2003 HONDA CR-V manual transmission

The Engine Number is stamped into
the engine block.
The Transmission Number is on a
label on top of the transmission.
Identif ication Numbers
T echnical Inf ormation341
AUTOMATIC TRANSMISSION NUMBER
ENGINE NUMBER MANUAL TRANSMISSION NUMBER

ÎÎ
ÎÎ
Î
Specif ications
T echnical Inf ormation342
Dimensions
Weights
Engine
Capacities
178.6 in (4,537 mm)
70.2 in (1,782 mm)
66.2 in (1,682 mm)
103.1 in (2,620 mm)
60.4 in (1,533 mm)
60.6 in (1,538 mm)
3.43 x 3.90 in (87.0 x 99.0 mm) 144 cu-in (2,354 cm
)
9.6 : 1
15.3 US gal (58
)
4.4 US qt (4.2
)
4.2 US qt (4.0)
5.6 US qt (5.3) 1.43 US gal (5.4
)
1.88 US gal (7.1)
1.45 US gal (5.5
)
1.90 US gal (7.2)
3.3 US qt (3.1
)
3.1 US qt (2.9)
7.6 US qt (7.2
)
6.9 US qt (6.5)
2.0 US qt (1.9)
2.4 US qt (2.3)
1.1 US qt (1.0
)
1.3 US qt (1.2)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb.
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Fuel tank
Engine oil Water cooled 4-stroke DOHC
VTEC 4-cylinder gasoline engine
4.8 US qt (4.5
)
2.6 US qt (2.5)
2.2 US qt (2.1
)
Engine
coolant
Automatic
transmission
fluid
Manual
transmission
fluid
Rear
differential
fluid (4WD)
Windshield
washer
reservoir
Excluding the oil remaining in the engine.
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity:
0.16 US gal (0.6
)
See spark plug maintenance
section page 269 .
Approx.
Front
Rear
Change
Without filter
Total 1:
2:Change
Total
Change
Total
Change
4WD
2WD
Total 4WD
2WD
Change
Total
Change
Total
U.S. Vehicles
Canada
Vehicles 4WD
2WD
Automatic Transmission
Manual Transmission
1 2
2
Including filter

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F. Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
T esting of Readiness Codes
St at e Emissions T est ing
T echnical Inf ormation352

CONT INUED
Dipstick
..........Automatic Transmission .260
..................................Engine Oil.188
..........................Directional Signals.77
........Disc Brake Wear Indicators .211
.....................Disposal of Used Oil.250
Doors
..............Locking and Unlocking .88
......................Power Door Locks.88
..........DOT Tire Quality Grading .344
Downshif ting,5-speed Manual
.............................Transmission.202
.......................................Drive Belt.277
...........................................Driving.197
....................................Economy.190
.........................In Bad Weather.215
................In Foreign Countries .347
........................Driving Guidelines.198
..................Dust and Pollen Filter .275
............................Fabric, Cleaning.302
...................................Fan, Interior.128
Features, Comfort and
..............................Convenience.127
....................Filling the Fuel Tank .185
Filters
................................Air Cleaner.265
.........................Dust and Pollen.275
...............................................Oil.249
5-speed Manual Transmission
...............Checking Fluid Level .261
................................Shif ting the.202
.............Flashers, Hazard Warning .81
...................Flat Tire, Changing a .308
..............................Economy, Fuel.190
............Emergencies on the Road .307
.............Battery, Jump Starting .320
...........Brake System Indicator .329
................Changing a Flat Tire .308
.....Charging System Indicator .326
..................Checking the Fuses .332
.....Low Oil Pressure Indicator .325
...Malf unction Indicator Lamp .327
...Manually Closing Moonroof .330
..................Overheated Engine .323
...........................Emergency Brake.82
......................Emergency Flashers.81
......................Emergency Towing.337
.......................Emissions Controls.349
.............Emissions Testing, State .352
Engine
....Coolant Temperature Gauge .74
...................................Drive Belt.277
......Engine Speed Limiter .203,208
Malf unction Indicator
................................Lamp.66,327
........Oil Pressure Indicator .66,325
..............Oil, What Kind to Use .247
...............................Overheating.323
............................Specif ications.342
.......................................Starting.200
......................Ethanol in Gasoline.347
.Evaporative Emissions Controls .349
...............................Exhaust Fumes.60
Expectant Mothers, Use of Seat
........................................Belts by.21
..................Exterior, Cleaning the .298
Index
E
F
III

.............Halogen Headlight Bulbs .287
.....................................Hatch Glass.94
..............Hazard Warning Flashers .81
Headlights
........................................Aiming.287
............Daytime Running Lights .77
..................High Beam Indicator .69
........................Reminder Beeper.76
........Replacing Halogen Bulbs .287
...................................Turning on.76
..............................Head Restraints.99
.....................Heating and Cooling.128
.............High Altitude, Starting at .201
.................High-Low Beam Switch .76
..............High-mount Brake Light .292
....................................Hood Latch.266
.......................Hood, Opening the.186
..............................................Horn.3,75
...........................Hydraulic Clutch.264
.................................Hydroplaning.216
Fluids
..........Automatic Transmission .260
..........................................Brake.263
.........................................Clutch.264
..............Manual Transmission .261
..........................Power Steering.264
.......................Rear Differential.262
..................Windshield Washer .258
FM Stereo Radio
...................................Reception.161
.........................Folding Rear Seat.104
.....Foreign Countries, Driving in .348
..........................Four-way Flashers.81
............................Front Airbags.10,54
.................................................Fuel.184
......................Fill Door and Cap.185
...........................................Gauge.74
................Octane Requirement .184
...............................Oxygenated.347
........................Reserve Indicator.69
........................Tank, Filling the.185
.....................Fuses, Checking the.331
...............Gas Mileage, Improving .190
..........................................Gasohol.347
.........................................Gasoline.184
...............Fuel Reserve Indicator .69
...........................................Gauge.74
................Octane Requirement .184
........................Tank, Filling the.185
................Gas Station Procedures .185
Gauges
...Engine Coolant Temperature .74
...............................................Fuel.74
...............................Speedometer.72
.................................Tachometer.72
Gearshif t Lever Positions
..........Automatic Transmission .204
5-speed Manual
.........................Transmission.203
..............................Glass Cleaning.303
........................................Glove Box.96
...Identif ication Number, Vehicle .340
Ignition
..............................................Keys.84
...........................................Switch.86
............Timing Control System .350
........................Immobilizer System.85
.........Important Safety Precautions .6
.........Indicators, Instrument Panel .65
Index
G
H
I
IV

