2003 CHEVROLET TAHOE coolant level

{CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol
and it will burn if the engine parts are hot
enough. Do not spill coolant on a hot engine.
1. Park the vehicle on a
level surface. You can
remove the coolant
surge tank pressure
cap when the cooling
system, including
the coolant surge tank
pressure cap and
upper radiator hose, is
no longer hot.2. Turn the pressure cap slowly counterclockwise
(left) about one full turn. If you hear a hiss,
wait for that to stop. A hiss means there is still
some pressure left.
3. Then keep turning the pressure cap slowly, and
remove it.
5-40

4. Then ®ll the coolant surge tank with the proper
mixture, to the FULL COLD mark.5. With the coolant surge tank pressure cap off, start
the engine and let it run until you can feel the upper
radiator hose getting hot. Watch out for the
engine cooling fan.
By this time, the coolant level inside the coolant
surge tank may be lower. If the level is lower, add
more of the proper mixture to the coolant surge tank
until the level reaches the FULL COLD mark.
5-41

How to Check Power Steering Fluid
Turn the key off, let the engine compartment cool down,
wipe the cap and the top of the reservoir clean, then
unscrew the cap and wipe the dipstick with a clean rag.
Replace the cap and completely tighten it. Then remove
the cap again and look at the ¯uid level on the dipstick.
The level should be at the FULL COLD mark.
If necessary, add only enough ¯uid to bring the level up
to the mark.
What to Use
To determine what kind of ¯uid to use, seePart D:
Recommended Fluids and Lubricants on page 6-18.
Always use the proper ¯uid. Failure to use the proper
¯uid can cause leaks and damage hoses and seals.
Windshield Washer Fluid
What to Use
When you need windshield washer ¯uid, be sure to read
the manufacturer's instructions before use. If you will
be operating your vehicle in an area where the
temperature may fall below freezing, use a ¯uid that has
sufficient protection against freezing. See
Engine
Compartment Overview on page 5-14for reservoir
location.
Adding Washer Fluid
Open the cap with the
washer symbol on it. Add
washer ¯uid until the
tank is full.
Notice:
·When using concentrated washer ¯uid, follow
the manufacturer's instructions for adding
water.
·Don't mix water with ready-to-use washer ¯uid.
Water can cause the solution to freeze and
damage your washer ¯uid tank and other parts
of the washer system. Also, water doesn't
clean as well as washer ¯uid.
·Fill your washer ¯uid tank only three-quarters
full when it's very cold. This allows for
expansion if freezing occurs, which could
damage the tank if it is completely full.
·Don't use engine coolant (antifreeze) in your
windshield washer. It can damage your
washer system and paint.
5-44

97,500 Miles (162 500 km)
qCheck rear/front axle ¯uid level and add ¯uid as
needed. Check constant velocity joints and axle seals
for leaking.
qRotate tires. See
Tire Inspection and Rotation on
page 5-69for proper rotation pattern and additional
information.(See footnote +.)
100,000 Miles (166 000 km)
qInspect spark plug wires.An Emission Control
Service.
qReplace spark plugs.An Emission Control Service.
qChange automatic transmission ¯uid and ®lter if
the vehicle's GVWR is over 8,600 lbs or if the vehicle
is mainly driven under one or more of these
conditions:
þ In heavy city traffic where the outside
temperature regularly reaches 90ÉF (32ÉC) or
higher.
þ In hilly or mountainous terrain.
þ When doing frequent trailer towing.
þ Uses such as found in taxi, police or delivery
service.qIf you haven't used your vehicle under severe service
conditions listed previously and, therefore, haven't
changed your automatic transmission ¯uid, change
both the ¯uid and ®lter.
qChange transfer case ¯uid.
qExcept 8.1L V8 Engine: Inspect Positive Crankcase
Ventilation (PCV) valve.
An Emission Control
Service.
150,000 Miles (240 000 km)
qDrain, ¯ush and re®ll cooling system (or every
60 months since last service, whichever occurs ®rst).
See
Engine Coolant on page 5-29for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service.
qInspect engine accessory drive belt.An Emission
Control Service.
6-10

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals speci®ed to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any ¯uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
in Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel ®ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-18for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOLž
coolant mixture if necessary. SeeEngine Coolant
on page 5-29for further details.
Windshield Washer Fluid Level Check
Check the windshield washer ¯uid level in the windshield
washer tank and add the proper ¯uid if necessary.
See
Windshield Washer Fluid on page 5-44for further
details.
At Least Once a Month
Tire In¯ation Check
Visually inspect your tires and make sure tires are
in¯ated to the correct pressures. Don't forget to check
your spare tire. See
Tires on page 5-67for further
details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every 50 hours of tape play. SeeAudio System(s)
on page 3-72for further details.
6-11

