2003 HONDA ELEMENT brake

Bef ore mounting the spare tire,
wipeanydirtoff themounting
surface of the wheel and hub with
a clean cloth. Wipe the hub
carefully,itmaybehotfrom
driving.Put on the spare tire. Put the
wheel nuts back on f inger-tight,
then tighten them in a crisscross
pattern with the wheel wrench
until the wheel is f irmly against
the hub. Do not try to tighten
them f ully.Lower the vehicle to the ground
and remove the jack.
12.
13.14.
T aking Care of t he Unexpect ed
Changing a Flat T ire
280
BRAKE HUB

If your vehicle’s battery has run
down,youmaybeabletostartthe
engine by using a booster battery.
Although this seems like a simple
procedure, you should take several
precautions.To jump start your vehicle, f ollow
these directions closely:
Open the hood and check the
physical condition of the battery
(see page ). In very cold
weather, check the condition of
the electrolyte. If it seems slushy
or like ice, do not try jump starting
until it thaws.
Turn of f all the electrical acces-
sories: heater, A/C, stereo system,
lights, etc.
Put the transmission in Neutral or
Park, and set the parking brake.
You cannot start a Honda with an
automatic transmission by pushing
or pulling it. 1.
2.240
CONT INUED
Jump Starting
T aking Care of t he Unexpect ed285
A battery can explode if you do
not follow the correct procedure,
seriously injuring anyone
nearby.
Keep all sparks, open flames,
and smoking materials away
from the battery.
If a battery sits in extreme cold, the
electrolyte inside can f reeze.
Attempting to jump start with a f rozen
battery can cause it to rupture.

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine.If you do not see steam or spray,
leave the engine running and
watch the temperature gauge. If
the high heat is due to overloading
(climbing a long, steep hill on a
hot day with the A/C running, for
example), the engine should start
to cool down almost immediately.
If it does, wait until the tempera-
ture gauge comes down to the mid-
point, then continue driving.
The pointer of your vehicle’s
temperature gauge should stay in
the midrange under most conditions.
Itmaygohigherif youaredrivingup
a long steep hill on a very hot day. If
it climbs to the red mark, you should
determine the reason.
Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park, and set the parking brake.
Turn of f the heating and cooling
system and all other accessories.
Turn on the hazard warning
indicators.If the temperature gauge stays at
the red mark, turn of f the engine.
Wait until you see no more signs
of steam or spray, then open the
hood.
Your vehicle can overheat for several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action. 1.
2.3.
4.
5.
If Your Engine Overheats
T aking Care of t he Unexpect ed288
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

Î
Î
If you must drive the vehicle a short
distance in this condition, drive
slowly and cautiously.
If it comes on at any other time, it
indicates a problem with the vehicle’s
brake system. In most cases, the
problem is a low f luid level in the
brake f luid reservoir. Press lightly on
the brake pedal to see if it f eels
normal. If it does, check the brake
f luid level the next time you stop at a
service station (see page ). If the
f luid level is low, take the vehicle to
your dealer and have the brake
system inspected f or leaks or worn
brake pads.
However, if the brake pedal does not
f eel normal, you should take
immediate action. Because of the
brake system’s dual-circuit design, a
problem in one part of the system
will still give you braking at two
wheels. You will f eel the brake pedal
go down much f arther bef ore the
vehicle begins to slow down, and you
will have to press harder on the
pedal. The distance needed to stop
will be much longer. Slow down by shif ting to a lower
gear, and pull to the side of the road
when it is saf e. Because of the
longer distance needed to stop, it is
hazardous to drive the vehicle. You
should have it towed, and repaired as
soon as possible. (See
on page .)
The Brake System Indicator
normallycomesonwhenyouturn
the ignition switch ON (II). It is a
reminder to check the parking brake.
It comes on and stays lit if you do not
f ully release the parking brake. If the ABS indicator comes on with
this indicator, have the vehicle
inspected by your Honda dealer
immediately.
234
301
On models equipped with ABS
Emergency
Towing
Brake System Indicator
T aking Care of t he Unexpect ed294
BRAKE SYSTEM INDICATOR
U.S. indicator shown

µµµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation307
Air Conditioning
Tires Alignment Fuses
Battery Lights HFC-134a (R-134a)
16.9 18.7 oz (480 530 g) SP-10
12 V 60/55 W (H4/HB2)
12 V 12 V
12 V
12 V
12 V
12 V
12 V
8W
4CP
8W
5W
18 W (21 CP)
21/5 W
21 W
Refrigerant type
Charge quantity
Lubricant type
P215/70R16 99S
Size
Pressure Toe-in
Camber
Caster 1°50’1°
0°13’
0.08 in (2.0 mm) 0.0in(0mm)
Interior
Under-hood
12 V 21/5 W
12 V 3 CP
12 V 21 W
Capacity See page
299or the fuse label
attached to the inside of the fuse
box door under the steering
column.
See page 300or the fuse box
cover.
32 psi (220 kPa , 2.2 kgf/cm
)
34 psi (235 kPa , 2.4 kgf/cm)
Headlights
Front turn signal/parking
lights
Front side marker lights
Rear turn signal lights
Brake/Taillights
Back-up lights
License plate lights
Ceiling light
Spotlights
Cargo area light
High-mount brake light
45 AH/20 HR
12 V Front
Rear
Front
Rear
Front
Front/Rear
Front
Rear