CONT INUED
..................................................
Keys .84
.................
Jacking up the Vehicle . 312
.......................................
Jack, Tire .309
................................
Jump Starting .320
...............................
Inf ant Restraint .34
......................................
Inf ant Seats .34
......
LATCH Anchorage System . 47
...........................
Lower Anchors .47
..........
Tether Anchorage Points . 46
...................
Inf lation, Proper Tire . 278
.................
High Speed Driving . 279
.........................
Normal Driving .279
.................................
Inside Mirror .114
.............................
Inspection, Tire .280
............................
Instrument Panel .65
........
Instrument Panel Brightness . 77
...........................
Interior Cleaning .301
...............................
Interior Lights .124
........................................
Introduction .i .......................
Label, Certif ication .340
.................
Lane Change, Signaling . 77
..................
Lap/Shoulder Belts . 17,50
...........
LATCH Anchorage System . 47
Lights ....................
Bulb Replacement .287
.......................................
Indicator .65
.........................................
Parking .76
..................................
Turn Signal .77
.....................................
Load Limit .194
......
LOCK (Ignition Key Position) . 87
Locks .......
Anti-thef t Steering Column . 87
............................
Fuel Fill Door .185
....................................
Glove Box .96
.................................
Power Door .88
........................................
Tailgate .93
........................
Low Coolant Level .189
.........................
Low Fuel Indicator .69
...
Low Oil Pressure Indicator . 66,325
................................
Lower Anchors .47
...
Lubricant Specif ications Chart . 342
.........................................
Luggage .193 ..................................
Maintenance .233
...
Owner Maintenance Checks . 245
.................................
Record .243-244
......................
Required Indicator .70
..........................................
Saf ety .234
.............................
Schedule .238-242
.
Malf unction Indicator Lamp . 66,327
...................
Manual Transmission . 202
........
Manual Transmission Fluid . 261
.........................
Meters, Gauges .65, 72
...................
Methanol in Gasoline . 347
........................
Mirrors, Adjusting .114
.......................................
Moonroof .113
......................
Closing Manually .330
...................................
Operation .113
Index
LM
K J
V

ÎÎ
.................
Vehicle Capacity Load . 194
......................
Vehicle Dimensions .342
....
Vehicle Identif ication Number . 340
.............................
Vehicle Storage .295
.....................................
Ventilation .131
.................................................
VIN .340
...............................
Vinyl Cleaning .302
..................................
Viscosity, Oil .248
Transmission
Checking Fluid Level, ..............................
Automatic .260
Checking Fluid Level, ...................................
Manual .261
..................
Fluid Selection . 260,261
..............
Identif ication Number . 341
.............
Shif ting the Automatic . 204
..................
Shif ting the Manual . 202
.....................................
Treadwear .344
.......................................
Trip Meter .73
....................................
Turn Signals .77
.....................
Underside, Cleaning .304
Unexpected, Taking Care ..........................................
of the .307
....
Unif orm Tire Quality Grading . 344
........................
Unleaded Gasoline .184
.....................
Upholstery Cleaning .301
.......
Used Oil, How to Dispose of . 250 .............
WARNING, Explanation of . ii
.........
Warning Labels, Location of . 61
..................
Warranty Coverages .357
Washers, Windshield ........
Checking the Fluid Level . 258
.....................................
Operation .79
.........................................
Washing .298
..................
Waxing and Polishing . 299
Wheels ...............
Adjusting the Steering . 83
............
Alignment and Balance . 280
......................................
Wrench .311 Windows
.....................................
Cleaning .303
................
Operating the Power . 110
...........................
Rear, Def ogger .81
Windshield .......................................
Cleaning .78
...................................
Def roster .134
.....................................
Washers .258
Wipers, Windshield .......................
Changing Blades .271
.....................................
Operation .78
....................................
Worn Tires .280
.....
Wrecker, Emergency Towing . 337
: U.S. and Canada only
Index
U V
W
IX

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:5-speed Manual Transmission
Fluid:
Rear Differential Fluid:Brake Fluid:
Tire Pressure (measured cold):
Automatic Transmission Fluid: Power Steering Fluid:
15.3 US gal (58
)
Unleaded gasoline, pump octane
number of 86 or higher.
Capacity (including differential): 26 psi (180 kPa , 1.8 kgf/cm
)
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Front/Rear:
2.0 US qt (1.9
)
API Premium grade 5W-20
detergent oil (see page ).
Oil change capacity (including
filter):
4.4 US qt (4.2
)
Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page ). Honda Dual Pump Fluid. Do not
use ATF (see page ).
Capacity:
1.1 US qt (1.0
)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ). Honda Manual Transmission
Fluid preferred, or an SAE 10W-30
or 10W-40 motor oil as a
temporary replacement (see page ).
247
262
264 263
260 261