2003 CHRYSLER SEBRING timing belt

8
7/115 POWERTRAIN WARRANTY
The following powertrain components are covered for 7 years or 115,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date. A $100 deductible per repairvisit applies after the 3-year or 60,000-kilometre basic warrantyexpires (whichever occurs first). Vehicles placed in Police, Taxi,Limousine, Postal or Ambulance service are excluded from the 7-year or 115,000-kilometre powertrain warranty and are coveredonly under the 3-year or 60,000-kilometre basic warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only.
¥ Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .¥
Front-Wheel Drive Ð Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differentialcover; oil pan; transaxle speed sensors; transaxle solenoidassembly; PRNDL position switch; transaxle electronic controller;torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
¥ All-Wheel Drive (AWD) Ð Power transfer unit and all internal
parts; viscous coupler; axle housing and all internal parts;constant velocity joints and boots; drive shaft and axle shaftassemblies; differential carrier assembly and all internal parts;output ball bearing; output flange; end cover; overrunning clutch;vacuum motor; torque tube; pinion spacer and shim, seals andgaskets for listed components only.
7/115 POWERTRAIN WARRANTY
03Minivan and Car Maint 1/15/03 9:55 AM Page 8

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
144,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-30-01 3N.
Maint enance Service Sc hedule ÒBÓ
144,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Replace the make-up air filter located inside the air cleaner (Neon and PT Cruiser only).
l Adjust the generator belt tension (Neon and PT Cruiser only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Replace the engine timing belt (2.4L Minivan, Sebring and Sebring Convertible only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Minivan, Neon and PT Cruiser only).
lInspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 89

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Replace the engine air cleaner filter if required (all models).
l Replace the spark plugs (2.4L).
l Inspect the PCV valve and replace as necessary.
l Replace the make-up air filter located inside the air cleaner (Neon and PT Cruiser only).
l Adjust the generator belt tension (Neon and PT Cruiser only).
l Inspect the generator belt, replace if necessary (2.4L Minivanonly).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Replace the engine timing belt (2.4L Minivan, Sebring and Sebring Convertible only).
l Change the all-wheel-drive power transfer unit fluid (Minivanonly).*
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the tie rod ends and boot seals (Minivan, Neon and PT Cruiser only).
l
Inspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals thanshown in Schedule B if the vehicle is operated more than 50% at sustainedhigh speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow
or commercial service.
Maint enance Service Sc hedule ÒBÓ
144,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 90

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
158,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-33-01 3N.
Maint enance Service Sc hedule ÒBÓ
158,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the spark plugs (Concorde, Intrepid and 300M only).
l Flush and replace engine coolant at 60 months or 160,000 kilometres.
l Replace the engine timing belt (Concorde, Intrepid and 300M only).
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 95

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l nspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace ifnecessary (Minivan, Concorde, Intrepid and 300M only).
l Replace the spark plugs (Concorde, Intrepid and 300Monly).
l Flush and replace engine coolant at 60 months or160,000 kilometres.
l Replace the engine timing belt (Concorde, Intrepid and300M only).
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all except Sebring and Sebring Convertible).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
158,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 96

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
168,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-35-01 3N.
Maint enance Service Sc hedule ÒBÓ
168,0 00 km
lChange engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect and replace, if required, the air cleaner element (PT Cruiser and Neon only).
l Replace the engine air cleaner filter if required (Minivan, Concorde, Intrepid and 300M only).
l Replace the spark plugs (2.7L Sebring and Sebring Convertible only).
l Inspect and replace, if required, the make-up air filter located inside the air cleaner (Neon and PT Cruiser only).
l Replace the accessory drive belts (2.7L Sebring, Sebring Convertible only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4L Minivan only).
l Replace the engine timing belt (2.4L PT Cruiser only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
l Change the all-wheel-drive overrunning clutch and rear carrier fluid (Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals than shown in Schedule B if the vehicle is operated more than 50% atsustained high speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow or commercial service.
03Minivan and Car Maint 1/15/03 9:55 AM Page 99

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary(Sebring, Sebring Convertible only).
l Inspect and replace, if required, the air cleaner element (PT Cruiser and Neon only).
l Replace the engine air cleaner filter if required (Minivan,Concorde, Intrepid and 300M only).
l Replace the spark plugs (2.7L Sebring and Sebring Convertibleonly).
l Inspect and replace, if required, the make-up air filter locatedinside the air cleaner (Neon and PT Cruiser only).
l Check and retention accessory drive belts (2.7L Sebring, SebringConvertible only).
l Inspect the generator belt, replace if necessary (2.4L Minivan only).
l Inspect and adjust the power steering pump belt tension (2.4LMinivan only).
l Replace the engine timing belt (2.4L PT Cruiser only).
l Change the all-wheel-drive power transfer unit fluid (Minivan only).*
l Change the all-wheel-drive overrunning clutch and rear carrierfluid (Minivan only).*
INSPECT THE FOLLOWING: l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
* All-wheel-drive minivans power transfer unit fluid and overrunning clutch/rear carrier fluid must be changed at more frequent intervals thanshown in Schedule B if the vehicle is operated more than 50% at sustainedhigh speeds during hot weather, above 32 ¡C (90 ¡F) or if used for trailer tow
or commercial service.Maint enance Service Sc hedule ÒBÓ
168,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 100