2002 TOYOTA SEQUOIA coolant reservoir

02_SEQUOIA_U (L/O 0108)
2482002 MY SEQUOIA_U (OM34418U)
If your engine coolant temperature
gauge indicates overheating, if you ex-
perience a loss of power, or if you hear
a loud knocking or pinging noise, the
engine has probably overheated. You
should follow this procedure...1. Pull safely off the road, stop the ve- hicle and turn on your emergency
flashers. Put the transmission in “P”
and apply the parking brake. Turn off
the air conditioning if it is being used.
2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine.
Wait until the steam subsides before
opening the hood. If there is no coolant
boiling over or steam, leave the engine
running.
CAUTION
To help avoid personal injury, keep
the hood closed until there is no
steam. Escaping steam or coolant is
a sign of very high pressure.
3. Visually check to see if the enginedrive belt (fan belt) is broken or loose.
Look for obvious coolant leaks from the
radiator, hoses, and under the vehicle.
However, note that water draining from
the air conditioning is normal if it has
been used.
CAUTION
When the engine is running, keep
hands and clothing away from the
moving fan and engine drive belts.
4. If the engine drive belt is broken or thecoolant is leaking, stop the engine im-
mediately. Call a Toyota dealer for as-
sistance.
5. If the engine drive belt is O.K. and there are no obvious leaks, you may
help the engine cool down more quickly
by running it at about 1500 rpm for a
few minutes with the accelerator pedal
lightly depressed.
6. Check the coolant reservoir. If it is dry, add coolant to the reservoir while the
engine is running. Fill it about half full.
CAUTION
Do not attempt to remove the radiator
cap when the engine and radiator are
hot. Serious injury could result from
scalding hot fluid and steam blown
out under pressure.
7. After the engine coolant temperaturehas cooled to normal, again check the
coolant level in the reservoir. If neces-
sary, bring it up to half full again. Seri-
ous coolant loss indicates a leak in the
system. You s hould have it checked as
soon as possible at your Toyota dealer.
If your vehicle overheats

02_SEQUOIA_U (L/O 0108)
2742002 MY SEQUOIA_U (OM34418U)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working. Check headlight aim.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Check that it has the specified free play.
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. Check that the head re-
straint move up and down smoothly and
that the locks hold securely in any latched
position. For foldingdown rear seatbacks,
swingup rear seat cushions and detach-
able temporary third seat, check that the
latches lock securely.Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure the belt
webbing is not cut, frayed, worn or dam-
aged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the pedal has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.
Automatic transmission “Park” mecha-
nism
Check the lock release button of the se-
lector lever for proper and smooth opera-
tion. On a safe incline, check that your
vehicle is held securely with the selector
lever in “P” position and all brakes re-
leased.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 299 in Section 73 for
additional information.
Engine coolant level
Make sure the coolant level is between
the “F” and “L” lines on the seethrough
reservoir when the engine is cold. See
page 285 in Section 72 for additional
information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt, or insects. See page 286 in
Section 72 for additional information.

02_SEQUOIA_U (L/O 0108)
2752002 MY SEQUOIA_U (OM34418U)
Battery condition
Check the battery condition by the indica-
tor color. See page 296 in Section 73 for
additional information.
Brake fluid level
Make sure the brake fluid level is correct.
See page 287 in Section 72 for addition-
al information.
Engine oil level
Check the level on the dipstick with the
engine turned off and the vehicle parked
on a level spot. See page 284 in Section
72 for additional information.
Power steering fluid level
Check the level through the reservoir. The
level should be in the “HOT” or “COLD”
range depending on the fluid temperature.
See page 287 in Section 72 for addition-
al information.
Exhaust system
If you notice any change in the sound of
the exhaust or smell exhaust fumes, have
the cause located and corrected immedi-
ately. (See “Engine exhaust cautions” on
page 217 in Section 2.)Be on the alert for changes in perfor-
mance, sounds, and visual tipoffs that
indicate service is needed. Some impor-
tant clues are as follows:
Engine missing, stumbling, or pinging
Appreciable loss of power
Strange engine noises
A leak under the vehicle (however, wa-
ter dripping from the air conditioning
after use is normal.)
Change in exhaust sound (This may
indicate a dangerous carbon monoxide
leak. Drive with the windows open and
have the exhaust system checked im-
mediately.)
Flatlooking tire; excessive tire squeal
when cornering; uneven tire wear
Vehicle pulls to one side when driving
straight on a level road
Strange noises related to suspension
movement
Loss of brake effectiveness; spongy
feeling brake or clutch pedal; pedal al-
most touches floor; vehicle pulls to one
side when braking
Engine coolant temperature continually
higher than normal
Engine continually runs hot; oil pres-
sure gauge stays low.
If you notice any of these clues, take your
vehicle to your Toyota dealer as soon as
possible. It probably needs adjustment or
repair.
CAUTION
Do not continue driving with the ve-
hicle unchecked. It could result in se-
rious vehicle damage and possibly
personal injury.
Does your vehicle need
repairing?

