2003 GMC SONOMA power steering

Fuse Usage
A Not Used
B Not Used
1 Not Used
2 Cigarette Lighter, Data Link
Connector
3 Cruise Control Module and Switch,
Body Control Module, Heated SeatsFuse Usage
4 Gages, Body Control Module,
Instrument Panel Cluster
5 Parking Lamps, Power Window
Switch, Body Control Module,
Ashtray Lamp
6 Steering Wheel Radio Controls
7 Headlamps Switch, Body Control
Module, Headlamp Relay
8 Courtesy Lamps, Battery Run-Down
Protection
9 Heating, Ventilation, Air Cooling
Control Head (Manual)
10 Turn Signal
11 Cluster, Engine Control Module
12 Interior Lights
13 Auxiliary Power
14 Power Locks Motor
15 4WD Switch, Engine Controls
(VCM, PCM, Transmission)
16 Supplemental Inflatable Restraint
17 Front Wiper
18 Steering Wheel Radio Controls
19 Radio, Battery
5-90
2003 - Sonoma OM

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).You should let your dealer’s
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-9.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chang, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in theoor pan or could let
exhaust fumes into the vehicle. SeeEngine Exhaust
on page 2-37.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
ttings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-31
2003 - Sonoma OM

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certied for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle’s engine, seeEngine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant on
page 5-25.
Hydraulic Brake
SystemDelco Supreme 11
®Brake Fluid or
equivalent DOT-3 brakeuid.
Windshield
Washer SolventGM Optilkeen
®Washer Solvent or
equivalent.
Hydraulic
Clutch SystemHydraulic Clutch Fluid (GM Part No.
U.S. 12345347, in Canada
10953517, or equivalent DOT-3
brakeuid).
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Manual
Transmission
with V6 EngineSynchromesh Transmission Fluid
(GM Part No. U.S. 12345349, in
Canada 10953465, or equivalent).
Manual
Transmission
with L4 EngineFriction Modied Synchromesh
Transmission Fluid (GM Part No.
U.S. 12377916, in Canada
10953509).
Automatic
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
®
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Wheel
BearingsWheel bearing lubricant meeting
requirements of NLGI #2, Category
GC or GC-LB (GM Part No. U.S.
1051344, in Canada 993037, or
equivalent).
Front and Rear
Axle (Standard
Differential)SAE 80W-90 Axle Lubricant (GM
Part No. U.S. 1052271, in Canada
10950849, or equivalent).
6-33
2003 - Sonoma OM

Flat Tire........................................................5-67
Flat Tire, Changing.........................................5-68
Fluid
Automatic Transmission................................5-20
Manual Transmission....................................5-23
Power Steering...........................................5-37
Windshield Washer......................................5-38
FM ...............................................................3-67
Fog Lamps ....................................................3-13
Following Distance..........................................4-57
Four-Wheel Drive....................................2-29, 5-48
Front Axle......................................................5-49
Front Map Lamps...........................................3-14
Front Storage Area.........................................2-49
Fuel............................................................... 5-4
Additives...................................................... 5-5
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-8
Filling Your Tank........................................... 5-6
Fuels in Foreign Countries.............................. 5-6
Gage .........................................................3-35
Gasoline Octane........................................... 5-4
Gasoline Specifications.................................. 5-5
Low Warning Light.......................................3-35
System Inspection
.......................................6-31
Fuses
Fuses and Circuit Breakers
...........................5-89
Windshield Wiper
.........................................5-88G
Gage
Check Gages Warning Light..........................3-34
Engine Coolant Temperature.........................3-29
Fuel..........................................................3-35
Oil Pressure...............................................3-32
Speedometer..............................................3-23
Tachometer.................................................3-23
Voltmeter Gage...........................................3-26
Garment Hooks..............................................2-50
Gasoline
Octane........................................................ 5-4
Specifications............................................... 5-5
Getting Familiar with Off-Road Driving................4-16
Glass Surfaces...............................................5-81
Glove Box.....................................................2-41
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-3
Head Restraints............................................... 1-7
Headlamp High/Low-Beam Changer.................... 3-6
Headlamps....................................................5-50
Bulb Replacement.......................................5-50
Electrical System.........................................5-88
6
2003 - Sonoma OM

