .85
.................................
IMA System .66
........
Key (Immobilizer System) . 63
Index
I H
G
IV

Index
INDEX
IX
Tires...........................................
Snow .342
............................
Specif ications .381
...................
Tools, Tire Changing . 350
Towing .....................................
A Trailer .296
..................
Emergency Towing . 374
Transmission Checking Fluid Level, ..............................
Automatic .318
...........................
Fluid Selection .319
..............
Identif ication Number . 379
.............
Shif ting the Automatic . 272
.....................................
Treadwear .340
.......................................
Trip Meter .79
..................................
Turn Signals .121
Unexpected, Taking Care ..........................................
of the .347
....
Unif orm Tire Quality Grading . 382
........................
Unleaded Gasoline .244
......................
USB Adapter Cable .205
.........
USB Flash Memory Device . 203
.......
Used Oil, How to Dispose of . 314................................
Vanity Mirror .158
.................
Vehicle Capacity Load . 257
......................
Vehicle Dimensions .380
....
Vehicle Identif ication Number . 378
Vehicle Stability Assist (VSA
)
....................................
System .293
.............
VSA OFF Indicator . 65,293
.........................
VSA Of f Switch .294
........
VSA System Indicator . 65,293
.............................
Vehicle Storage .346
.....................................
Ventilation .165
.................................................
VIN .378
..................................
Viscosity, Oil .311
............
WARNING, Explanation of . iv
.........
Warning Labels, Location of . 57
....................
Warranty Coverages .395
Washer, Windshield ........
Checking the Fluid Level . 317
...................................
Operation .119
Wheels .............
Adjusting the Steering . 128 ............
Alignment and Balance . 340
.....................................
Cleaning .343
..........................
Compact Spare .348
...............................
Nut Wrench .350
Windows .............................
Auto Reverse .150
................
Operating the Power . 149
.........................
Rear, Def ogger .126
Windshield .....................................
Cleaning .119
...................................
Def roster .166
.....................................
Washers .119
Wipers, Windshield .......................
Changing Blades .332
...................................
Operation .119
....................................
Worn Tires .339
.....
Wrecker, Emergency Towing . 374
W
U V