2003 HONDA INSIGHT automatic transmission

µµµ
µ
µ
Ì
µ
Youshouldcheckthefollowing
items at the specif ied intervals. If
you are unsure of how to perf orm
any check, turn to the appropriate
page listed.
Engine oil level Check every
time you fill the fuel tank. See
page .
Engine coolant level Check the
radiator reserve tank every time
youfillthefueltank.Seepage .
Automatic transmission Check
the f luid level monthly. See page .
Brakes Check the f luid level
monthly. See page .
Tires Check the tire pressure
monthly. Examine the tread f or
wear and foreign objects. See page .
U.S. Vehicles:
According to state and federal
regulations, f ailure to perf orm
maintenance on the items marked
with will not void your emissions
warranties. However, all
maintenance services should be
perf ormed in accordance with the
intervals indicated by the multi-
inf ormation display.
Lights Check the operation of
all the lights monthly. See page
.
249 250
318 319
338 321
CONT INUED
Owner’s Maintenance Checks
Maintenance Minder
Maint enance
307
TM

Fluid Locations
Maint enance
309
RADIATOR CAP
ENGINE OIL DIPSTICK
(Orange loop)
AUTOMATIC
TRANSMISSION (CVT)
FLUID DIPSTICK
(Yellow loop) BRAKE FLUID
(Black cap)
ENGINE OIL FILL CAP
ENGINE COOLANT
RESERVOIR
WASHER FLUID
(Blue cap)

Remove the dipstick and check
the f luid level. There is a HOT
side and a COLD side on the
dipstick. The f luid level should be
between the upper and lower
marks on the HOT side.
Remove the dipstick (yellow loop)
f rom the transmission, and wipe it
with a clean cloth.
Insert the dipstick all the way into
the transmission securely as
shown in the illustration.
Check the f luid level with the engine
at normal operating temperature.
Park the vehicle on level ground.
Start the engine, let it run until the
radiator f an comes on, then shut
of f the engine. For accurate
results, wait about 60 seconds (but
no longer than 90 seconds) bef ore
doing step 2.
3. 4.
2.
1. Continuously Variable
T ransmission (CVT )
Automatic Transmission Fluid
318
DIPSTICK
HOT
Range
UPPER
MARK
LOWER
MARK

CONT INUED
Check the brake f luid level in the
reservoirs monthly.
You will also see the ‘‘BRAKE
FLUID LOW’’ message on the multi-
inf ormation display when the brake
f luid level is low.
Insert the dipstick all the way back
into the transmission securely.
The transmission should be drained
and ref illed with new f luid when this
service is indicated by a maintenance
message on the multi-inf ormation
display.
If you are not sure how to add f luid,
contact your dealer.
If the level is below the lower
mark, add f luid into the dipstick
hole to bring it to the level
between the upper and lower
marks.
Pour the f luid slowly and caref ully
so you do not spill any. Clean up
any spill immediately; it could
damage components in the engine
compartment.
Always use Honda CVTF
(continuously variable
transmission f luid).
Independent of the Maintenance
Minder inf ormation, replace the
brake f luid every 3 years.
6.
5.
Automatic Transmission Fluid, Brake Fluid
Brake Fluid
Maint enance
319

Î
Î
Î
Î
Specif ications
380
Dimensions
Weights
Seating CapacitiesCapacities
Engine 172.3 in (4,377 mm)
66.7 in (1,695 mm)
56.2 in (1,427 mm)
100.4 in (2,550 mm)
58.3 in (1,481 mm)
58.0 in (1,472 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb. 3.4 US qt (3.2
)
3.2 US qt (3.0)
4.0 US qt (3.8)
Total
Front
Rear 5
2
3
Excluding the oil remaining in the engine Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 0.116 US gal (0.44
)
2.6 US qt (2.5
)
4.76 US qt (4.50)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid (CVTF)
Windshield
washer
reservoir
Type
BorexStroke
Displacement
Compression ratio
Spark plugs 10.8 : 1
82 cu-in (1,339 cm
)
2.87 x 3.15 in (73.0 x 80.0 mm) 3.0 US qt (2.8
)
5.5 US qt (5.2)
10.6 US gal (40
)
1.165 US gal (4.41)
1.295 US gal (4.90)
Water cooled 4-stroke SOHC i-VTEC gasoline engine with Hybrid Electric Motor
DILFR6J11
Front
Rear
Approx.
1:
2: Change
Total
Change
Including filter
Without filter
Total
Change
Total
U.S. Vehicles
Canada Vehicles
(NGK)
1
2

