2003 GMC YUKON brake

Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
The key should turn to LOCK only when the
shift lever is in PARK (P).
The key should come out only in LOCK.
Parking Brake and Automatic
Transmission Park (P) Mechanism
Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With the
engine running and transmission in NEUTRAL (N),
slowly remove foot pressure from the regular brake
pedal. Do this until the vehicle is held by the parking
brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK (P). Then
release the parking brake followed by the regular
brake.
Underbody Flushing Service
At least every spring, use plain water toush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-14
2003 - Yukon/Yukon XL

Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
Transfer Case and Front Axle
(Four-Wheel Drive) Inspection
Every 12 months or at engine oil change intervals,
check front axle and transfer case and add lubricant
when necessary. Auid loss could indicate a problem;
check and have it repaired, if needed. On manual
shift transfer case, oil the control lever pivot point. Check
vent hose at transfer case for kinks and proper
installation. More frequent lubrication may be required
on off-road use.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chang, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. You may need to
have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
6-16
2003 - Yukon/Yukon XL

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certied for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle’s engine, seeEngine Oil on
page 5-16.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-26.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brakeuid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent or
equivalent.
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Automatic
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
Usage Fluid/Lubricant
Key Lock
CylindersMulit-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Axle
(Four-Wheel
Drive)SAE 80W-90 Axle Lubricant
(GM Part No. U.S. 1052271, in
Canada 10950849 or equivalent).
Front Axle
(All-Wheel
Drive)SAE 75W-90 Synthetic Axle
Lubricant (GM Part No. U.S.
12378261, in Canada 10953455) or
equivalent meeting GM Specication
9986115.
Rear AxleSAE 75W-90 Synthetic Axle
Lubricant (GM Part No. U.S.
12378261, in Canada 10953455) or
equivalent meeting GM Specication
9986115.
Rear Axle
(Steerable)Synthetic Axle Lubricant; use only
GM Part No. 12378557 (in Canada
88901362). Do not add friction
modier.
Transfer Case
(All-Wheel
Drive with
Stabilitrak
®)Dexron-III Automatic Transmission
Fluid.
6-17
2003 - Yukon/Yukon XL

Reporting Safety Defects to the
Canadian Government
If you live in Canada, and you believe that your vehicle
has a safety defect, you should immediately notify
Transport Canada, in addition to notifying General
Motors of Canada Limited. You may write to:
Transport Canada
330 Sparks Street
Tower C
Ottawa, Ontario K1A 0N5
Reporting Safety Defects to General
Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, we certainly hope you’ll notify us.
Please call us at 1-800-GMC-8782 (1-800-462-8782), or
write:
Pontiac-GMC Customer Assistance Center
P.O. Box 33172
Detroit, MI 48232-5172
In Canada, please call us at 1-800-263-3777 (English)
or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, 163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair service
procedures, adjustments, and specications for GM
transmissions, transaxles, and transfer cases.
RETAIL SELL PRICE: $50.00
Service Bulletins
Service Bulletins give technical service information
needed to knowledgeably service General Motors cars
and trucks. Each bulletin contains instructions to
assist in the diagnosis and service of your vehicle.
In Canada, information pertaining to Product Service
Bulletins can be obtained by contacting your General
Motors dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483).
7-10
2003 - Yukon/Yukon XL

