2002 VOLVO S80 suspension

tire damage.
Wear indicator
The tires have wear indicator strips runnin across or paralle to the tread. When approx. 1/16" (1.6 mm) is left on the
tread, these strips become visible and indicate that the tire should be replaced.
Tires with less than 1/16" (1.6 mm) tread have a very poor grip in rain
or snow.
When replacing worn tires, it is recommended that the tire be identical in type (radial) and size as the one being
replaced. Using a tire of the same make (manufacturer) will prevent alteration of the driving characteristics of the
vehicle.
To improve tire economy:
· Maintain correct tire pressure. See the tire pressure label on the inside of the fuel filler door.
· Drive smoothly: avoid fast starts, hard braking and tire screeching.
· Tire wear increases with speed.
· Correct front wheel alignment is very important.
· Unbalanced wheels impair tire economy and driving comfort.
· Volvo does not recommend rotating the tires. If tires are rotated, they must be kept on the same side of the car so that
they revolve in the same direction as before rotation.
· Hitting curbs or potholes can damage the tires and/or wheels permanently.
Flat spots
All tires become warm during use. After cooling, when the vehicle is parked, the tires have a tendency to distort
slightly, forming flat spots. These flat spots can cause vibrations similar to the vibrations caused by unbalanced wheels.
They do, however, disappear when the tire warms up. The degree to which flat spots form depends on the type of cord
used in the tire. In cold weather, it takes longer for the tire to warm up and consequently longer for the flat spot to
disappear.
CAUTION:
The car must not be driven with wheels of different dimensions or with a spare tire other than the one that came with
the car. The use of different size wheels can seriously damage your car's transmission.
pg. 89 Wheels and tires
Snow chains
Snow chains can be used on your Volvo with the following restrictions:
· Snow chains should be installed on front wheels only. Use only Volvo approved snow chains.
· Special snow chains must be mounted on 215/55 R16, 225/55 R16 and 225/50 R17 tires. Consult your Volvo retailer.
· If accessory, aftermarket or "custom" tires and wheels are installed and are of a size different than the original tires
and wheels, chains in some cases CANNOT be used. Sufficient clearances between chains and brakes, suspension and
body components must be maintained.
· Some strapon type chains will interfere with brake components and therefore CANNOT be used.
ProCarManuals.com

2 0 0 2
VOLVO S80
Chapter 9 - Specifications
pg. 123 Specifications
Label information124
Dimensions and weights125
Engine/transmission specifications126
Oil/fluid specifications and volumes127
Fuel system, Distributor ignition system, Suspension128
Electrical system129
Volvo On Call130
pg. 124 Label information
1 Vehicle Emission Control Information
Your Volvo is designed to meet all applicable emission standards, as evidenced by the certification label on the
underside of the hood. For further information regarding these regulations, please consult your Volvo retailer.
2 Vacuum hose routing
(underside of hood)
3 Loads and Tire Pressures
(on inside of fuel filler door)
4 Model plate
Vehicle Identification Number (VIN). Codes for color and upholstery, etc. The plate is located in the engine
compartment, on the inside of the left front fender.
5 Vehicle Identification Number (VIN) *
The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door
pillar.
6 Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS)
ProCarManuals.com

Coolant: Volvo original coolant/antifreeze.
Volume: Normally-aspirated 6-cylinder engine - 9.3 US qts (8.8 liters).
Turbo 6-cylinder engine - 10.1 US qts (9.6 liters).
Power steering fluid
ATF fluid.
Volume: 6 cyl engine - 0.95 US qt (0.9 liter).
Brake fluid
DOT 4+ boiling point > 536°F (280° C) P/N 9437433
Volume: 0.6 US qt (0.6 liter)
Climate control system - refrigerant (R 134a)
Oil: PAG
Volume: 2.2 lbs (1000 g) R134a.
Fuel
Minimum octane requirement - AKI 87 (RON 91)
Volume (fuel tank): 21.1 US gals (80 liters)
Washer fluid reservoir
Volume: 6 cyl: 4.7 US qts. (4.5 liters)
All specifications are subject to change without prior notice.
pg.128 Fuel system, Distributor ignition system, Suspension
Fuel system
The engine is equipped with a multiport fuel injection system.
Distributor ignition system
Firing order: 15-3-6-2-4
Distributor ignition setting: Not adjustable
Spark plugs: B 6284 T: P/N 271367-4 (or equivalent)
B 6294 S: P/N 272371-8 (or equivalent)
Spark plug gap: 0.028-0.032" (0.7-0.8 mm)
Tightening torque: 18.4 ft. lbs. (25 Nm)
WARNING!
ProCarManuals.com

