2003 CHEVROLET TAHOE steering

Center Instrument Panel Fuse Block
The center instrument panel utility block is located
underneath the instrument panel, to the left of the
steering column.
Device Usage
SEO Special Equipment Option
TRAILER Trailer Brake Wiring
UPFIT Up®tter (Not Used)
SL RIDERide Control Harness
Connection
HDLR 2 Headliner Wiring Connector
BODY Body Wiring Connector
DEFOG Rear Defogger Relay
HDLNR 1 Headliner Wiring Connector 1
SPARE RELAY Not Used
CB SEATDriver and Passenger Seat
Module Circuit Breaker
CB RT DOORRight Power Window Circuit
Breaker
SPARE Not Used
INFOInfotainment Harness
Connection
5-112

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Your Vehicle and the Environment....................6-2
Maintenance Requirements..............................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using Your Maintenance Schedule....................6-4
Scheduled Maintenance...................................6-5
Part B: Owner Checks and Services................6-11
At Each Fuel Fill..........................................6-11
At Least Once a Month.................................6-11
At Least Twice a Year...................................6-12
At Least Once a Year...................................6-13Part C: Periodic MaintenanceInspections.........6-16
Steering and Suspension Inspection................6-16
Exhaust System Inspection............................6-16
Fuel System Inspection..................................6-16
Engine Cooling System Inspection...................6-17
Transfer Case and Front Axle (Four-Wheel
Drive) Inspection.......................................6-17
Brake System Inspection................................6-17
Part D: Recommended Fluids and Lubricants. . . .6-18
Part E: Maintenance Record...........................6-20
Section 6 Maintenance Schedule
6-1

If the system is ever reset accidentally, you must
change your oil at 3,000 miles (5 000 km) since your
last oil change. Remember to reset the oil life system
whenever the oil is changed. See
Engine Oil on
page 5-18for information on resetting the system.
An Emission Control Service.
Lubricate chassis components with each engine oil
and ®lter change.
Lubricate the front suspension, ball joints, steering
linkage, transmission shift linkage, transfer case shift
linkage and parking brake cable guides. Ball joints
should not be lubricated unless their temperature is
10ÉF (-12ÉC) or higher, or they could be damaged.
See the mileage intervals following for additional
services that may be performed with an engine oil
change and chassis lubrication. After the services are
performed, record the date, odometer reading and
who performed the service on the maintenance record
pages in Part E of this schedule.
7,500 Miles (12 500 km)
qCheck rear/front axle ¯uid level and add ¯uid as
needed. Check constant velocity joints and axle seals
for leaking.
qRotate tires. See
Tire Inspection and Rotation on
page 5-69for proper rotation pattern and additional
information.(See footnote +.)
15,000 Miles (25 000 km)
qInspect engine air cleaner ®lter or change indicator
(if equipped). If necessary, replace the ®lter. If
vehicle is driven in dusty/dirty conditions, inspect
®lter or change indicator (if equipped) at every engine
oil change. See
Engine Air Cleaner/Filter on
page 5-23for more information.An Emission Control
Service. (See footnote ².)
qCheck rear/front axle ¯uid level and add ¯uid as
needed. Check constant velocity joints and axle seals
for leaking.
qRotate tires. See
Tire Inspection and Rotation on
page 5-69for proper rotation pattern and additional
information.(See footnote +.)
22,500 Miles (37 500 km)
qCheck rear/front axle ¯uid level and add ¯uid as
needed. Check constant velocity joints and axle seals
for leaking.
qRotate tires. See
Tire Inspection and Rotation on
page 5-69for proper rotation pattern and additional
information.(See footnote +.)
6-6

Part C: Periodic
MaintenanceInspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-11.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-43.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
6-16

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil with the American
Petroleum Institute Certi®ed for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see
Engine Oil on
page 5-18.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
žCoolant. SeeEngine
Coolant on page 5-29.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent or
equivalent.
Usage Fluid/Lubricant
Power Steering
SystemGM Power Steering Fluid (GM Part
No. U.S. 1052884, in Canada
993294, or equivalent).
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474, or equivalent).
Chassis
LubricationChassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Axle
(Four-Wheel
Drive)SAE 80W-90 Axle Lubricant (GM
Part No. U.S. 1052271, in Canada
10950849 or equivalent).
Front Axle
(All-Wheel
Drive)SAE 75W-90 Synthetic Axle
Lubricant (GM Part No. U.S.
12378261, in Canada 10953455) or
equivalent meeting GM Speci®cation
9986115.
6-18