Headlamps (cont.)
Halogen Bulbs............................................5-50
One-Piece Front Turn Signal Lamps...............5-52
Two-Piece Front Turn Signal Lamps...............5-53
Heated Seats................................................... 1-5
Heating.........................................................3-18
Highway Hypnosis...........................................4-34
Hill and Mountain Roads..................................4-34
Hitches..........................................................4-56
Hood
Checking Things Under.................................. 5-8
Release....................................................... 5-9
Horn ............................................................... 3-4
How to Add Coolant to the Coolant
Recovery Tank............................................5-32
How to Add Coolant to the Radiator..................5-34
How to Add Fluid....................................5-22, 5-24
How to Check................................5-20, 5-23, 5-59
How to Check and Add Fluid
............................5-25
How to Check Lubricant
..........................5-47, 5-49
How to Check Power Steering Fluid
..................5-37
How to Inspect the Engine Air Cleaner/Filter
.......5-19
How to Use This Manual
...................................... ii
How to Wear Safety Belts Properly
...................1-15
Hydraulic Clutch
.............................................5-24
Hydraulic Clutch System Check
........................6-27
Hydroplaning
..................................................4-30I
If No Steam Is Coming From Your Engine..........5-29
If Steam Is Coming From Your Engine...............5-28
If the Light Is Flashing.....................................3-30
If the Light Is On Steady.................................3-31
If You Are Stuck in Sand, Mud, Ice or Snow.......4-40
If You Do Decide To Pull A Trailer.....................4-52
If You’re Caught in a Blizzard...........................4-38
Ignition Positions.............................................2-20
Ignition Transmission Lock Check......................6-29
Infants and Young Children, Restraints...............1-32
Inflation–Tire Pressure...................................5-58
Inspection
Brake System.............................................6-32
Engine Cooling System................................6-31
Exhaust System..........................................6-31
Fuel System...............................................6-31
Part C - Periodic Maintenance.......................6-31
Steering, Suspension and Front Drive
Axle Boot and Seal..................................6-31
Throttle System...........................................6-32
Transfer Case and Front Axle
(Four-Wheel Drive)...................................6-32
Installing a Garage Door Opener.......................2-43
Instrument Panel
Cluster.......................................................3-21
Overview..................................................... 3-2
7
2003 - Sonoma OM

Locks
Door ........................................................... 2-8
Leaving Your Vehicle....................................2-11
Lockout Protection.......................................2-11
Power Door .................................................. 2-9
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks.............................2-11
Long Trip/Highway Definition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-18
Loss of Control...............................................4-12
Low Fuel Warning Light...................................3-35
Luggage Carrier..............................................2-50
Lumbar
Manual Controls............................................ 1-4
Power Controls............................................. 1-5
M
Maintenance, Normal Replacement Parts............5-96
Maintenance Schedule
At Each Fuel Fill.........................................6-26
At Least Four Times a Year..........................6-27
At Least Once a Month................................6-26
At Least Once a Year..................................6-28
At Least Twice a Year..................................6-26Maintenance Schedule (cont.)
Brake System Inspection..............................6-32
Engine Cooling System Inspection.................6-31
Exhaust System Inspection...........................6-31
Fuel System Inspection................................6-31
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-18
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-26
Part C - Periodic Maintenance Inspections......6-31
PartD-Recommended Fluids and
Lubricants...............................................6-33
PartE-Maintenance Record........................6-35
Selecting the Right Schedule
.......................... 6-5
Short Trip/City Scheduled Maintenance
............. 6-7
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection
...................6-31
Throttle System Inspection
............................6-32
Transfer Case and Front Axle
(Four-Wheel Drive) Inspection
....................6-32
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
.....................4-60
Making Turns
.................................................4-58
9
2003 - Sonoma OM