The distributor ignition system operates at very high voltages. Special safety precautions must be followed to
prevent injury. Always turn the ignition off when:
· Replacing distributor ignition components e.g. plugs, coil, etc.
· Do not touch any part of the distributor ignition system while the engine is running. This may result in unintended
movements and body injury.
Front suspension
Spring strut suspension with integrated shock absorbers and control arms linked to the support frame. Powerassisted
rack and pinion steering. Safety type steering column.
The alignment specifications apply to an unladen car but include fuel, coolant and spare wheel.
Toe-in measured on the wheel rims: 2.3 mm +/ 0.8 mm
Toe-in measured on tire sides: 2.8 +/ 0.9 mm
Rear suspension
Individual rear wheel suspension with longitudinal support arms, double link arms and track rods.
Toe-in measured on the tire sides: 1.9 mm +/ 1.9 mm
Vehicle loading
The tires on your Volvo should perform to specifications at all normal loads when inflated as recommended on the tire
information label. The label is located on the inside of the fuel tank cover. The label lists both tire and vehicle design
limits. Do not load your car beyond the load limits indicated. WARNING!
Improperly inflated tires will reduce tire life, adversely affect vehicle handling and can possibly lead to failure
resulting in loss of vehicle control without prior warning.
All specifications are subject to change without prior notice.
pg. 129 Electrical system
Electrical system
12 Volt, negative ground.
Voltagecontrolled generator. Singlewire system with chassis and engine used as conductors. Grounded on chassis.
Battery
Voltage: 12 Volt, capacity: 600 A/115 min.
The battery contains corrosive and poisonous acids. It is of the utmost importance that old batteries are disposed of
correctly. Your Volvo retailer can assist you in this matter.
ProCarManuals.com

Front fog lights..........30
Front fog lights - replacing ........103
Front reading lights..........50
Front seats - adjusting..........48
Front seats - heated..........33
Front suspension..........128
Fuel..........66, 127
Fuel filler cap..........68
Fuel filler door..........68
Fuel gauge..........23
Fuel requirements..........66
Fuel system..........111, 128
Fuel/emissions systems..........111
Fuses..........96 - 99
G
Gas cap..........68
Gasoline..........66
Gear indicator..........23
Gear ratios..........126
Geartronic (automatic transmission)..........72 - 73
Generator..........129
Generator warning light..........24
H
Hand brake..........34
Handling..........75
Hazard warning flashers..........33
Head restraint - center rear..........3
Head restraints, rear - folding..........27
Headlight bulbs - replacing..........100
Headlight wiper blades - replacing..........121
Headlights..........30
Heated front seats..........33
Heated rear window..........33
Heated sideview mirrors..........33
Heating..........41 - 45
Hoisting the car..........114
Home Safe System..........56
HomeLink¨ ........147-149
Hood - opening..........115
I
Ignition switch..........32
Immobilizer (start inhibitor)..........56,69
Indicator lights..........24, 25
Inflatable curtain (IC)..........9
ProCarManuals.com

Paint touch-up..........107
Panic function (alarm)..........61
Parking brake..........34
Parking brake reminder light..........24
Parking lights..........30
Passenger's seat backrest - folding..........49
Polishing..........109
Power seats..........48
Power steering - speed-sensitive..........75
Power steering fluid ........ 118, 127
Power windows..........35
PROPOSITION 65 WARNING..........119
R
Reading lights - front/rear ........ 50
Rear door step lights - replacing..........104
Rear fog light..........25, 30
Rear reading lights..........50
Rear seat backrests - folding..........54
Rear suspension..........128
Rear window - heated..........33
Rearview mirror..........36
Refrigerant..........44, 127
Refueling..........68
Remote control - keyless entry system..........57
Remote control - keyless entry system and sideview mirrors..........36
Remote keyless entry system..........57
Remote keyless entry system - replacing batteries..........58
Remote keyless entry system and driver's seat..........49
Replacing bulbs..........100-106
Replacing fuses..........96
Replacing wiper blades..........121
Reporting safety defects..........11
Road assistance..........130
Roadholding..........75
Roof load - maximum..........125
Roof racks..........76
S
Safety defects - reporting..........11
Safety locks - child..........63
Seat belt maintenance..........11
Seat belts..........2, 3, 14
Seat belts - cleaning..........109
Seats - front..........48
Servicing..........113, 114
ProCarManuals.com

Shiftlock..........69, 70, 72
Side direction indicator - replacing..........103
Side impact airbag system (SIPS)..........8
Side marker lights - replacing..........105
Sideview mirrors..........36
Sideview mirrors - folding ........27
Sideview mirrors - heated..........33
Sideview mirrors - memory function..........36
Snow chains..........89
Snow tires..........89
Spare tire.......... 53, 90
Spark plugs..........128
Specifications..........126
Speed -sensitive power steering..........75
SRS..........6
SRS diagnostic system..........24
Stability Traction Control (STC)..........17, 27
Start inhibitor (immobilizer)..........56, 69
Starting the engine..........69
Steering wheel adjustment ........ 32
Steering wheel lock..........32
Storage compartment in center console..........52
Storage compartments..........51
Studded tires..........89
Sun blinds..........38
Sun roof..........37
Supplemental Restraint System..........4, 24
Suspension..........128
Switches in center console ........ 27
T
Tachometer..........23
Tail light bulbs - replacing ........ 102
Temperature gauge..........23
Temporary spare tire..........90
Text window..........26
Three-way catalytic converters..........85
Tire pressure..........90
Tires..........75, 88 - 91
Tires - changing..........92, 93
Tool bag..........53
Towing a trailer..........79
Towing eyelet..........77
Towing the car..........77, 78
Trailer towing..........79
ProCarManuals.com