2003 GMC SIERRA brake

Starter Switch Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake and the regular
brake. SeeParking Brake on page 2-22if
necessary.
Do not use the accelerator pedal, and be ready to
turn off the engine immediately if it starts.
3. Try to start the engine in each gear. The starter
should work only in PARK (P) or NEUTRAL (N).
If the starter works in any other position, your
vehicle needs service.
Automatic Transmission Shift Lock
Control System Check
{CAUTION:
When you are doing this check, the vehicle
could move suddenly. If it does, you or others
could be injured. Follow the steps below.
1. Before you start, be sure you have enough room
around the vehicle. It should be parked on a level
surface.
2. Firmly apply the parking brake. SeeParking Brake
on page 2-22if necessary.
Be ready to apply the regular brake immediately if
the vehicle begins to move.
3. With the engine off, turn the key to the RUN
position, but don’t start the engine. Without applying
the regular brake, try to move the shift lever out
of PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle needs service.
6-12
2003 - Sierra Denali

Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to LOCK in each shift lever position.
The key should turn to LOCK only when the
shift lever is in PARK (P).
The key should come out only in LOCK.
Parking Brake and Automatic
Transmission Park (P) Mechanism
Check
{CAUTION:
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in
case it begins to roll. Be ready to apply the
regular brake at once should the vehicle begin
to move.Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake’s holding ability: With
the engine running and transmission in NEUTRAL
(N), slowly remove foot pressure from the regular
brake pedal. Do this until the vehicle is held by the
parking brake only.
To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to PARK (P).
Then release the parking brake followed by the
regular brake.
Underbody Flushing Service
At least every spring, use plain water toush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
6-13
2003 - Sierra Denali

Transfer Case and Front Axle
(All-Wheel Drive) Inspection
Every 12 months, or at engine oil change intervals,
check front axle and transfer case and add lubricant
when necessary. Auid loss could indicate a problem.
Check and have it repaired, if needed. Check vent
hose at transfer case for kinks and proper installation.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chang, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. You may need to
have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certied for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle’s engine, seeEngine Oil on
page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-23.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brakeuid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent or
equivalent.
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Automatic
TransmissionDEXRON
®-III Automatic
Transmission Fluid.
6-15
2003 - Sierra Denali

If NHTSA receives similar complaints, it may open an
investigation, and if itnds that a safety defect exists in
a group of vehicles, it may order a recall and remedy
campaign. However, NHTSA cannot become involved in
individual problems between you, your dealer or
General Motors.
To contact NHTSA, you may either call the Auto Safety
Hotline toll-free at 1-800-424-9393 (or 366-0123 in
the Washington, D.C. area) or write to:
NHTSA, U.S. Department of Transportation
Washington, D.C. 20590
You can also obtain other information about motor
vehicle safety from the hotline.
Reporting Safety Defects to the
Canadian Government
If you live in Canada, and you believe that your vehicle
has a safety defect, you should immediately notify
Transport Canada, in addition to notifying General
Motors of Canada Limited. You may write to:
Transport Canada
330 Sparks Street
Tower C
Ottawa, Ontario K1A 0N5
Reporting Safety Defects to General
Motors
In addition to notifying NHTSA (or Transport Canada) in
a situation like this, we certainly hope you’ll notify us.
Please call us at 1-800-GMC-8782 (1-800-462-8782), or
write:
Pontiac-GMC Customer Assistance Center
P.O. Box 33172
Detroit, MI 48232-5172
In Canada, please call us at 1-800-263-3777 (English)
or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, 163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
7-9
2003 - Sierra Denali

