2002 TOYOTA SEQUOIA fuel pump

02_SEQUOIA_U (L/O 0108)
2112002 MY SEQUOIA_U (OM34418U)
INFORMATION BEFORE DRIVING YOUR
TOYOTA
Offroad vehicle precautions212
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin period 213
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . .
Fuel 213
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 215
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 215
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Threeway catalytic converter 216
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine exhaust cautions 217
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Facts about engine oil consumption 217
. . . . . . . . . . . . . . . . . . . . . . . . . .
Brake system 218
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . .
Brake pad wear limit indicators 222
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 222
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Toyota’s identification 223
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 224
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Suspension and chassis 224
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
Types of tires 224
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
SECTION 2

02_SEQUOIA_U (L/O 0108)
2132002 MY SEQUOIA_U (OM34418U)
Always slow down in gusty cross-
winds. Because of its profile and
higher center of gravity, your ve-
hicle is more sensitive to side
winds than an ordinary passenger
car. Slowing down will allow you to
have better control.
When driving offroad or in rugged
terrain, do not drive at excessive
speeds, jump, make sharp turns,
strike objects, etc. This may cause
loss of control or vehicle rollover
causing death or serious injury. You
are also risking expensive damage
to your vehicle’s suspension and
chassis.
Do not drive horizontally across
steep slopes. Driving straight up or
straight down is preferred. Your ve-
hicle (or any similar offroad ve-
hicle) can tip over sideways much
more easily than forward or back-
ward.
Drive gently and avoid high speeds.
Your vehicle does not need an elaborate
breakin. But following a few simple tips
for the first 1600 km (1000 miles) can add
to the future economy and long life of
your vehicle:
Do not drive over 88 km/h (55 mph).
Run the engine at moderate speed be-
tween 2000 and 4000 rpm.
Avoid fullthrottle starts.
Try to avoid hard stops during the first
300 km (200 miles).
Do not drive for a long time at any
single speed, either fast or slow.
Do not tow a trailer during the first
3200km (2000miles).FUEL TYPE
Your new vehicle must use only un-
leaded gasoline.
To help prevent gas station mixups, your
Toyota has a smaller fuel tank opening.
The special nozzle on pumps with un-
leaded fuel will fit it, but the larger stan-
dard nozzle on pumps with leaded gas will
not.
At a minimum, the gasoline you use
should meet the specifications of ASTM
D4814 in the U.S.A. and CGSB 3.5M93
in Canada.
NOTICE
Do not use leaded gasoline. Use of
leaded gasoline will cause the three
way catalytic converter to lose its ef-
fectiveness and the emission control
system to function improperly. Also,
this can increase maintenance costs.
Breakin period
Fuel

02_SEQUOIA_U (L/O 0108)
2152002 MY SEQUOIA_U (OM34418U)
GASOLINE QUALITY
In a very few cases, you may experience
driveability problems caused by the partic-
ular gasoline that you are using. If you
continue to have unacceptable driveability,
try changing gasoline brands. If this does
not rectify your problem, then consult your
Toyota dealer.
NOTICE
Do not use gasohol other than
stated above. It will cause fuel sys-
tem damage or vehicle performance
problems.
 If driveab ility problems occur (poor
hot starting, vaporizing, engine
knock, etc.), discontinue the use.
 Take care not to spill gasohol dur-
ing refueling. Gasohol may cause
paint damage.
FUEL TANK CAPACITY
98.5 L (26 gal., 21.6 Imp. gal.) The fuel pump shut off system stops sup-
plying fuel to the engine to minimize the
risk of fuel leakage when the engine stalls
or an airbag inflates upon collision. To
restart the engine after the fuel pump shut
off system activates, turn the ignition
switch to “ACC” or “LOCK” once and start
it.
CAUTION
Inspect the ground under the vehicle
before restarting the engine. If you
find that liquid has leaked onto the
ground, it is the fuel system has
been damaged and it is in need of
repair. In this case, do not restart the
engine.
If you plan to drive your Toyota in
another country...
First,
comply with the vehicle registration
laws.
Second, confirm the availability of the cor-
rect fuel (unleaded and minimum octane
number).
Fuel pump shut off system Operation in foreign countries

02_SEQUOIA_U (L/O 0108)
2852002 MY SEQUOIA_U (OM34418U)
API service symbol
ILSAC certification mark
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum Insti-
tute) designations such as SL. The center
portion of the label shows the SAE viscos-
ity grade such as SAE 5W30. “Energy
Conserving” shown in the lower portion,
indicates that the oil has fuelsaving ca-
pabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “F” and “L” lines on the reservoir.
If the level is low, add ethyleneglycol
type coolant for a proper corrosion
protection of aluminum components.
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “L” line, add
coolant. Bring the level up to the “F” line.
Always use ethyleneglycol type coolant
for a proper corrosion protection of alumi-
num components. See information in the
next column.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
Checking the engine coolant
level

