2002 TOYOTA RAV4 service indicator

’02 Rav4_U (L/O 0108)
902002 MY RAV4_U (OM42503U)
3. Trip meter reset knob—Resets the twotrip meters to zero, and also change
the meter display.
To change the meter display, quickly
push and release the knob. The meter
display changes in the order from the
odometer to trip meter A to trip meter
B, then back to the odometer each
time you push.
To reset the trip meter A to zero, dis-
play the meter A reading, then push
and hold the knob until the meter is
set to zero. The same process can be
applied for resetting the trip meter B.
(a) If parking brake
is off, stop
immediately and
contact Toyota
dealer.
(b) Fasten driver ’s
seat belt.
If the indicator or
buzzer comes on...
(d) Stop and check.
(indicator and buzzer)
(e) Stop and check.
or
Do this.
(c) Fasten front passenger ’s seat
belt.
(h)Take vehicle to
Toyota dealer.
If brake system
warning light is
also on, stop
immediately and
contact Toyota
dealer.
or
(g)
Fill up tank.
(f)
Take vehicle to
Toyota dealer.
or
Do this.
If the indicator or
buzzer comes on...
Service reminder indicators
an d warn in g bu zzers

’02 Rav4_U (L/O 0108)
932002 MY RAV4_U (OM42503U)
Loose fuel tank cap
If the fuel tank cap is loose, securely
tighten it.
These cases are temporary malfunctions.
The malfunction indicator lamp will go off
after taking several driving trips.
If the lamp will not go off even after the
several trips, contact your Toyota dealer
as soon as possible.
If the fuel tank is not empty or the fuel
tank cap is not loose...
There is a problem somewhere in the
engine, emission control system, auto-
matic transmission electrical system or
warning light system itself.
Contact your Toyota dealer as soon as
possible to service the vehicle.
Emissions Inspection and Maintenance
(I/M) programs
Your vehicle may not pass a state
emission inspection if the malfunction
indicator lamp remains on. Contact your
Toyota dealer to check your vehicle’s
emission control system and OBD
(OnBoard Diagnostics) system before
taking your vehicle for the inspection.
For details, see “Emissions Inspection and
Maintenance (I/M) programs” on page 216
in Section 6. (g) Low Fuel Level Warning Light
This light comes on when the fuel level
in the tank becomes nearly empty. Fill up
the tank as soon as possible.
On inclines or curves, due to the move-
ment of fuel in the tank, the low fuel level
warning light may come on earlier than
usual.
(h) “ABS” Warning Light
The light comes on with the ignition key
turned to the “ON” position. If the anti
lock brake system works properly, the
light turns off after a few seconds. There-
after, if the system malfunctions, the light
comes on again.
When the “ABS” warning light is on (and
the brake system warning light is off), the
antilock brake system does not operate,
but the brake system still operates con-
ventionally.
When the “ABS” warning light is on (and
the brake system warning light is off), the
antilock brake system does not operate
so that the wheels could lock up during
a sudden braking or braking on slippery
road surfaces.
If either of the following conditions
occurs, this indicates a malfunction
somewhere in the parts monitored by
the warning light system. Contact your
Toyota dealer as soon as possible to
service the vehicle.
The light does not come on when the
ignition key is turned to the “ON” posi-
tion, or remains on.
The light comes on while you are driv-
ing.
A warning light turning on briefly during
operation does not indicate a problem.
CAUTION
If the “ABS” warning light remains on
together with the brake system warn-
ing light, immediately stop your ve-
hicle at a safe place and contact your
Toyota dealer.
In this case, not only the antilock
brake system will fail but also the
vehicle will become extremely unsta-
ble during braking.

’02 Rav4_U (L/O 0108)
952002 MY RAV4_U (OM42503U)
CHECKING SERVICE REMINDER
INDICATORS (except the low fuel level
warning light and low windshield
washer fluid level warning light)1. Apply the parking brake.
2. Open one of the side doors or back door.
The open door warning light should
come on.
3. Close the door. The open door warning light should go
off.
4. Turn the ignition key to “ON”, but do not start the engine.
All the service reminder indicators ex-
cept the open door warning light should
come on. The “ABS” warning light goes
off after a few seconds. The SRS
warning light goes off after about 6
seconds.
If any service reminder indicator or warn-
ing buzzer does not function as described
above, have it checked by your Toyota
dealer as soon as possible.