A
Accessory Power Outlets.................................3-16
Adding Washer Fluid.......................................5-35
Additional Program Information........................... 7-8
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-91
Add-On Equipment..........................................4-50
Adjusting the Speakers (Balance/Fade)..............3-60
After Off-Road Driving.....................................4-30
Air Bag
Off Light.....................................................3-28
Passenger Status Indicator...........................3-31
Readiness Light..........................................3-27
Air Bag Systems.............................................1-55
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-71
Air Bag Off Switch.......................................1-61
How Does an Air Bag Restrain?....................1-59
Passenger Sensing System...........................1-66
Servicing Your Air Bag-Equipped Vehicle.........1-70
What Makes an Air Bag Inflate?....................1-59
What Will You See After an Air Bag Inflates?......1-59
When Should an Air Bag Inflate?...................1-58
Where Are the Air Bags?
..............................1-57
Air Cleaner/Filter, Engine
.................................5-18
Air Conditioning
..............................................3-21
All Overseas Locations
...................................... 7-4
All-Wheel Drive
...............................................5-45
All-Wheel Drive (AWD) System
.........................2-21AM ...............................................................3-76
Antenna, Fixed Mast.......................................3-78
Antenna, XM™ Satellite Radio Antenna System.....3-78
Anti-lock Brake System..................................... 4-6
Anti-Lock Brake, System Warning Light..............3-35
Appearance Care............................................5-82
Care of Safety Belts....................................5-84
Chemical Paint Spotting...............................5-88
Cleaning the Inside of Your Vehicle................5-83
Cleaning the Outside of Your Vehicle..............5-85
Finish Damage............................................5-87
GM Vehicle Care/Appearance Materials..........5-88
Sheet Metal Damage...................................5-87
Underbody Maintenance...............................5-87
Weatherstrips..............................................5-85
Approaching a Hill..........................................4-23
Ashtrays........................................................3-17
Audio System(s).............................................3-56
Audio Steering Wheel Controls......................3-76
Care of Your Cassette Tape Player................3-77
Care of Your CD Player...............................3-78
Care of Your CDs ........................................3-78
CD Changer
...............................................3-73
Fixed Mast Antenna
.....................................3-78
Navigation/Radio System
..............................3-70
Radio with Cassette and CD
.........................3-57
Rear Seat Audio (RSA)
................................3-71
Setting the Time
..........................................3-57
Theft-Deterrent Feature
................................3-75
Understanding Radio Reception
.....................3-76
1
2003 - Sierra Denali

Audio System(s) (cont.)
XM™Satellite Radio Antenna System............3-78
Automatic Headlamp System............................3-12
Automatic Transmission
Fluid..........................................................5-20
Operation...................................................2-19
Automatic Transmission Check..........................6-11
Automatic Transmission Shift Lock Control
System Check.............................................6-12
B
Backing Up....................................................4-58
Battery..........................................................5-39
BATTERY NOT CHARGING.............................3-52
Battery Replacement......................................... 2-5
Battery Run-Down Protection............................3-16
Battery Warning Light......................................3-33
Before Leaving on a Long Trip.........................4-37
Before You Go Off-Roading..............................4-18
Body Lubrication Service..................................6-11
Brake
Parking......................................................2-22
System Inspection.......................................6-15
System Warning Light..................................3-34
Brake Adjustment............................................5-38
Brake Fluid....................................................5-36
Brake Pedal Travel.........................................5-38
Brake Wear...................................................5-38
Brakes..........................................................5-36Braking........................................................... 4-5
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-15
Bulb Replacement...........................................5-48
Center High-Mounted Stoplamp (CHMSL)
and Cargo Lamp......................................5-52
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-49
Halogen Bulbs............................................5-48
Headlamps.................................................5-48
Pickup Box Identification and Fender
Marker Lamps.........................................5-54
Replacement Bulbs......................................5-55
Roof Marker Lamps.....................................5-51
Taillamps....................................................5-54
Buying New Tires...........................................5-60
C
California Fuel.................................................. 5-5
Canada........................................................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-6
Capacities and Specifications............................5-99
Car Washes for QUADRASTEER™Equipped
Vehicles.....................................................4-14
Carbon Monoxide...................4-40, 4-53, 2-10, 2-26
Care of
Safety Belts................................................5-84
Your Cassette Tape Player............................3-77
2
2003 - Sierra Denali