CONT INUED
BatteryCharging System ...........................
Indicator .63, 364
............................
Jump Starting .358
..............................
Maintenance .344
............................
Specif ications .381
..............................
Bef ore Driving .243
....................................
Belts,Seat .9,21
...........................
Beverage Holder .154
.......
Bluetooth
HandsFreeLink. 225
Brakes ...........
Anti-lock System (ABS) . 287
.............
Break-in, New Linings . 244
....................
Bulb Replacement .330
...........................................
Fluid .319
...................
Pad Wear Indicator . 286
.......................................
Parking .151
...........
System Indicator . 63,64,366
....................................
Accessories .254
ACCESSORY (Ignition Key .....................................
Position) .131
.............
Accessory Power Socket . 155
................
Active Head Restraints . 144
....................
Additives, Engine Oil . 311
.............................
Airbag (SRS) .10, 25
...
Airbags, Additional Information . 25
...
Additional Safety Precautions . 37
..........
AdvancedAirbagSystem . 30
.............................
Airbag Service .36
How the Passenger Airbag Of f ......................
Indicator Works .35
How the Side Airbag Of f ......................
Indicator Works .34
..
How the SRS Indicator Works . 34
How Your Front Airbags .........................................
Work .28
...
How Your Side Airbags Work . 32
How Your Side Curtain Airbags .........................................
Work .33
........................
SRS Components .25
..............
Air Conditioning System . 162
.......................
Air Pressure, Tires .339 ................................
Ambient Meter .72
......................................
Antif reeze .315
Anti-lock Brakes (ABS) ...............................
Indicator .64, 287
...................................
Operation .287
..............
Anti-thef t, Audio System . 219
Anti-thef t Steering Column ............................................
Lock .131
..........................................
Armrest .146
................................
Audio System .168
.......................
Auto Door Locking .109
...................
Auto Door Unlocking . 110
................................
Auto Idle Stop .281
...
Automatic Seat Belt Tensioners . 23
.............
Automatic Speed Control . 222
.
Automatic Transmission (CVT) . 271
..........................
Capacity,Fluid .380
...............
Checking Fluid Level . 318
Paddle Shif ters in the ..............................
D Position .276
Paddle Shif ters in the ...............................
S Position .279
.....
Recommended Shif t Points . 280
.......................................
Shif ting .272
Shif t Lever Position ...............................
Indicators .271 ................
Shif t Lever Positions . 273
....................
Shif t Lock Release . 275
......................
Auxiliary Input Jack .218
Index
A
B
INDEX
I