Parking
Brake........................................................2-32
Over Things That Burn.................................2-36
Parking Brake and Automatic Transmission
Park (P) Mechanism Check...........................6-30
Parking on Hills..............................................4-59
Parking Your Vehicle.......................................2-36
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-26
Part C - Periodic Maintenance Inspections..........6-31
PartD-Recommended Fluids and Lubricants....6-33
PartE-Maintenance Record...........................6-35
Passing.................................................4-10, 4-58
Passlock
®......................................................2-19
Payload.........................................................4-48
Pickup Conversion to Chassis Cab....................4-50
Plan Ahead When Possible................................ 7-7
Playing a Cassette Tape..................................3-52
Playing a Compact Disc..................3-45, 3-54, 3-62
Playing a Specific Loaded
Compact Disc
.............................................3-63
Playing the Radio
...................3-37, 3-40, 3-47, 3-56
Power
Accessory Outlets
........................................3-15
Door Locks
.................................................. 2-9
Electrical System
.........................................5-88
Lumbar Controls
........................................... 1-5
Seat
............................................................ 1-4Power (cont.)
Steering Fluid.............................................5-37
Windows....................................................2-15
Power Steering................................................ 4-8
Programmable Automatic Door Locks.................. 2-9
Q
Questions and Answers About Safety Belts.........1-15
R
Radiator Pressure Cap....................................5-27
Radio Messages.............................3-39, 3-45, 3-52
Radios..........................................................3-36
AM-FM Radio.............................................3-37
Care of Your Cassette Tape Player................3-68
Care of Your CD Player...............................3-69
Care of Your CDs ........................................3-69
Radio with Cassette and CD.........................3-47
Radio with CD............................................3-40
Radio with Six-Disc CD................................3-56
Setting the Time for Radios with Radio
Data Systems (RDS)................................3-37
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-36
Theft-Deterrent............................................3-67
Understanding Reception..............................3-67
RDS Messages..............................3-43, 3-51, 3-61
11
2003 - Sonoma OM

Vinyl.............................................................5-80
Visors...........................................................2-16
Voltmeter Gage..............................................3-26
W
Warning Lights, Gages and Indicators................3-20
Warnings
Hazard Warning Flashers............................... 3-3
Other Warning Devices.................................. 3-4
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Washing Your Vehicle......................................5-82
Weatherstrip Lubrication...................................6-27
Weight of the Trailer........................................4-53
Weight of the Trailer Tongue.............................4-55
What Kind of Engine Oil to Use........................5-14
What to Add ..................................................5-40
What to Do with Used Oil ................................5-17
What to Use ..........................5-26, 5-38, 5-47, 5-49
Wheels
Alignment and Tire Balance..........................5-64
Replacement...............................................5-65
When to Add Engine Oil..................................5-13
When to Change Engine Oil.............................5-16
When to Check......................................5-23, 5-59
When to Check and Change............................5-20
When to Check and Change Lubricant.......5-47, 5-49When to Check and What to Use.....................5-24
When to Check Power Steering Fluid................5-37
When to Inspect the Engine Air Cleaner/Filter.....5-19
When You Are Ready to Leave
After Parking on a Hill..................................4-60
Where to Put the Restraint.......................1-39, 1-40
Why Safety Belts Work....................................1-12
Window Lockout.............................................2-15
Windows.......................................................2-14
Manual......................................................2-15
Power ........................................................2-15
Sliding Rear................................................2-16
Swing-Out Windows.....................................2-16
Windshield and Wiper Blades...........................5-84
Windshield Washer........................................... 3-7
Fluid..........................................................5-38
Windshield Washer Fluid Level Check................6-26
Windshield Wiper
Blade Replacement......................................5-56
Fuses........................................................5-88
Windshield Wipers............................................ 3-7
Winter Driving................................................4-36
Wiper Blade Check.........................................6-27
Wood Panels.................................................5-81
Y
Your Vehicle and the Environment....................... 6-2
16
2003 - Sonoma OM