Care of (cont.)
Your CD Player...........................................3-78
Your CDs ...................................................3-78
Cargo Lamp...................................................3-14
CARGO LAMP ON .........................................3-54
Cassette Tape Messages.................................3-67
Cassette Tape Player Service...........................6-10
CD Adapter Kits.............................................3-68
CD Changer...................................................3-73
CD Functions.................................................3-74
Center Console Storage Area...........................2-39
Center High-Mounted Stoplamp (CHMSL)
and Cargo Lamp.........................................5-52
Center Instrument Panel Fuse Block..................5-94
Center Passenger Position, Safety Belts.............1-21
Chains, Tires..................................................5-64
CHANGE ENGINE OIL ....................................3-52
Check
Engine Light...............................................3-37
Check Engine Light.........................................3-37
CHECK OIL LEVEL .........................................3-54
CHECK WASHER FLUID .................................3-54
Checking Brake Fluid......................................5-37
Checking Coolant............................................5-24
Checking Engine Oil........................................5-13
Checking Things Under the Hood
......................5-10
Checking Your Restraint Systems
......................1-71
Chemical Paint Spotting
...................................5-88
Child Restraints
Child Restraint Systems
...............................1-35Child Restraints (cont.)
Infants and Young Children...........................1-31
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-42
Older Children.............................................1-29
Securing a Child Restraint Designed for the
LATCH System........................................1-45
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-47
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-45
Securing a Child Restraint in the Right Front
Seat Position...........................................1-49
Top Strap...................................................1-39
Top Strap Anchor Location............................1-40
Where to Put the Restraint...........................1-38
Cigarette Lighter.............................................3-17
Cleaning
Inside of Your Vehicle..................................5-83
Outside of Your Vehicle................................5-85
Underbody Maintenance...............................5-87
Weatherstrips..............................................5-85
Cleaning Aluminum or Chrome-Plated Wheels.....5-87
Cleaning Exterior Lamps/Lenses.......................5-85
Cleaning Fabric/Carpet....................................5-83
Cleaning Glass Surfaces..................................5-84
Cleaning Interior Plastic Components
.................5-84
Cleaning Leather
............................................5-83
Cleaning the Mirror
.........................................2-30
Cleaning the Top of the Instrument Panel
...........5-84
3
2003 - Sierra Denali

H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-5
Headlamp High/Low Beam Changer.................... 3-6
Headlamps....................................................5-48
Bulb Replacement.......................................5-48
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-49
Halogen Bulbs............................................5-48
Pickup Box Identification and Fender
Marker Lamps.........................................5-54
Roof Marker Lamps.....................................5-51
Heated Seats................................................... 1-3
Heating.........................................................3-22
Highway Hypnosis...........................................4-38
Hill and Mountain Roads..................................4-38
Hitches..........................................................4-57
HomeLink
®Transmitter, Programming................2-35
HomeLink®Transmitter....................................2-35
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn ............................................................... 3-5
How to Add Coolant to the Coolant Surge Tank......5-30
How to Add Fluid............................................5-22
How to Check........................................5-20, 5-57
How to Check Lubricant...................................5-46
How to Check Power Steering Fluid..................5-35How to Inspect...............................................5-18
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-12
Hydroplaning..................................................4-33
I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light is Flashing.....................................3-38
If the Light Is On Steady.................................3-38
If You Are Stuck in Sand, Mud, Ice or Snow.......4-44
If You Do Decide To Pull A Trailer.....................4-53
If You’re Caught in a Blizzard...........................4-42
Ignition Positions.............................................2-16
Ignition Transmission Lock Check......................6-13
Illuminated Visor Vanity Mirrors.........................2-13
Infants and Young Children, Restraints...............1-31
Inflation -- Tire Pressure..................................5-57
Inspection
Brake System
.............................................6-15
Engine Cooling System
................................6-14
Exhaust System
..........................................6-14
Fuel System
...............................................6-14
Part C - Periodic Maintenance
.......................6-14
Steering and Suspension
..............................6-14
Transfer Case and Front Axle
(All-Wheel Drive)
......................................6-15
7
2003 - Sierra Denali