2002 TOYOTA RAV4 steering wheel

’02 Rav4_U (L/O 0108)
1802002 MY RAV4_U (OM42503U)
Crosswinds and rough roads will ad-
versely affect handling of your vehicle
and trailer, causing sway. Pay attention
to the rear from time to time to pre-
pare yourself for being passed by large
trucks or buses, which may cause your
vehicle and trailer to sway. If swaying
happens, firmly grip the steering wheel
and reduce speed immediately but
gradually. Never increase speed. Steer
straight ahead. If you make no extreme
correction with the steering or brakes,
the vehicle and trailer will stabilize.
Be careful when passing other ve-
hicles. Passing requires considerable
distance. After passing a vehicle, do
not forget the length of your trailer and
be sure you have plenty of room be-
fore changing lanes.
In order to maintain engine braking effi-
ciency, do not use fifth gear (manual
transmission) or overdrive (automatic
transmission).
Because of the added load of the trail-
er, your vehicle’s engine may overheat
on hot days (at temperatures over
30C [85 F]) when going up a long or
steep grade with a trailer. If the engine
coolant temperature gauge indicates
overheating, immediately turn off the air
conditioning (if in use), pull off the road
and stop in a safe spot. Refer to “If
your vehicle overheats” on page 188 in
Section 4.
Always place wheel blocks under both
the vehicle and trailer wheels when
parking. Apply the parking brake firmly.
Put the transmission in “P” (automatic)
or in first or reverse (manual). Avoid
parking on a slope with a trailer, but
if it cannot be avoided, do so only
after performing the following:
1. Apply the brakes and hold.
2. Have someone place wheel blocks un- der both the vehicle and trailer wheels.
3. When the wheel blocks are in place, release your brakes slowly until the
blocks absorb the load.
4. Apply the parking brake firmly.
5. Shift into first or reverse (manual) or “P” (automatic) and turn off the engine. When restarting out after parking on a
slope:
1. With the transmission in “P” position (automatic) or the clutch pedal de-
pressed (manual), start the engine.
(With an automatic transmission, be
sure to keep the brake pedal de-
pressed.)
2. Shift into gear.
3. Release the parking brake (also foot brake on automatic transmission ve-
hicles) and slowly pull or back away
from the wheel blocks. Stop and apply
your brakes.
4. Have someone retrieve the blo cks.
CAUTION
Do not exceed 72 km/h (45 mph) or
the posted towing speed limit,
whichever is lower. Because insta-
bility (swaying) of a towing vehicle
trailer combination usually in-
creases as the speed increases, ex-
ceeding 72 km/h (45 mph) may
cause loss of control.

’02 Rav4_U (L/O 0108)
1822002 MY RAV4_U (OM42503U)
Keep the front wheels in proper
alignment. Avoid hitting the curb and
slow down on rough roads. Improper
alignment not only causes faster tire
wear but also puts an extra load on
the engine, which, in turn, wastes fuel.
Keep the bottom of your vehicle free
from mud, etc. This not only lessens
weight but also helps prevent corro-
sion.
Keep your vehicle tunedup and in
top shape. A dirty air cleaner, improp-
er valve clearance, dirty plugs, dirty oil
and grease,brakes not adjusted, etc. all
lower engine performance and contrib-
ute to poor fuel economy. For longer
life of all parts and lower operating
costs, keep all maintenance work on
schedule, and if you often drive under
severe conditions, see that your vehicle
receives more frequent maintenance.
(For scheduled maintenance informa-
tion, please refer to the “Scheduled
Maintenance Guide” or “Owner ’s Manu-
al Supplement”).
CAUTION
Never turn off the engine to coast
down hills. Your power steering and
brake booster will not function with-
out the engine running. Also, the
emission control system operates
properly only when the engine is run-
ning.

