2003 CHRYSLER SEBRING wheel

8
7/115 POWERTRAIN WARRANTY
The following powertrain components are covered for 7 years or 115,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date. A $100 deductible per repairvisit applies after the 3-year or 60,000-kilometre basic warrantyexpires (whichever occurs first). Vehicles placed in Police, Taxi,Limousine, Postal or Ambulance service are excluded from the 7-year or 115,000-kilometre powertrain warranty and are coveredonly under the 3-year or 60,000-kilometre basic warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only.
¥ Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .¥
Front-Wheel Drive Ð Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differentialcover; oil pan; transaxle speed sensors; transaxle solenoidassembly; PRNDL position switch; transaxle electronic controller;torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
¥ All-Wheel Drive (AWD) Ð Power transfer unit and all internal
parts; viscous coupler; axle housing and all internal parts;constant velocity joints and boots; drive shaft and axle shaftassemblies; differential carrier assembly and all internal parts;output ball bearing; output flange; end cover; overrunning clutch;vacuum motor; torque tube; pinion spacer and shim, seals andgaskets for listed components only.
7/115 POWERTRAIN WARRANTY
03Minivan and Car Maint 1/15/03 9:55 AM Page 8

12
WHAT IS NOT COVERED
WHAT IS NOT COVERED
DAMAGE FROMMISUSE ORACCIDENT
The warranties in this booklet do not cover repairs required due to fire, accidents, abuse, negligence, objects striking your vehicle,carrying corrosive materials (such as chemicals, acids andfertilizers), misuse (such as driving over curbs, overloading,spinning wheels, etc.), racing or participating in a racing event,improper disconnection of components, modifying the exhaustsystem, tampering or making adjustments which do not complywith DaimlerChrysler specifications.
Disconnecting, tampering with or changing the reading of the
odometer will void your warranties. D AMAGE FROMTHEENVIRONMENT
The warranties in this booklet do not cover fading or deterioration caused by exposure to the elements, or repairs required due toairborne fallout, acid rain, chemicals, tree sap, insects, bird or insectdroppings, salt, sand, gravel, road hazards, hail, windstorms,lightning, floods or any other event of nature. Road salt, car washes, scuffs and scratches, and everyday
abrasion from sand and dirt can affect the appearance of a vehicleÕs wheels (steel, chrome and aluminum) and other undercarriageparts. Some surface corrosion with use is normal; it is not a defectand is not covered by any warranty. N ORMAL MAINTENANCE ANDWEAR
The warranties in this booklet do not cover normal maintenance services, such as oil and filter changes, generallubrication, tire rotation, alignments, engine tune-ups and replacing spark plugs, light bulbs and fuses. Requiredmaintenance services are described in detail in your OwnerÕsManual and herein. The warranties also do not cover worn wiperblades, clutch discs, brake rotors, pads, linings or drums,windshield and rear window (unless they are defective, see
page 7).
03Minivan and Car Maint 1/15/03 9:55 AM Page 12

25
1.
POWER TRAIN PLANS
Plan 737 complements the powertrain factory warranty by eliminating the deductible and providing a car rental allowance.Plan 738 provides additional distance coverage. Major components covered are: ¥ engine ¥ transmission ¥ front-wheel drive ¥ rear-wheel drive¥ four-wheel drive (4x4) ¥ all-wheel-drive vehicles Maximum terms available on new vehicles registered in Canada only.
P LAN CODE TERM DEDUCTIBLE
Plan 737 7 years or 115,000 km* $0
Plan 7387 years or 160,000 km* $0
*Whichever comes first. Measured from the warranty start date (the original in-service date of the vehicle) and from zero metrage.
NOTE: Purchase price of contract plans varies. See dealer for further details. 2.
ÒG OLD Ó PLAN S
Each plan provides full mechanical repair protection to non-powertrain (Gold) components. Plans 705, 706 and 708 also provide fullmechanical protection against powertrain component repairs beyondyour vehicleÕs 7-year or 115,000-kilometre powertrain warrantycoverage. Contracts are available with or without a deductible. Major components covered are: ¥ steering ¥ air conditioning ¥ engine cooling and fuel ¥ frontsuspension ¥ rear suspension ¥ electrical ¥ hydraulic brakecomponents ¥ anti-lock brakes Maximum terms available on new vehicles registered in Canada only.
P LAN CODE TERM DEDUCTIBLE
Plan 702 3 years or 80,000 km* $0
Plan 7034 years or 100,000 km* $0
Plan 7045 years or 100,000 km* $0
Plan 7055 years or 120,000 km* $0
OPTIONAL DAIMLERCHRYSLER CANADA SERVICE CONTRACTS
03Minivan and Car Maint 1/15/03 9:55 AM Page 25

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
24,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-05-01 3N.
Maint enance Service Sc hedule ÒBÓ
24,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect and replace, if required, the air cleaner element (PT Cruiser and Neon only).
l Replace the engine air cleaner filter (Minivan, Concorde, Intrepid and 300M only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner(Neon and PT Cruiser only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 39

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible only).
l Inspect and replace, if required, the air cleaner element (PTCruiser and Neon only).
l Replace the engine air cleaner filter (Minivan, Concorde,Intrepid and 300M only).
l Inspect and replace, if required, the make-up air filter locatedinside the air cleaner (Neon and PT Cruiser only).
l Adjust the drive belt tension (Concorde, Intrepid and 300Monly).
l Inspect the generator belt, replace if necessary (2.4L Minivanonly).
l Inspect and adjust the power steering pump belt tension(2.4L Minivan only).
l Change the all-wheel-drive power transfer unit fluid(Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals thanshown in Schedule B if the vehicle is operated more than 50% at sustainedhigh speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow
or commercial service.Maint enance Service Sc hedule ÒBÓ
24,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 40

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
34,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-07-01 3N.
Maint enance Service Sc hedule ÒBÓ
34,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Change the all-wheel-drive overrunning clutch and rear carrier fluid (Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 43

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace ifnecessary (Minivan, Concorde, Intrepid and 300M only).
l Change the all-wheel-drive overrunning clutch and rearcarrier fluid (Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals thanshown in Schedule B if the vehicle is operated more than 50% at sustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or
commercial service.Maint enance Service Sc hedule ÒBÓ
34,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 44

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
48,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-10-01 3N.
Maint enance Service Sc hedule ÒBÓ
48,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Replace the make-up air filter located inside the air cleaner (Neon and PT Cruiser only).
l Adjust the drive belt tension (Concorde, Intrepid and 300M only).
l Adjust the generator belt tension (Neon and PT Cruiser only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Minivan, Neon and PT Cruiser only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 49