’02 Rav4_U (L/O 0108)
1302002 MY RAV4_U (OM42503U)
Air intake selector
Press the button to select the air source.1. Recirculate— Recirculates the air inside
the vehicle.
2. Fresh— Draws outside air into the sys-
tem.
To prevent fogging up of the windshield,
the air intake mode may change automati-
cally to FRESH depending on the condi-
tion of the air conditioning system. “A/C” button (on some models)
To turn on the air conditioning, press the
“A/C” button. The “A/C” button indicator
will come on. To turn the air conditioning
off, press the button again.
If the “A/C” button indicator flashes, there
is a problem in the air conditioning system
and the air conditioning automatically
shuts off. If this happens, take your ve-
hicle to a Toyota dealer for service.

’02 Rav4_U (L/O 0108)
2142002 MY RAV4_U (OM42503U)
INSIDE THE VEHICLE
Items listed below should be checked
regularly, e.g. while performing periodic
services, cleaning the vehicle, etc.
Lights
Make sure the headlights, stop lights, tail
lights, turn signal lights, and other lights
are all working.
Service reminder indicators and warning
buzzers
Check that all service reminder indicators
and warning buzzers function properly.
Steering wheel
Check that it has the specified free play.
Be alert for changes in steering condition,
such as hard steering or strange noise.
Seats
Check that all seat controls such as seat
adjusters, seatback recliner, etc. operate
smoothly and that all latches lock securely
in any position. For foldingup rear seat-
backs, check that the latches lock secure-
ly.Seat belts
Check that the seat belt system such as
buckles, retractors and anchors operate
properly and smoothly. Make sure the belt
webbing is not cut, frayed, worn or dam-
aged.
Accelerator pedal
Check the pedal for smooth operation and
uneven pedal effort or catching.
Clutch pedal
Check the pedal for smooth operation.
Brake pedal
Check the pedal for smooth operation and
that the pedal has the proper clearance.
Check the brake booster function.
Brakes
At a safe place, check that the brakes do
not pull to one side when applied.
Parking brake
Check that the lever has the proper travel
and that, on a safe incline, your vehicle
is held securely with only the parking
brake applied.Automatic transmission “Park” mecha-
nism
Check the lock release button of the se-
lector lever for proper and smooth opera-
tion. On a safe incline, check that your
vehicle is held securely with the selector
lever in “P” position and all brakes re-
leased.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 243 in Section 73 for
additional information.
Engine coolant level
Make sure the coolant level is between
the “FULL” and “LOW” lines on the see
through reservoir when the engine is cold.
See page 227 in Section 72 for addition-
al information.
Radiator, condenser and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt, or insects. See page 228 in
Section 72 for additional information.

’02 Rav4_U (L/O 0108)
2162002 MY RAV4_U (OM42503U)
Some states have vehicle emission in-
spection programs which include OBD
(OnBoard Diagnostics) checks.
The OBD system monitors the operation
of the emission control system. When the
OBD system determines that a problem
exists somewhere in the emission control
system, the malfunction indicator lamp
comes on. In this case, your vehicle may
not pass the I/M test and need to be
repaired. Contact your Toyota dealer to
service the vehicle.
Even if the malfunction indicator lamp
does not come on, your vehicle may not
pass the I/M test as readiness codes
have not been set in the OBD system.
Readiness codes are automatically set
during ordinary driving. However, when the
battery is disconnected or run down, the
codes are erased. Also, depending on
your driving habits, the codes may not be
completely set.
Also, if the malfunction indicator lamp had
come on recently due to temporary mal-
function such as a loose fuel tank cap,
your vehicle may not pass the I/M test. The malfunction indicator lamp will go off
after taking several driving trips, but the
error code in the OBD system will not be
cleared unless about 40 trips or more are
taken.
If your vehicle does not pass the I/M test
even the malfunction indicator lamp does
not come on, contact your Toyota dealer
to prepare the vehicle for retesting.
Emissions Inspection and
Maintenance (I/M) programs