In Canada, please call us at 1-800-263-3777 (English)
or 1-800-263-7854 (French). Or, write:
General Motors of Canada Limited
Customer Communication Centre, 163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle, suspension,
brakes, electrical, steering, body, etc.
RETAIL SELL PRICE: $120.00
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit repair service
procedures, adjustments, and speci®cations for GM
transmissions, transaxles, and transfer cases.
RETAIL SELL PRICE: $50.00
Service Bulletins
Service Bulletins give technical service information
needed to knowledgeably service General Motors cars
and trucks. Each bulletin contains instructions to
assist in the diagnosis and service of your vehicle.
In Canada, information pertaining to Product Service
Bulletins can be obtained by contacting your General
Motors dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483).
7-11

A
Accessory Power Outlets.................................3-19
Adding Washer Fluid.......................................5-44
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment...........................5-108
Adjustable Throttle and Brake Pedal..................2-24
Adjusting the Speakers (Balance/Fade).....3-75, 3-79,
3-90, 3-104
After Off-Road Driving.....................................4-40
Air Bag Systems.....................................1-73, 1-80
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-88
How Does an Air Bag Restrain?....................1-80
Passenger Sensing System...........................1-83
Servicing Your Air Bag-Equipped Vehicle.........1-87
What Makes an Air Bag In¯ate?....................1-80
What Will You See After an Air Bag In¯ates?......1-81
When Should an Air Bag In¯ate?...................1-79
Where Are the Air Bags?..............................1-76
Air Bag .........................................................3-39
Passenger Status Indicator...........................3-39
Readiness Light..........................................3-39
Air Cleaner/Filter, Engine.................................5-23
Air Conditioning..............................................3-28
All-Wheel Drive with Stabilitrak
ž........................2-34All-Wheel Drive...............................................5-55
AM-FM Radio.................................................3-73
AM .............................................................3-127
Antenna, Fixed Mast......................................3-129
Antenna, XMŸ Satellite Radio
Antenna System........................................3-129
Anti-Lock Brake, System Warning Light..............3-44
Anti-lock Brake System..................................... 4-7
Appearance Care............................................5-99
Care of Safety Belts...................................5-102
Chemical Paint Spotting..............................5-105
Cleaning the Inside of Your Vehicle................5-99
Cleaning the Outside of Your Vehicle............5-102
Finish Damage..........................................5-104
Sheet Metal Damage..................................5-104
Underbody Maintenance.............................5-105
Vehicle Care/Appearance Materials...............5-105
Weatherstrips............................................5-102
Approaching a Hill..........................................4-30
Ashtrays........................................................3-20
Audio Output................................................3-121
Audio System(s).............................................3-72
AM-FM Radio.............................................3-73
Audio Steering Wheel Controls....................3-126
Care of Your Cassette Tape Player...............3-127
Care of Your CD and DVD Player................3-129
1

Engine (cont.)
Coolant Temperature Gage...........................3-45
Coolant......................................................5-29
Cooling System Inspection............................6-17
Exhaust.....................................................2-43
Fan Noise..................................................5-42
Oil .............................................................5-18
Overheating................................................5-33
Starting......................................................2-23
Entering or Exiting the Third Row Seats.............. 1-9
Entertainment System....................................3-129
Cleaning the Video Screen..........................3-129
DVD Distortion..........................................3-126
Entry Lighting.................................................3-17
Environmental Concerns..................................4-27
Erasing HomeLink
žButtons..............................2-60
Exit Lighting...................................................3-17
Express-Down Windows...................................2-17
Extender, Safety Belt.......................................1-46
Exterior Lamps...............................................3-14
F
Filter.............................................................5-23
Engine Air Cleaner......................................5-23
Finding a PTY Station
(RDS and XMŸ).......................3-80, 3-91, 3-104Finding a Station..................3-74, 3-78, 3-89, 3-102
Finish Care..................................................5-103
Finish Damage.............................................5-104
Fixed Mast Antenna.......................................3-129
Flash-To-Pass.................................................. 3-8
Flat Tire, Changing.........................................5-77
Flat Tire........................................................5-76
Fluid.............................................................5-26
Automatic Transmission................................5-26
Power Steering...........................................5-43
Windshield Washer......................................5-44
FM Stereo....................................................3-127
Fog Lamps....................................................3-16
Folding the Seatback.......................................1-16
Folding the Seatbacks.....................1-10, 1-12, 1-21
Following Distance..........................................4-74
Footnotes........................................................ 6-5
Four-Wheel Drive....................................2-29, 5-57
Four-Wheel-Drive Light....................................3-51
Front Axle Locking Feature...............................2-30
Front Axle......................................................5-58
Front Reading Lamps......................................3-18
Front Storage Area.........................................2-61
Frontal Air Bags.............................................1-79
Fuel Information Button....................................3-57
FUEL LEVEL LOW.........................................3-67
7