’02 Rav4_U (L/O 0108)
1992002 MY RAV4_U (OM42503U)
TOWING PRECAUTIONS:
Use a safety chain system for all towing,
and abide by the state/provincial and local
laws. The wheels and axle on the ground
must be in good condition. If they are
damaged, use a towing dolly.
Twowheel drive models—
(a) Towing with wheel lift type truck
From front—Release the parking brake.
NOTICE
When lifting wheels, take care to en-
sure adequate ground clearance for
towing at the opposite end of the
raised vehicle. Otherwise, the bumper
and/or underbody of the towed vehicle
will be damaged during towing.
From rear—
Manual transmission:
We recommend using a towing dolly
under the front wheels. If you do not
use a towing dolly, place the ignition
key in the “ACC” position and put the
transmission in neutral.
NOTICE
Do not tow with the key removed or
in the “LOCK” position when towing
from the rear without a towing dolly.
The steering lock mechanism is not
strong enough to hold the front
wheels straight.
Automatic transmission:
Use a towing dolly under the front
wheels.
NOTICE
Never tow a vehicle with an automatic
transmission from the rear with the
front wheels on the ground, as this
may cause serious damage to the
transmission.
(b) Using flat bed truck
Fourwheel drive models—
(a) Towing with wheel lift type truck
Use a towing dolly under the wheels not
lifted by the truck.
(b) Using flat bed truck
(c) Towing with sling type
truck
All models—
(c) Towing with sling type truck
NOTICE
Do not tow with sling type truck, ei-
ther from the front or rear. This may
cause body damage.

’02 Rav4_U (L/O 0108)
2002002 MY RAV4_U (OM42503U)
Front
Rear (fourwheel drive models with manu-
al transmission and twowheel drive mod-
els)
Rear (fourwheel drive models with auto-
matic transmission)
If towing is necessary, we recommend
you to have it done by your Toyota
dealer or a commercial tow truck ser-
vice.
If towing service is not available in an
emergency, your vehicle may be tempo-
rarily towed by a cable or chain se-
cured to the emergency towing eyelets
under the front of the vehicle or the
left emergency towing eyelet under the
rear of the vehicle. Use extreme caution
when towing vehicle.
NOTICE
Only use specified towing eyelet;
otherwise your vehicle may be dam-
aged.
A driver must be in the vehicle to steer
it and operate the brakes.
Towing in this manner may be done only
on hardsurfaced roads for a short dis-
tance and at low speeds. Also, the
wheels, axles, drive train, steering and
brakes must all be in good condition.
CAUTION
Use extreme caution when towing ve-
hicles. Avoid sudden starts or erratic
driving maneuvers which would place
excessive stress on the emergency
towing eyelet and towing cable or
chain. The eyelet and towing cable or
chain may break and cause serious
injury or damage.
—Emergency towing

’02 Rav4_U (L/O 0108)
2142002 MY RAV4_U (OM42503U)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Check that it has the specified free play.
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. For foldingup rear seat-
backs, check that the latches lock secure-
ly.Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure the belt
webbing is not cut, frayed, worn or dam-
aged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Clutch pedal
Check the pedal for smooth operation.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the lever has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.Automatic transmission “Park” mecha-
nism
Check the lock release button of the se-
lector lever for proper and smooth opera-
tion. On a safe incline, check that your
vehicle is held securely with the selector
lever in “P” position and all brakes re-
leased.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 243 in Section 73 for
additional information.
Engine coolant level
Make sure the coolant level is between
the “FULL” and “LOW” lines on the see
through reservoir when the engine is cold.
See page 227 in Section 72 for addition-
al information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt, or insects. See page 228 in
Section 72 for additional information.