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your Honda dealer.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (A/T) or 5th (M/T). Do not use
thecruisecontrol.Whentraffic
allows, drive f or 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
T echnical Inf ormation
St at e Emissions T est ing
317

CONT INUED
BatteryCharging System ...........................
Indicator .66, 291
............................
Jump Starting .285
..............................
Maintenance .240
............................
Specif ications .307
..............................
Bef ore Driving .157
....................................
Belts,Seat .8,50
.........................
Beverage Holders .110
.................................
Body Repairs .274 Brakes
...........
Anti-lock System (ABS) . 186
.............
Break-in, New Linings . 158
....................
Bulb Replacement .261
...........................................
Fluid .234
.......................................
Parking .111
.................
System Indicator . 66,294
........................
Wear Indicators .185
.............................
Braking System .185
.................
Break-in, New Vehicle . 158
..
Brightness Control, Instruments . 77
........................
Brights, Headlights .76
Bulb Replacement ..........................
Back-up Lights .261
..............................
Brake Lights .261
......................
Cargo Area Light .265
..............................
Ceiling Light .264
................
Front Parking Lights . 259
........
Front Side Marker Lights . 260
.................................
Headlights .258
.........
High-mount Brake Light . 263
...........................
Interior Lights .264
.................
License Plate Lights . 262
...
Accessories and Modif ications . 165
................................
Accessories .165
.
Additional Safety Precautions . 166
............................
Modif ications .166
ACCESSORY (Ignition Key .......................................
Position) .86
............
Accessory Power Sockets . 113
....................
Additives, Engine Oil . 222
.............................
Airbag (SRS) .10, 54
.....................
Air Cleaner Element .236
..............
Air Conditioning System . 118
..............................
Maintenance .245
.........................................
Usage .118
.......................
Air Outlets (Vents) .120
.......................
Air Pressure, Tires .249
.........................
Normal Driving .250
.......................
Alcohol in Gasoline .311
......................................
Antif reeze .225
Anti-lock Brakes (ABS) ...............................
Indicator .68, 188
...................................
Operation .186
..............
Anti-thef t, Audio System . 152
Anti-thef t Steering Column ..............................................
Lock .85 ..........................
Appearance Care .267
...................
Armrest, Driver’s Seat . 93
................................
Audio System .126
...
Automatic Seat Belt Tensioners . 52
.............
Automatic Speed Control . 153
..............
Automatic Transmission . 178
..........................
Capacity, Fluid .306
...............
Checking Fluid Level . 231
.......................................
Shif ting .179
.
Shif t Lever Position Indicator . 178
................
Shif t Lever Positions . 179
....................
Shif t Lock Release . 183
Index
A
B
I

ÎÎ
Bulb Replacement
............................
Specif ications .307
...................................
Spotlights .264
....................
Turn Signal Lights . 259
..............................
Bulbs, Halogen .258
............................
Capacities Chart .306
.............
Carbon Monoxide Hazard . 60
..........................
Cargo Area Light .115
.................................
Cargo Hooks .170
.............................
Carrying Cargo .167
..............
CAUTION, Explanation of . ii
..........................
CD Changer .134, 147
..............................
CD Player .132, 145
...............................
Ceiling Pocket .112
........................
Certif ication Label .304
............................................
Chains .255
....................
Changing a Flat Tire .277
............
Changing Engine Coolant . 227
.................................
Changing Oil .223
........................................
How to .223
......................................
When to .212
...
Charging System Indicator . 66,291
............
Checklist, Bef ore Driving . 173.....................................
Child Saf ety .24
.......................................
Child Seats .29
......
LATCH Anchorage System . 47
...........................
Lower Anchors .47
............
Tether Anchorage Point . 46
....................
Cleaner Element, Air . 236
Cleaning ....................
Aluminum Wheels .269
......................................
Exterior .268
.........................................
Fabric .271
..........................
Floor Covering .271
.......................................
Interior .271
...................................
Seat Belts .271
...........................................
Vinyl .271
....................................
Windows .272
.................
Clock, Setting the . 130,142
...................................
Clutch Fluid .235
........................
CO in the Exhaust .312
............
Cold Weather, Starting in . 175
...............
Consumer Inf ormation . 320
.............
Controls, Instruments and . 63
Coolant ........................................
Adding .225
....................................
Checking .163
.........................
Proper Solution .225
...................................
Replacing .227 ...................
Temperature Gauge . 74
....................
Corrosion Protection .273
Crankcase Emissions Control ........................................
System .313
............
Cruise Control Operation . 153
........
Customer Relations Of f ice . 320
................
DANGER, Explanation of . ii
.......................................
Dashboard .64
................
Daytime Running Lights . 77
............
Def ects, Reporting Saf ety . 322
........................
Def og and Def rost .124
................
Def ogger, Rear Window . 81
..............
Def rosting the Windows . 124
....................................
Dimensions .306
...............
Dimming the Headlights . 76
Dipstick ..........
Automatic Transmission . 231
..................................
Engine Oil .162
..........................
Directional Signals .77
........
Disc Brake Wear Indicators . 185
.....................
Disposal of Used Oil .224
Doors ..............
Locking and Unlocking . 87
Index
C
D
II