A
Accessory Power Outlets.................................3-20
Adding Washer Fluid.......................................5-39
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-5
Add-On Electrical Equipment............................5-97
Adjustable Throttle and Brake Pedal..................2-21
Adjusting the Speakers
(Balance/Fade)..................3-74, 3-78, 3-88, 3-101
After Off-Road Driving.....................................4-37
Air Bag
Passenger Status Indicator...........................3-40
Readiness Light..........................................3-40
Air Bag Systems.....................................1-70, 1-77
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-86
How Does an Air Bag Restrain?....................1-78
Passenger Sensing System...........................1-81
Servicing Your Air Bag-Equipped Vehicle.........1-85
What Makes an Air Bag Inflate?....................1-78
What Will You See After an Air Bag Inflates?......1-79
When Should an Air Bag Inflate?...................1-76
Where Are the Air Bags?..............................1-74
Air Cleaner/Filter, Engine.................................5-21
Air Conditioning
..............................................3-29
All Overseas Locations
...................................... 7-4
All-Wheel Drive
...............................................5-49
All-Wheel Drive with Stabilitrak
®........................2-31
AM
.............................................................3-123AM-FM Radio.................................................3-72
Antenna, Fixed Mast......................................3-125
Antenna, XM™ Satellite Radio Antenna System . . . 3-126
Anti-lock Brake System..................................... 4-7
Anti-Lock Brake, System Warning Light..............3-44
Appearance Care............................................5-88
Care of Safety Belts....................................5-91
Chemical Paint Spotting...............................5-94
Cleaning the Inside of Your Vehicle................5-89
Cleaning the Outside of Your Vehicle..............5-92
Finish Damage............................................5-94
GM Vehicle Care/Appearance Materials..........5-95
Sheet Metal Damage...................................5-94
Underbody Maintenance...............................5-94
Weatherstrips..............................................5-91
Approaching a Hill..........................................4-29
Ashtrays........................................................3-21
Audio Output................................................3-118
Audio System(s).............................................3-71
AM-FM Radio.............................................3-72
Audio Steering Wheel Controls....................3-122
Care of Your Cassette Tape Player...............3-124
Care of Your CD and DVD Player
................3-125
Care of Your CDs and DVDs
.......................3-125
Chime Level Adjustment
.............................3-126
Fixed Mast Antenna
...................................3-125
Radio with Cassette and CD
.........................3-85
Radio with CD
............................................3-75
Radio with Six-Disc CD
................................3-98
Rear Seat Audio (RSA)
...............................3-120
1
2003 - Yukon/Yukon XL

Audio System(s) (cont.)
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-72
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-71
Theft-Deterrent Feature...............................3-122
Understanding Radio Reception...................3-123
XM™Satellite Radio Antenna System...........3-126
Automatic Headlamp System............................3-15
Automatic Level Control...................................4-60
Automatic Transfer Case..................................2-26
Automatic Transmission
Fluid..........................................................5-23
Operation...................................................2-22
Automatic Transmission Check..........................6-12
Automatic Transmission Shift Lock Control
System Check.............................................6-13
Autoride™.....................................................4-60
Auxiliary Roof Mounted Lamp Switch.................3-17
B
Backing Up....................................................4-69
Battery..........................................................5-43
BATTERY NOT CHARGING.............................3-65
Battery Replacement......................................... 2-6
Battery Run-Down Protection............................3-20
Battery Warning Light......................................3-42
Before Leaving on a Long Trip.........................4-44
Before You Drive...........................................3-111Before You Go Off-Roading..............................4-25
Bench Seat....................................................1-15
Bench Seat Split (50/50)..................................1-11
Bench Seat, Split (60/40)................................... 1-9
Body Lubrication Service..................................6-12
Brake
Parking......................................................2-34
System Inspection.......................................6-16
System Warning Light..................................3-43
Brake Adjustment............................................5-43
Brake Fluid
....................................................5-40
Brake Pedal, Throttle
.......................................2-21
Brake Pedal Travel
.........................................5-43
Brake Wear
...................................................5-42
Brakes
..........................................................5-40
Braking
........................................................... 4-6
Braking in Emergencies
..................................... 4-9
Break-In, New Vehicle
.....................................2-18
Bucket Seats, Rear
.........................................1-20
Bulb Replacement
...........................................5-52
Front Turn Signal, Sidemarker and Daytime
Running Lamps
........................................5-54
Halogen Bulbs
............................................5-53
Headlamps
.................................................5-53
Replacement Bulbs
......................................5-59
Roof Marker Lamps
.....................................5-55
Side Identification Marker Lamps
...................5-55
Taillamps
....................................................5-57
Buying New Tires
...........................................5-64
2
2003 - Yukon/Yukon XL

