2003 BMW MOTORRAD F 650 CS fuel pump

1
23
Safety check
2
Engine oil
Checking oil level
e Attention:
The red warning light
p (b7)
for engine oil pressure indicates
that the oil pump is delivering
very little oil or none at all: do
not regard this light as an oil
level indicator. Oil pressure
builds up after 1 – 2 seconds
and the warning light goes out –
the red engine oil pressure
warning light
p should remain
off when the engine is running.
Check the oil level regularly,
each time you stop for fuel (or
every second time at the latest).
e Attention:
The dipstick might show a low
oil level if the motorcycle has
been out of use for a lengthy
period. Under these circum-
stances top up the oil level only
after measuring the oil level in
accordance with the instruc-
tions.
Check the oil level only when
the engine is at operating tem-
perature.
Checking the oil level when the
engine is cold, just after the en-
gine has been run briefly or
when it is not properly warm will
falsify the reading, and could
lead to the engine being operat-
ed with the wrong quantity of oil
in the system.
10K14bkg2.book Seite 23 Montag, 15. September 2003 5:30 17

26
Safety check
2
Refuelling
d Warning:
Fuel is flammable and explo-
sive. Do not smoke. Never
bring a naked flame near the
fuel tank.
Fuel expands when hot (for
instance if the fuel tank is in
the sun). Consequently, add
fuel only until the pump noz-
zle automatically cuts off the
supply.
e Attention:
Leaded fuel will destroy the cat-
alytic converter.
Do not run the fuel tank dry or
you may damage the engine or
catalytic converter.
Wipe off plastic parts immedi-
ately if they are wetted with fuel.
Fuel
10K14bkg2.book Seite 26 Montag, 15. September 2003 5:30 17

1
27
Safety check
2
 Prop the motorcycle on its side stand
– Make sure the ground is level and firm.
 Open the fuel filler cap
Refuel
e Attention:
Add fuel only until the pump
nozzle automatically cuts off the
supply
– Always use regular unleaded fuel to DIN 51607 or equiva-
lent standard, min. octane
number 91 (RON) or 81 (MON)
e Attention:
Always use the key to lock the
fuel filler cap.
 Close the fuel filler cap
Capacity– Usable tank capacity 15 litres
–A yellow warning light 1
comes on when there are
approximately 4 litres (0.9 gal)
of fuel left in the tank
Fuel
1
10K14bkg2.book Seite 27 Montag, 15. September 2003 5:30 17

3
56
Starting – Riding – ParkingSwitch on the ignition– Kill switch3 in the run
position
U
 Ignition switch 1 in the ON
position
 Wait until the warning light for
coolant temperature (
b7)
stops flashing
In an emergency only:
 Move kill switch 3 to position
V
– The electronic engine man-
agement, fuel pump and
starter motor electrical cir-
cuits are de-energised
Fully retract the side stand
L Note:
If the side stand is extended
and a gear engaged, you can-
not start the motorcycle.
Select neutral– Neutral indicator light 2
green
k ON
L Note:
Engine does not start:
– Move the gear lever to the
k
position or disengage the
clutch
Engine stops when first gear is
engaged:
– Fully retract the side stand; if
necessary, consult the trou-
bleshooting chart (
b Mainte-
nance Instructions, Chapter 2)
Before you start
12
10K1403g2.fm Seite 56 Montag, 29. September 2003 4:15 16