2002 TOYOTA MR2 SPYDER gas type

02 MY MR2 SMT(U) L/O 0108
124
01 06 12
2002 MR2 (OM17493U)
Breakin period
Drive gently and avoid high speeds.
Your vehicle does not need an elaborate
breakin. But following a few simple tips
for the first 1600 km (1000 miles) can add
to the future economy and long life of
your vehicle:
Do not drive over 88 km/h (55 mph).
Run the engine at moderate speed be-
tween 2000 and 4000 rpm.
Avoid fullthrottle starts.
Try to avoid hard stops during the first
300 km (200 miles).
Do not drive slowly with the transmis-
sion in a high gear.
Do not drive for a long time at any
single speed, either fast or slow.
Fuel
FUEL TYPE
Your new vehicle must use only
unleaded gasoline.
To help prevent gas station mixups, your
Toyota has a smaller fuel tank opening.
The special nozzle on pumps with un-
leaded fuel will fit it, but the larger stan-
dard nozzle on pumps with leaded gas will
not.
At a minimum, the gasoline you use
should meet specifications of ASTM
D4814 in the U.S.A.
NOTICE
Do not use leaded gasoline. Use of
leaded gasoline will cause the three
way catalytic converter to lose its ef-
fectiveness and the emission control
system to function improperly. Also,
this can increase maintenance costs.
OCTANE RATING
Select Octane Rating 87 (Research Oc-
tane Number 91) or higher.
Use of unleaded fuel with an octane num-
ber or rating lower than stated above will
cause persistent heavy knocking. If se-
vere, this will lead to engine damage.If your engine knocks...
If you detect heavy knocking even when
using the recommended fuel, or if you
hear steady knocking while holding a
steady speed on level roads, consult your
Toyota dealer.
However, now and then, you may notice
light knocking for a short time while accel-
erating or driving up hills. This is no need
of concern.
GASOLINES CONTAINING DETERGENT
ADDITIVES
Toyota recommends the use of gaso-
lines that contain detergent additives to
avoid buildup of engine deposits.
However, all gasoline sold in the U.S con-
tains detergent additives to keep clean
and/or clean intake systems.

02 MY MR2 SMT(U) L/O 0108
125
01 06 12
2002 MR2 (OM17493U)
QUALITY GASOLINE
Automotive manufacturers in the U.S.,
Europe and Japan have developed a
specification for quality fuel named
WorldWide Fuel Charter (WWFC) that
is expected to be applied world wide.
The WWFC consists of three categories
that depend on required emission lev-
els. In the U.S., category 3 has been
adopted. The WWFC improves air quali-
ty by providing for better emissions in
vehicle fleets, and customer satisfaction
through better vehicle performance.
CLEANER BURNING GASOLINE
Cleaner burning gasoline, including re-
formulated gasoline that contains oxy-
genates such as ethanol or MTBE is
available in many areas.
Toyota recommends the use of cleaner
burning gasoline and appropriately blended
reformulated gasoline. These types of
gasoline provide excellent vehicle perfor-
mance, reduce vehicle emissions, and im-
prove air quality.OXYGENATES IN GASOLINE
Toyota allows the use of oxygenate
blended gasoline where the oxygenate
content is up to 10% ethanol or 15%
MTBE. If you use gasohol in your
Toyota, be sure that it has an octane
rating no lower than 87.
Toyota does not recommend the use of
gasoline containing methanol.
GASOLINE CONTAINING MMT
Some gasoline contain an octane en-
hancing additive called MMT (Methylcy-
cropentadienyl Manganese Tricarbonyl).
Toyota does not recommend the use of
gasoline that contains MMT. If fuel con-
taining MMT is used, your emission con-
trol system may be adversely affected.
The Malfunction Indicator Lamp on the in-
strument cluster may come on. If this
happens, contact your Toyota dealer for
service.
GASOLINE QUALITY
In a very few cases, you may experience
drivability problems caused by the particu-
lar gasoline that you are using. If you
continue to have unacceptable drivability,
try changing gasoline brands. If this does
not rectify your problem, then consult your
Toyota dealer.NOTICE

Do not use gasohol other than
stated above. It will cause fuel sys-
tem damage or vehicle performance
problems.
 If driveab ility problems occur (poor
hot starting, vaporizing, engine
knock, etc.), discontinue the use.
 Take care not to spill gasohol dur-
ing refueling. Gasohol may cause
paint damage.
FUEL TANK CAPACITY
48 L (12.7 gal., 10.6 Imp. gal.)

02 MY MR2 SMT(U) L/O 0108
170
01 06 12
2002 MR2 (OM17493U)
2. Scrub with a small, soft bristle hand-brush. Add water as needed until the
cleaner becomes soapy. Allow solution
to settle for two to five minutes. Use
a cloth or sponge to remove dirt so it
will not be ground into the top. Be
careful not to allow any cleaner to dry
on the body paint as it may cause
streaks.
3. Rinse thoroughly.
If any dirt is left, repeat the procedure.
After the top has been cleaned, rinse the
vehicle with clean water to remove all the
cleaner.
After cleaning, always make sure the top
is completely dry before you lower it. Low-
ering the top while wet or damp may
cause interior water damage, water stains
or mildew of the top material.
C lean in g th e in t erio r
CAUTION
Do not wash the vehicle floor with
water, or allow water to get onto the
floor when cleaning the vehicle interi-
or or exterior. Water may get into
audio components or other electrical
components above or under the floor
carpet (or mat) and cause a malfunc-
tion; and it may cause body corro-
sion.
Vinyl interior
The vinyl upholstery may be easily
cleaned with a mild soap or detergent
and water.
First vacuum over the upholstery to re-
move loose dirt. Then, using a sponge or
soft cloth, apply the soap solution to the
vinyl. After allowing it to soak in for a few
minutes to loosen the dirt, remove the dirt
and wipe off the soap with a clean damp
cloth. If all the dirt do not come off, re-
peat the procedure. Commercial foaming
type vinyl cleaners are also available
which work well. Follow the manufacturer ’s
instructions.
NOTICE
Do not use solvent, thinner, gasoline
or window cleaner on the interior.
Carpets
Use a good foamtype shampoo to
clean the carpets.
Begin by vacuuming thoroughly to remove
as much dirt as possible. Several types of
foam cleaners are available; some are in
aerosol cans and others are powders or
liquids which you mix with water to pro-
duce a foam. To shampoo the carpets,
use a sponge or brush to apply the foam.
Rub in overlapping circles.
Do not apply water—the best results are
obtained by keeping the carpet as dry as
possible. Read the shampoo instructions
and follow them closely.
Seat belts
The seat belts may be cleaned with
mild soap and water or with lukewarm
water.
Use a cloth or sponge. As you are clean-
ing, check the belts for excessive wear,
fraying, or cuts.