’02 Rav4_U (L/O 0108)
2252002 MY RAV4_U (OM42503U)
DOITYOURSELF MAINTENANCE
Engine and Chassis
Checking the engine oil level226
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 227
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the radiator and condenser 228
. . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 229
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Checking power steering fluid 229
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing the air conditioning filter 230
. . . . . . . . . . . . . . .
Checking tire pressure 231
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. .
Checking and replacing tires 232
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 234
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Installing snow tires and chains 234
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 236
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
Aluminum wheel precautions 237
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SECTION 7 2

’02 Rav4_U (L/O 0108)
2572002 MY RAV4_U (OM42503U)
BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):118 (4.6)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf): 6—8 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3 STEERING
Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III Tire size:
215/70R16 99S
235/60R16 100H
Tire pressure, kPa (kgf/cm
2 or bar, psi):
200 (2.0, 29)
Wheel size: Steel wheel 16 61/2J
Aluminum Wheel 16 7JJ
Wheel nut torque, N
·m (kgf·m, ft·lbf):
103 (10.5, 76)
NOTE: For a complete information on tires (e.g. replacing tires or re-
placing wheels), see “Checking
tire pressure” through “Aluminum
wheel precautions”, pages 231
through 237, in Section 72.
Tires

’02 Rav4_U (L/O 0108)
2662002 MY RAV4_U (OM42503U)
A
Adding washer fluid243
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 29
. . . . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 40
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air cleaner 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 128
. . . . . . . . . . . . . . .
Airbags 50
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 237
. . . . . . . . . .
Antiglare inside rear view mirror 76 . . . . . . .
Antilock brake system warning light 90 . . . .
Antitheft steering column lock 98
. . . . . . . . .
Appearance care
Cleaning the interior 209
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 206
. . . . . . . . . . . . . . . . . . .
Washing and waxing 207
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 99
. . . . . . . . .
Shift lock override button 202
. . . . . . . . . . . .
Shift pattern 99
. . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 99
. . . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 90
. . . . . . . . . . . .
Auxiliary boxes 141
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 22
. . . . . . . . . . .
B
Back door 21
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 21
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 240
. . . . . . . . . .
Gas caution 240
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 240
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 241
. . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Before starting the engine 170
. . . . . . . . . . . . .
Brake pad wear limit indicators 164 . . . . . . . .
Brake system 161
. . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 90
. . . . . . . . . . . . .
Brakes
Fluid level 229
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 164
. . . . . . . . . . . .
Parking 104
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 155
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 82
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 110
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 159
. . . . . . . . . . . . .
Cassette player 110
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 242
. . . . . . . . .
Checking brake fluid 229
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 226
. . . . . . . . . .
Checking the radiator and condenser 228
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 58
. . . . . . . . . . . . . . .
Installation 60
. . . . . . . . . . . . . . . . . . . . . . . . .
Installation with ISOFIX rigid anchor 72
. . . . . . . . . . . . . . . . . . . . . .
Precautions 57
. . . . . . . . . . . . . . . . . . . . . . . . Types of child restraint system 59
. . . . . . . .
Using a top strap 69
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtrays 136
. . . . . . . . .
Cleaning the interior 209
. . . . . . . . . . . . . . . . . .
Clock 136
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 173
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer controller 110
. . . . . . . . . . . . . . . . . .
Compact disc player 110
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 228
. . . . . . . . . . . .
Controls, Instrument panel 2,4
. . . . . . . . . . . .
Cooling system
Coolant level 227
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 188
. . . . . . . . . . . . . . . . .
Radiator and reservoir 227
. . . . . . . . . . . . . .
Radiator cap 188
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 173
. . . . . . . . . . . . . . . . . .
Corrosion prevention 206
. . . . . . . . . . . . . . . . .
Cruise control 105
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder
Front 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear 143
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger
Out side rear view mirror 85 . . . . . . . . . . . . .
Rear window 85
. . . . . . . . . . . . . . . . . . . . . . . .
Differential, Limited slip 165
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 80
. . . . . . . . . . . . . .
Dinghy towing 174,175
. . . . . . . . . . . . . . . . . . .
Directional signals 80
. . . . . . . . . . . . . . . . . . . .