Index
.............................
Braking System .285
.................
Break-in, New Vehicle . 244
Brightness Control, ...............................
Instruments .124
Bulb Replacement ..........................
Back-up Lights .327
..............................
Brake Lights .330
........
Front Side Marker Lights . 326
.........
Front Turn Signal Lights . 325
.................................
Headlights .321
..........................
Parking Lights .324
..........
Rear Turn Signal Lights . 327
............................
Specif ications .381
..............................
Bulbs, Halogen .321 ...............
DANGER, Explanation of . iv
...................................
Dashboard .3, 60
..............
Daytime Running Lights . 123
............
Def ects, Reporting Saf ety . 396
..............
Def ogger, Rear Window . 126
......
Def rosting the Windows . 165,166
....................................
Dimensions .380
.............
Dimming the Headlights . 120
Dipstick ..........
Automatic Transmission . 318
..................................
Engine Oil .249
........................
Directional Signals .120
Disc Brake Pad Wear ...................................
Indicators .286
............................
Disc Player .173, 188
.....................
Disposal of Used Oil .314
..........................
Cargo Area Light .160
............................
Capacities Chart .380
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo .256
.............
CAUTION, Explanation of . iv
..................................
Ceiling Light .159
..............................
Center Pockets .157
...................................
Center Tray .156
........................
Certif ication Label .378 ............................................
Chains .342
....................
Changing a Flat Tire .349
Changing Oil ........................................
How to .312
......................................
When to .299
...
Charging System Indicator . 63,364
............
Checklist, Bef ore Driving . 262
.....................................
Child Saf ety .38
Child Seats .............
LATCH Anchor System . 47
.............................
Lower Anchor .47
............................
Tether Anchor .51
................
Childproof Door Locks . 134
.............................
Climate Control .162
.........................
Clock, Setting the .220
........................
CO in the Exhaust .387
............
Cold Weather, Starting in . 263
..............................
Compact Spare .348
.................
Console Compartment . 155
.............
Controls, Instruments and . 59
Coolant ........................................
Adding .315
....................................
Checking .250
.........................
Proper Solution .315
...............
Temperature Indicator . 67Crankcase Emissions Control
........................................
System .387
............
Cruise Control Operation . 222
.........................
Customer Service .394
C D
II

CONT INUED
Doors...................
Auto Door Locking . 109
...............
Auto Door Unlocking . 110
............
Childproof Door Locks . 134
............
Locking and Unlocking . 133
..........
DOT Tire Quality Grading . 382
...........
Driver and Passenger Safety . 5
...........................................
Driving .261
....................................
Economy .251
..................
Dust and Pollen Filter . 332 ...................................
Fan, Interior .164
.........................................
Features .161
....................
Filling the Fuel Tank . 245
Filters .........................
Dust and Pollen .332
...............................................
Oil .313
...........
Flashers, Hazard Warning . 125
...................
Flat Tire, Changing a . 349
.....................................
Floor Mats .331
Fluids ..........
Automatic Transmission . 318
..........................................
Brake .319
..................
Windshield Washer . 317
FM Stereo Radio ...................................
Reception .212
........................
Four-way Flashers .125
............................
Front Airbags .10, 25
........................
Eco Assist System .264
................
Ecological Drive Display . 81
................................
ECON Button .127
..................................
ECON Mode .127
..............................
Economy, Fuel .251
............
Emergencies on the Road . 347
.............
Battery, Jump Starting . 358
.....
Brake System Indicator . 63,366
................
Changing a Flat Tire . 349
Charging System ...........................
Indicator .63, 364
..................
Checking the Fuses . 369Low Oil Pressure
...........................
Indicator .62, 363
Malf unction Indicator ................................
Lamp .62, 365
..................
Overheated Engine . 360
.........................
Emergency Brake .151
....................
Emergency Flashers .125
...........
Emergency Hatch Opener . 140
......................
Emergency Towing .374
.......................
Emissions Controls .387
........................
Emissions Testing .390
Engine ............
Adding Engine Coolant . 315
Coolant Temperature ...................................
Indicator .67
.........................
If It Won’t Start .356
Malf unction Indicator ................................
Lamp .62, 365
.........................
Oil Lif e Display .299
........
Oil Pressure Indicator . 62,363
..............
Oil, What Kind to Use . 310
...............................
Overheating .360
............................
Specif ications .380
............................
Speed Limiter .274
.......................................
Starting .263
.
Evaporative Emissions Controls . 387...............................
Exhaust Fumes .56
Expectant Mothers, Use of Seat ........................................
Belts by .19
Index
F
E
INDEX
III