2002 YAMAHA TW200 gas type

7-1
EAU01010
CLEANING AND STORAGE
1
2
3
4
5
6
7
8
9
EAU01301A. CLEANING
Frequent, thorough cleaning of
your motorcycle will not only
enhance its appearance but will
improve its
general performance and extend
the useful life of many compo-
nents.
ECA00002
cC
8Improper cleaning can damage
the cowlings, panels and other
plastic parts. Use only a soft,
clean cloth or sponge with
mild detergent and water to
clean plastic.
8Do not use any harsh chemical
products on plastic parts. Be
sure to avoid using cloths or
sponges which have been in
contact with strong or abra-
sive cleaning products, solvent
or thinner, fuel (gasoline), rust
removers or inhibitors, brake
fluid, antifreeze or electrolyte.
EC000111
cC
Excessive hose pressure may
cause water seepage and deterio-
ration of wheel bearings, front
fork, brakes, transmission seals
and electrical parts.
Many expensive repair bills have
resulted from improper high pres-
sure detergent applications such
as those available in coin-operated
car washers.
4. After riding on salted roads,
wash the motorcycle with cold
water immediately. Do not use
warm water as it increases the
chemical reaction of the salt.
5. Once the majority of the dirt
has been hosed off, wash all
surfaces with warm water and
mild, detergent-type soap. An
old toothbrush or bottle brush
is handy for hard-to-get-at
places. 1. Before cleaning the motorcy-
cle:
a. Block off the end of the
exhaust pipe to prevent water
entry; a plastic bag and strong
rubber band may be used.
b. Make sure the spark plug and
all filler caps are properly
installed.
2. If the engine case is excessive-
ly greasy, apply degreaser
with a paint brush. Do not
apply degreaser to the chain,
sprockets or wheel axles.
3. Rinse the dirt and degreaser
off with a garden hose. Use
only enough pressure to do
the job.
5FY-9-E0 (TW200) 7/29/02 10:54 AM Page 65

8-1
EAU01038
SPECIFICATIONS
1
2
3
4
5
6
7
8
9
Specifications
Model TW200E
Dimensions:
Overall length 2,090 mm
Overall width 815 mm
Overall height 1,115 mm
Seat height 790 mm
Wheel base 1,325 mm
Ground clearance 250 mm
Minimum turning radius 1,900 mm
Basic weight (With oil and full
fuel tank):126 kg
Engine:
Engine type Air-cooled 4-stroke, SOHC,
gasoline
Cylinder arrangement Forward inclined
single cylinder
Displacement 196 cm
3
Bore ×Stroke 67.0 ×55.7 mm
Compression ratio 9.5:1
Starting system Electric and kick starter
Lubrication system Wet sumpEngine oil:
Type:
Classification API Service “SE”, “SF” type
or equivalent
(e.g. “SF-SE”, “SF-SE-CC”,
“SF-SE-SD” etc.)
Capacity:
Periodic oil change 1.0 L
With oil filter replacement 1.1 L
Total amount 1.3 L
Air filter:Wet type element
Fuel:
Type Regular gasoline
Fuel tank capacity 7.0 L
Reserve amount 1.7 L
Carburetor:
Type / quantity Y29P-5C / 1
Manufacturer TEIKEI
–10° 0° 10° 20° 30° 40°
SAE 10W/30
SAE 10W/40
SAE 20W/40
SAE 20W/50C
5FY-9-E0 (TW200) 7/29/02 10:54 AM Page 67

8-3
SPECIFICATIONS
1
2
3
4
5
6
7
8
9
Wheels:
Type:
Front Spoke wheel
Rear Spoke wheel
Size:
Front 18 ×2.50
Rear 14M/C ×MT4.50
Brakes:
Front:
Type Drum brake
Operation Right hand operation
Rear:
Type Drum brake
Operation Right foot operation
Suspension:
Front Telescopic fork
Rear Swingarm
(Monocross suspension)
Shock absorber:
Front Coil spring / oil damper
Rear Coil-gas spring / oil damper
Wheel travel:
Front 160 mm
Rear 150 mmElectrical:
Ignition system: C.D.I.
Charging system:
Type A.C. magneto
Standard output 12V 11A / 5,000 rpm
Battery:
Type GM7CZ-3D
Voltage, capacity 12V 7 AH
Headlight typeHalogen bulb
Bulb voltage, wattage ×quantity:
Headlight 12V 35W / 35W ×1
Stop / tail light 12V 27W / 8W ×1
Front flasher light 12V 27W / 8W ×2
Rear flasher light 12V 27W ×2
Meter light 12V 3.4W ×1
Neutral indicator light 12V 3.4W ×1
High beam indicator light 12V 3.4W ×1
Turn indicator light 12V 3.4W ×1
Fuse:
Main 15A
5FY-9-E0 (TW200) 7/29/02 10:54 AM Page 69