Braking........................................................... 4-6
Break-In, New Vehicle.....................................2-21
Bucket Seats, Rear.........................................1-21
BUCKLE PASSENGER....................................3-65
BUCKLE SEATBELT.......................................3-65
Bulb Replacement...........................................5-59
Front Turn Signal, Sidemarker and Daytime
Running Lamps........................................5-61
Halogen Bulbs............................................5-59
Headlamps.................................................5-60
Replacement Bulbs......................................5-66
Roof Marker Lamps.....................................5-62
Side Identi®cation Marker Lamps...................5-62
Taillamps....................................................5-64
Buying New Tires...........................................5-71
C
California Fuel.................................................. 5-6
Canada ± Customer Assistance.......................... 7-5
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-8
Capacities and Speci®cations..........................5-118
Car Washes for QUADRASTEERŸ Equipped
Vehicles.....................................................4-19
Carbon Monoxide...................4-51, 4-65, 2-14, 2-43Care of........................................................5-102
Safety Belts..............................................5-102
Your Cassette Tape Player..........................3-127
Your CD and DVD Player...........................3-129
Your CDs and DVDs..................................3-128
Cargo Cover..................................................2-64
Cargo Tie Downs............................................2-64
Cassette Tape Messages.................................3-97
Cassette Tape Player Service...........................6-11
CD Adapter Kits.............................................3-98
Center Console Storage Area...........................2-62
Center Instrument Panel Fuse Block................5-112
Center Passenger Position, Safety Belts.............1-39
Chains, Tires..................................................5-76
CHANGE ENGINE OIL....................................3-65
Check Engine Light.........................................3-47
CHECK OIL LEVEL.........................................3-66
CHECK TIRE PRESSURE...............................3-66
CHECK WASHER FLUID.................................3-66
Checking Brake Fluid......................................5-46
Checking Coolant............................................5-31
Checking Engine Oil........................................5-18
Checking Things Under the Hood......................5-12
Checking Your Restraint Systems......................1-88
Check...........................................................3-47
Engine Light...............................................3-47
3

Driving in Mud, Sand, Snow or Ice....................4-38
Driving in Water..............................................4-39
Driving On Grades..........................................4-75
Driving on Off-Road Hills.................................4-30
Driving on Snow or Ice....................................4-52
Driving Through Deep Standing Water...............4-44
Driving Through Flowing Water.........................4-44
Driving Uphill..................................................4-31
Driving with a Trailer.......................................4-73
Driving..........................................................4-40
At Night.....................................................4-40
City...........................................................4-45
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-46
Hill and Mountain Roads..............................4-49
In Rain and on Wet Roads...........................4-42
Winter........................................................4-51
Dual Automatic Climate Control System.............3-25
Dual Climate Control System............................3-21
DVD Player..................................................3-114
DVD ............................................................3-129
Cleaning the Video Screen..........................3-129
Distortion..................................................3-126
Rear Seat Entertainment System..................3-114E
Easy Exit Seat...............................................2-67
Electrical System...........................................5-108
Add-On Equipment.....................................5-108
Fuses and Circuit Breakers.........................5-109
Power Windows and Other Power Options....5-108
Windshield Wiper Fuses.............................5-108
Electrochromic Mirror Operation................2-46, 2-49
Emissions Inspection and
Maintenance Programs.................................3-50
ENGINE COOLANT HOT.................................3-66
Engine Coolant Level Check.............................6-11
Engine Hour Meter Display...............................3-38
Engine Oil Additives........................................5-21
Engine Oil and Chassis Lubrication Scheduled
Maintenance................................................. 6-5
Engine Oil Level Check...................................6-11
ENGINE OVERHEATED..................................3-66
Engine..........................................................5-23
Air Cleaner/Filter.........................................5-23
Battery.......................................................5-48
Check and Service Engine Soon Light............3-47
Compartment Overview................................5-14
Coolant Heater............................................2-24
6

Engine (cont.)
Coolant Temperature Gage...........................3-45
Coolant......................................................5-29
Cooling System Inspection............................6-17
Exhaust.....................................................2-43
Fan Noise..................................................5-42
Oil .............................................................5-18
Overheating................................................5-33
Starting......................................................2-23
Entering or Exiting the Third Row Seats.............. 1-9
Entertainment System....................................3-129
Cleaning the Video Screen..........................3-129
DVD Distortion..........................................3-126
Entry Lighting.................................................3-17
Environmental Concerns..................................4-27
Erasing HomeLink
žButtons..............................2-60
Exit Lighting...................................................3-17
Express-Down Windows...................................2-17
Extender, Safety Belt.......................................1-46
Exterior Lamps...............................................3-14
F
Filter.............................................................5-23
Engine Air Cleaner......................................5-23
Finding a PTY Station
(RDS and XMŸ).......................3-80, 3-91, 3-104Finding a Station..................3-74, 3-78, 3-89, 3-102
Finish Care..................................................5-103
Finish Damage.............................................5-104
Fixed Mast Antenna.......................................3-129
Flash-To-Pass.................................................. 3-8
Flat Tire, Changing.........................................5-77
Flat Tire........................................................5-76
Fluid.............................................................5-26
Automatic Transmission................................5-26
Power Steering...........................................5-43
Windshield Washer......................................5-44
FM Stereo....................................................3-127
Fog Lamps....................................................3-16
Folding the Seatback.......................................1-16
Folding the Seatbacks.....................1-10, 1-12, 1-21
Following Distance..........................................4-74
Footnotes........................................................ 6-5
Four-Wheel Drive....................................2-29, 5-57
Four-Wheel-Drive Light....................................3-51
Front Axle Locking Feature...............................2-30
Front Axle......................................................5-58
Front Reading Lamps......................................3-18
Front Storage Area.........................................2-61
Frontal Air Bags.............................................1-79
Fuel Information Button....................................3-57
FUEL LEVEL LOW.........................................3-67
7