02_SEQUOIA_U (L/O 0108)
2882002 MY SEQUOIA_U (OM34418U)
Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
automatic transmission fluid DEXRONII
or III to bring the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
Keep your tire pressures at the proper
level.
The recommended cold tire pressures, tire
size and the vehicle capacity weight are
given on page 308 and 312 in Section 8.
The recommended cold tire pressures and
tire size are also on the tire pressure
label as shown.
You should check the tire pressures every
two weeks, or at least once a month. And
do not forget the spare! Incorrect tire pressure can reduce tire
life and make your vehicle less safe to
drive.
Low tire pressure results in excessive
wear, poor handling, reduced fuel econo-
my, and the possibility of blowouts from
overheated tires. Also, low tire pressure
can cause poor sealing of the tire bead.
If the tire pressure is excessively low,
there is the possibility of w
heel deforma-
tion and/or tire separation.
High tire pressure produces a harsh ride,
handling problems, excessive wear at the
center of the tire tread, and a greater
possibility of tire damage from road haz-
ards.
If a tire frequently needs ref illing, have it
checked by your Toyota dealer.
The following instructions for checking
tire pressure should be observed:
The pressure should be checked only
when the tires are cold. If your ve-
hicle has been packed for at least 3
hours and has not been driven for
more than 1.5 km or 1 mile since, you
will get an accurate cold tire pressure
reading.
Checking tire pressure

02_SEQUOIA_U (L/O 0108)
3242002 MY SEQUOIA_U (OM34418U)
Loosening wheel nuts252
. . . . . . . . . . . . . . .
Lowering vehicle 255
. . . . . . . . . . . . . . . . . . .
Reinstalling w heel ornament 255
. . . . . . . . .
Removing wheel ornament 251
. . . . . . . . . .
Wheel block 251
. . . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 254
. . . . . . . . . . . . . . . . . . . . . . . .
Floor mat 208
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level
Brake 287
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 287
. . . . . . . . . . . . . . . . . . . . .
Washer fluid 299
. . . . . . . . . . . . . . . . . . . . . . .
Fog light switch, Front 114
. . . . . . . . . . . . . . . .
Foreign countries, Operation in 215 . . . . . . . .
Fourwheel drive
Operating the fourwheel drive system 137
. . . . . . . . . . . . . . . . . . . . .
Front air conditioning system
Instrument panel 172
. . . . . . . . . . . . . . . . . . .
Front fog light switch 114
. . . . . . . . . . . . . . . . .
Front passenger ’s seat belt reminder light 125
. . . . . . . . . . . . . . . . . . . . . .
Front seats 36,37,38
. . . . . . . . . . . . . . . . . . . . .
Fuel
Filler door o pener 31
. . . . . . . . . . . . . . . . . . .
Fuel economy 240
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 215
. . . . . . . . . .
Gauge 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 215 . . . . . . .
Tank cap 31
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 213
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 215
. . . . . . . . . . . .
Fuse
Fuse box 298
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 279
. . . . . . . . . . . . . . . . . . . . . . . G
Garage door opener 186
. . . . . . . . . . . . . . . . . .
Garage door opener box 197
. . . . . . . . . . . . . .
Gauge
Engine coolant temperature 122
. . . . . . . . .
Engine oil pressure 123
. . . . . . . . . . . . . . . . .
Fuel 122
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 197
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice 133
. . . . . . . . . . . . . . . . .
Grocery bag hooks 207
. . . . . . . . . . . . . . . . . . .
H
Hazard switch 113
. . . . . . . . . . . . . . . . . . . . . . .
Head restraints 52
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 110,112
. . . . . . . . . . . . . . . . .
High speed operation
During breakin 213
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 29
. . . . . . . . . . . . . . . . . .
How to start the engine 228
. . . . . . . . . . . . . . .
I
I/M test 276
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification
Vehicle 223
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 132
. . . . . . . . . . . . . . . . . . . . . . .
Ignition switch light 117
. . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . . . .
Instrument panel
Brightness control 114
. . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 195
. . . . . . . . .
Clock 195
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 123
. . . . . . . . . . . Fuel gauge
122
. . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5
. . . . . . . . . . . . . . . . . . . .
Odometer 124
. . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 124
. . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 124
. . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 114
. . . . . . . . . .
Instrument panel overview 2,4
. . . . . . . . . . . .
J
Jack
Location 250 . . . . . . . . . . . . . . . . . . . . . . . . . .
Jump starting 245 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 125
. . . . . . . . . . . . . . . . .
Keys 8,261
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Backup light 303 . . . . . . . . . . . . . . . . . . . . . .
Front fog lights 302 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 302 . . . . . . . . . . . . .
Front turn signal lights 302 . . . . . . . . . . . . . .
Headlights 301 . . . . . . . . . . . . . . . . . . . . . . . .
High mounted stoplight 305 . . . . . . . . . . . . .
Licence plate lights 305 . . . . . . . . . . . . . . . . .
Parking lights 302 . . . . . . . . . . . . . . . . . . . . . .
Rear turn signal light 303 . . . . . . . . . . . . . . .
Stop/tail/rear side marker light 303 . . . . . . .
Tail lights 304 . . . . . . . . . . . . . . . . . . . . . . . . . .