C
California Fuel.................................................. 5-5
Canada........................................................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Specifications..........................5-106
Car Washes for QUADRASTEER™Equipped
Vehicles.....................................................4-19
Carbon Monoxide...................4-47, 4-61, 2-12, 2-38
Care of
Safety Belts................................................5-91
Your Cassette Tape Player..........................3-124
Your CD and DVD Player...........................3-125
Your CDs and DVDs ..................................3-125
Cargo Cover..................................................2-57
Cargo Tie Downs............................................2-57
Cassette Tape Messages.................................3-94
Cassette Tape Player Service...........................6-11
CD Adapter Kits.............................................3-95
Center Console Storage Area...........................2-54
Center Instrument Panel Fuse Block................5-100
Center Passenger Position, Safety Belts.............1-36
Chains, Tires..................................................5-68
CHANGE ENGINE OIL
....................................3-64
Check
Engine Light
...............................................3-48
Check Engine Light
.........................................3-48
CHECK OIL LEVEL
.........................................3-68
CHECK WASHER FLUID
.................................3-68Checking Brake Fluid......................................5-41
Checking Coolant............................................5-28
Checking Engine Oil........................................5-16
Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-86
Chemical Paint Spotting...................................5-94
Child Restraints
Child Restraint Systems...............................1-50
Infants and Young Children...........................1-46
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-58
Older Children.............................................1-44
Securing a Child Restraint Designed for the
LATCH System........................................1-61
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-64
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-61
Securing a Child Restraint in the Center Front
Seat Position...........................................1-66
Securing a Child Restraint in the Right Front
Seat Position...........................................1-66
Top Strap...................................................1-54
Top Strap Anchor Location............................1-55
Where to Put the Restraint
...........................1-53
Chime Level Adjustment
.................................3-126
Cigarette Lighter
.............................................3-21
Cleaning
Inside of Your Vehicle
..................................5-89
Outside of Your Vehicle
................................5-92
3
2003 - Yukon/Yukon XL

H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-8
Headlamp High/Low-Beam Changer.................... 3-9
Headlamps....................................................5-53
Bulb Replacement.......................................5-52
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-54
Halogen Bulbs............................................5-53
Roof Marker Lamps.....................................5-55
Side Identification Marker Lamps...................5-55
Headphones.................................................3-117
Heated Seats................................................... 1-5
Heating.........................................................3-30
Highway Hypnosis...........................................4-44
Hill and Mountain Roads..................................4-45
Hitches..........................................................4-67
HomeLink Transmitter, Programming..................2-51
HomeLink
®Transmitter....................................2-50
Hood
Checking Things Under................................5-10
Release.....................................................5-11
Horn ............................................................... 3-7
How to Add Coolant to the Coolant Surge Tank......5-34
How to Add Fluid
............................................5-25
How to Check
........................................5-23, 5-61
How to Check Lubricant
...................................5-50How to Check Power Steering Fluid..................5-39
How to Inspect...............................................5-21
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-27
Hydroplaning..................................................4-40
I
If No Steam Is Coming From Your Engine..........5-31
If Steam Is Coming From Your Engine...............5-30
If the Light is Flashing.....................................3-49
If the Light Is On Steady.................................3-49
If You Are Stuck in Sand, Mud, Ice or Snow.......4-52
If You Do Decide To Pull A Trailer.....................4-62
If You’re Caught in a Blizzard...........................4-50
Ignition Positions.............................................2-19
Ignition Transmission Lock Check......................6-14
Infants and Young Children, Restraints...............1-46
Inflation -- Tire Pressure..................................5-61
Inspection
Brake System.............................................6-16
Engine Cooling System................................6-16
Exhaust System..........................................6-15
Fuel System...............................................6-15
Part C - Periodic Maintenance.......................6-15
Steering and Suspension..............................6-15
Transfer Case and Front Axle
(Four-Wheel Drive)...................................6-16
8
2003 - Yukon/Yukon XL