2003 CHRYSLER PT CRUISER differential

8
7/115 POWERTRAIN WARRANTY
The following powertrain components are covered for 7 years or 115,000 kilometres, whichever occurs first, measured from thevehicleÕs original warranty start date. A $100 deductible per repairvisit applies after the 3-year or 60,000-kilometre basic warrantyexpires (whichever occurs first). Vehicles placed in Police, Taxi,Limousine, Postal or Ambulance service are excluded from the 7-year or 115,000-kilometre powertrain warranty and are coveredonly under the 3-year or 60,000-kilometre basic warranty. ¥ Engine Ð Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing;intake and exhaust manifolds; flywheel with starter ring gear; coreplugs; valve covers; oil pan; turbocharger housing and internalparts; turbocharger wastegate actuator; supercharger; serpentinebelt tensioner; seals and gaskets for listed components only.
¥ Transmission Ð Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;transmission control module; bell housing; oil pan; seals andgaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time .¥
Front-Wheel Drive Ð Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differentialcover; oil pan; transaxle speed sensors; transaxle solenoidassembly; PRNDL position switch; transaxle electronic controller;torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
¥ All-Wheel Drive (AWD) Ð Power transfer unit and all internal
parts; viscous coupler; axle housing and all internal parts;constant velocity joints and boots; drive shaft and axle shaftassemblies; differential carrier assembly and all internal parts;output ball bearing; output flange; end cover; overrunning clutch;vacuum motor; torque tube; pinion spacer and shim, seals andgaskets for listed components only.
7/115 POWERTRAIN WARRANTY
03Minivan and Car Maint 1/15/03 9:55 AM Page 8

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
77,000 km
Dealer copy.
Remove and attach to Repair Order 26-92-16-01 3N.
Maint enance Service Sc hedule ÒBÓ
77 ,000 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and 300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 61

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace ifnecessary (Minivan, Concorde, Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
77 ,000 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 62

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
154,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-32-01 3N.
Maint enance Service Sc hedule ÒBÓ
154,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and 300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 93

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace ifnecessary (Minivan, Concorde, Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (Sebring and Sebring Convertible only).
l Inspect the brake hoses.
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
154,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 94

Maintenance Service
Sc hedule ÒBÓ
Odometer Reading
Date
230,0 00 km
Dealer copy.
Remove and attach to Repair Order 26-92-48-01 3N.
Maint enance Service Sc hedule ÒBÓ
230,0 00 km
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering and suspension components.
l Inspect the engine air cleaner filter and replace if necessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace if necessary (Minivan, Concorde,Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and 300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all models).
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plug condition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.
03Minivan and Car Maint 1/15/03 9:55 AM Page 125

Odometer Reading
Date
Repair Order No.
DAIMLER CHR YSLER
D EALER STAMP
Signature of authorized DaimlerChrysler Canada dealer
l Change engine oil and engine oil filter (or every 3 months).
l Inspect and lubricate as required all steering andsuspension components.
l Inspect the engine air cleaner filter and replace ifnecessary (Sebring, Sebring Convertible only).
l Inspect the engine air cleaner filter and replace ifnecessary (Minivan, Concorde, Intrepid and 300M only).
l Replace the air conditioning filter (Minivan only).
l Change the automatic transaxle fluid and filter.
l Replace the differential fluid (Concorde, Intrepid and300M only).
l Tires Ð Rotate and check tire pressure.
INSPECT THE FOLLOWING: l Inspect the front and rear brake linings and components (all models).
l Check the automatic transaxle fluid level.
l Check the manual transaxle fluid level and fill plugcondition.
l Check the coolant level, hoses and clamps.
l Inspect the exhaust system.Maint enance Service Sc hedule ÒBÓ
230,0 00 km
03Minivan and Car Maint 1/15/03 9:55 AM Page 126