02_SEQUOIA_U (L/O 0108)
2782002 MY SEQUOIA_U (OM34418U)
1. Windshield and back window washerfluid tank
2. Power steering fluid reservoir
3. Engine oil level dipstick
4. Engine oil filler cap
5. Brake fluid reservoir
6. Fuse blocks
7. Battery
8. Engine coolant reservoir
9. Electric cooling fan
10. Condenser
11. Radiator
Engine compartment overview

02_SEQUOIA_U (L/O 0108)
2852002 MY SEQUOIA_U (OM34418U)
API service symbol
ILSAC certification mark
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum Insti-
tute) designations such as SL. The center
portion of the label shows the SAE viscos-
ity grade such as SAE 5W30. “Energy
Conserving” shown in the lower portion,
indicates that the oil has fuelsaving ca-
pabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “F” and “L” lines on the reservoir.
If the level is low, add ethyleneglycol
type coolant for a proper corrosion
protection of aluminum components.
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “L” line, add
coolant. Bring the level up to the “F” line.
Always use ethyleneglycol type coolant
for a proper corrosion protection of alumi-
num components. See information in the
next column.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
Checking the engine coolant
level

02_SEQUOIA_U (L/O 0108)
3232002 MY SEQUOIA_U (OM34418U)
Cooling systemCoolant level 285 . . . . . . . . . . . . . . . . . . . . . .
Engine overheating 248 . . . . . . . . . . . . . . . . .
Radiator and reservoir 285 . . . . . . . . . . . . . .
Radiator cap 248 . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Corrosion prevention 264 . . . . . . . . . . . . . . . . .
Cruise control 148 . . . . . . . . . . . . . . . . . . . . . . .
Cup holders 205 . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Back window 119 . . . . . . . . . . . . . . . . . . . . . .
Outside rear view mirror 119 . . . . . . . . . . . .
Dimmer switch, Headlight 110,112 . . . . . . . . .
Dinghy towing 233 . . . . . . . . . . . . . . . . . . . . . . .
Directional signals 110,112 . . . . . . . . . . . . . . .
Discharge warning light 125 . . . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 281 . . . . . . . . . . . . . . . . . . . . .
Service precautions 280 . . . . . . . . . . . . . . . .
Does your vehicle need repairing? 275 . . . . .
Doors
Side doors 12 . . . . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 125 . . . . . .
Driver ’s seat belt reminder light 125 . . . . . . . .
Driving
Automatic transmission 133 . . . . . . . . . . . . .
Driving tips 228 . . . . . . . . . . . . . . . . . . . . . . . .
Driving tips
Driving tips in various conditions 229 . . . . .
Driving with an automatic transmission 133 . . . . . . . .
Economical driving 240 . . . . . . . . . . . . . . . . . Good driving practice 133
. . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
During
Breakin 213 . . . . . . . . . . . . . . . . . . . . . . . . . .
E
Economical driving
Saving money on both fuel and repairs 240 . . . . . . . . . . . . . . . . . . . . . .
Electric moon roof 32 . . . . . . . . . . . . . . . . . . . . .
Electrical system,
Battery 296,297 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 279 . . . . . . . . . . . . . . . . . . . . .
Fuses 298 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 113 . . . . . . . . . . . . .
Emergency, In case of8
Blown fuse 298 . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 113 . . . . . . . . . . .
Flat tire 249 . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the engine speed 247 . . . . . . . . . . . . . . . . .
If you lose your keys 261 . . . . . . . . . . . . . . . .
If you lose your wireless remote control transmitter 261 . . . . . . . . . . . . . . . .
If your engine stalls while driving 247 . . . . .
If your vehicle needs to be towed 257 . . . . .
If your vehicle will not start 244 . . . . . . . . . .
Jump starting 245 . . . . . . . . . . . . . . . . . . . . . .
Overheating 248 . . . . . . . . . . . . . . . . . . . . . . .
Towing 257 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and
Maintenance (I/M) programs 276 . . . . . . . . . Engine
Before starting the engine 228 . . . . . . . . . . .
Checking the coolant level 285 . . . . . . . . . .
Emission control device 216 . . . . . . . . . . . . .
Engine compartment 278 . . . . . . . . . . . . . . .
Exhaust gas caution 217 . . . . . . . . . . . . . . . .
Hood release 29 . . . . . . . . . . . . . . . . . . . . . . .
Oil consumption 217 . . . . . . . . . . . . . . . . . . . .
Oil level 284 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil pressure gauge 123 . . . . . . . . . . . . . . . . .
Overheating 248 . . . . . . . . . . . . . . . . . . . . . . .
Starting procedure 228 . . . . . . . . . . . . . . . . .
Threeway catalytic converter 216 . . . . . . .
Engine coolant
Temperature gauge 122 . . . . . . . . . . . . . . . . .
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 122 . . . . .
Engine immobiliser system 10 . . . . . . . . . . . . .
Engine oil
Winter driving tips 232 . . . . . . . . . . . . . . . . . .
Engine oil pressure gauge 123 . . . . . . . . . . . . .
Exhaust gas caution 217 . . . . . . . . . . . . . . . . . .
F
Facts about engine oil consumption 217 . . . .
Flasher, Headlight 110,112 . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 256 . . . . . . . . . . . . . .
Changing tire 254 . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 249 . . . . . . . . . . . . . . . .
Jack point 252 . . . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 249 . . . . . . . . . . . . . . . .
Jacking up 253 . . . . . . . . . . . . . . . . . . . . . . . .