’02 Rav4_U (L/O 0108)
2692002 MY RAV4_U (OM42503U)
Low windshield washer fluid level warning light 90 . . . . . . . . . . . . . . . . . . . . . . . .
Luggage cover 146 . . . . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 164 . . . . . . . . .
M
Maintenance
Doityourself maintenance 219 . . . . . . . . .
Does your vehicle need repairing? 215 . . . . . . . . . . . . . . . . . .
General maintenance 213 . . . . . . . . . . . . . . .
Maintenance requirements 212 . . . . . . . . . .
Parts and tools 221 . . . . . . . . . . . . . . . . . . . . .
Where to go for service 212 . . . . . . . . . . . . .
Malfunction indicator lamp 90,216 . . . . . . . . .
Manual transmission
Driving with a manual transmission 103 . . . . . . . . . . . .
Shift pattern 103
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 103
. . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed
Automatic transmission 99
. . . . . . . . . . . . . .
Manual transmission 103
. . . . . . . . . . . . . . .
Mirror
Antiglare inside rear view 76
. . . . . . . . . . .
Mirrors
Folding rear view 75
. . . . . . . . . . . . . . . . . . . .
Outside rear view 74
. . . . . . . . . . . . . . . . . . .
Power rear view 75
. . . . . . . . . . . . . . . . . . . . .
Vanity 77
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Moon roof 25
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
N
New vehicle breakin 155
. . . . . . . . . . . . . . . . .
O
Odometer 89
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Offroad driving precautions 172
. . . . . . . . . .
Offroad vehicle precautions 154
. . . . . . . . . .
Oil
Consumption 159
. . . . . . . . . . . . . . . . . . . . . .
Power steering 229
. . . . . . . . . . . . . . . . . . . . .
Viscosity and grade 226
. . . . . . . . . . . . . . . .
Oil consumption 159
. . . . . . . . . . . . . . . . . . . . .
Open door warning light 90
. . . . . . . . . . . . . . . .
Operation in foreign countries 157
. . . . . . . . .
Overdrive switch 99
. . . . . . . . . . . . . . . . . . . . . .
Overheating, Engine 188
. . . . . . . . . . . . . . . . . .
Overheating, Engine coolant 88
. . . . . . . . . . .
Overview
Engine compartment 218
. . . . . . . . . . . . . . .
P
Parking brake
Operation 104 . . . . . . . . . . . . . . . . . . . . . . . . .
Reminder light 104 . . . . . . . . . . . . . . . . . . . . .
Personal light 83 . . . . . . . . . . . . . . . . . . . . . . . . .
Polishing 207 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 222 . . . . . . . . . . . . . . . . . .
Power outlet 137 . . . . . . . . . . . . . . . . . . . . . . . . .
Power rear view mirror control 75 . . . . . . . . . .
Power steering
Fluid level 229 . . . . . . . . . . . . . . . . . . . . . . . . .
Power window switches 19 . . . . . . . . . . . . . . . . Preloaders (seat belt pretensioners) 48
. . . . .
Pretensioners (seat belt pretensioners) 48 . . . . . . . . . . . . .
R
Radiator
Checking the radiator 228 . . . . . . . . . . . . . . .
Coolant, Engine 227 . . . . . . . . . . . . . . . . . . . .
Radio 110 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear cup holder 143 . . . . . . . . . . . . . . . . . . . . . .
Rear seats 30 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear view mirror
Antiglare inside 76 . . . . . . . . . . . . . . . . . . . .
Rear view mirrors
Folding 75 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside 74 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power 75 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear window and outside rear view mirror defogger switch 85 . . . . . . . . . . . . . . .
Rear window wiper and washer switch 84 . . . . . . . . . . . . . . . . . . . . . .
Reporting safety defects for U.S. owners 262 . . . . . . . . . . . . . . . . . . . . . . .
Roof luggage carrier 150 . . . . . . . . . . . . . . . . . .
S
Seat adjustment precautions
Front seats 28 . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt extender 46 . . . . . . . . . . . . . . . . . . . . .
Seat belts
Cleaning 209 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening 40 . . . . . . . . . . . . . . . . . . . . . . . . . .

’02 Rav4_U (L/O 0108)
2002 MY RAV4_U (OM42503U)
Publication No. OM42503U
Part No. 01999-42503
Printed in Japan 01-0108-00
I

( U)
Quick index
If a service reminder indicator or warning buzzer comes on 90 . . . . . . . . .
 If your vehicle will not start 184 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. .
 If your engine stalls while driving 188 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If your vehicle overheats 188 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . .
 If you have a flat tire 189 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . .
 If your vehicle needs to be towed 198 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 Tips for driving during breakin period 155 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 How to start the engine 170 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . .
 General maintenance 213 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . .
 Complete index 265 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . .
Gas station information
Fuel type:
UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91)
or higher
See page 155 for detailed information.
Fuel tank capacity:
56 L (14.8 gal., 12.3 lmp. gal.)
Engine oil:
API grade SJ “EnergyConserving”, SL “EnergyConserving” or ILSAC
multigrade engine oil is recommended.
See page 226 for detailed information.
Tire information: See pages 231 through 237.
Tire pressure: See page 257.
\fU8