02 MY MR2 SMT(U) L/O 0108
204
01 06 12
2002 MR2 (OM17493U)
NOTICE
Do not use engine antifreeze or any
other substitute because it may dam-
age your vehicle’s paint.
Replacing light bulbs—
The following illustrations show how to
gain access to the bulbs. When replacing
a bulb, make sure the ignition switch and
light switch are off. Use bulbs with the
wattage ratings given in the table.
CAUTION
To prevent yourself from burning,
do not replace the light bulbs while
they are hot.
Halogen bulbs have pressurized gas
inside and require special handling.
They can burst or shatter if
scratched or dropped. Hold a bulb
only by its plastic or metal case.
Do not touch the glass part of a
bulb with bare hands.
NOTICE
Only use a bulb of the listed type.
The inside of the lens of exterior lights
such as headlights may temporarily fog up
when the lens becomes wet in the rain or
in a car wash. This is not a problem
because the fogging is caused by the
temperature difference between the outside
and inside of the lens, just like the wind-
shield fogged up in the rain. However, if
there is large drop of water on the inside
of the lens, or if there is water pooled
inside the light, contact your Toyota deal-
er.

02 MY MR2 SMT(U) L/O 0108
214
01 06 12
2002 MR2 (OM17493U)
Dimensions and weight
Overall length mm (in.) 3885 (153.0)
Overall width mm (in.) 1695 (66.7)
Overall height mm (in.) 1240 (48.8)
∗
Wheelbase mm (in.) 2450 (96.5)
Front tread mm (in.) 1475 (58.1)
Rear tread mm (in.) 1460 (57.5)
Vehicle capacity weight
(occupants + luggage)kg (lb.) 193 (425)
∗: Unladen vehicle
Engine
Model: 1ZZFE
Type: 4 cylinder in line, 4 cycle, gasoline
Bore and stroke, mm (in.): 79.0  91.5 (3.11  3.60)
Displacement, cm
3 (cu. in.):
1794 (109.5)
Fuel
Fuel type:
Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher
Fuel tank capacity, L (gal., Imp. gal.): 48 (12.7, 10.6)

02 MY MR2 SMT(U) L/O 0108
228
01 06 12
2002 MR2 (OM17493U)
A
Adding washer fluid203
. . . . . . . . . . . . . . . .
Adjustment
Seats 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 107
. . . . . . . . . . . . .
Airbags 36
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 197 . . . . . . . .
Antiglare inside rear view mirror 59 . . . . .
Antilock brake system warning light 70
. . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 76 . . . . . . .
Appearance care Cleaning the interior 170
. . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 166
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 167
. . . . . . . . . . . . . .
Auxiliary box 118
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Trunk lid 14
. . . . . . . . . . . . .
B
Battery
Checking battery condition 200 . . . . . . . .
Gas caution 200 . . . . . . . . . . . . . . . . . . . . .
Handling safety 200 . . . . . . . . . . . . . . . . . .
Recharging precautions 201 . . . . . . . . . . .
Winter driving tips 140 . . . . . . . . . . . . . . . .
Before starting the engine 138 . . . . . . . . . . .
Brake pad wear limit indicators 132 . . . . . .
Brake system 129 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 70 . . . . . . . . . . Brakes
Fluid level 191 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 132 . . . . . . . . . .
Parking 89 . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 124 . . . . . . . . . . . . . . . . . . . . . .
Brightness control 64 . . . . . . . . . . . . . . . . . . .
C
Car audio system 93
. . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 127
. . . . . . . . . . .
Cassette player 94
. . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 202 . . . . . . . .
Checking brake fluid 191
. . . . . . . . . . . . . . . .
Checking the engine oil level 188 . . . . . . . .
Checking power steering fluid 191 . . . . . . .
Child restraint Child restraint system 46
. . . . . . . . . . . . .
Installation with seat belt 48
. . . . . . . . . . .
Precautions 46
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 47 . . . . . .
Cigarette lighter and ashtray 116
. . . . . . . . .
Cleaning the interior 170
. . . . . . . . . . . . . . . .
Clock 116
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 140
. . . . . . . . . . . . .
Compact disc player 94
. . . . . . . . . . . . . . . . .
Cooling system
Coolant level 189
. . . . . . . . . . . . . . . . . . . .
Engine overheating 150
. . . . . . . . . . . . . . .
Radiator and condenser 190
. . . . . . . . . . .
Radiator and reservoir 189
. . . . . . . . . . . .
Radiator cap 150
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . . Corrosion prevention
166
. . . . . . . . . . . . . . .
Cruise control 90
. . . . . . . . . . . . . . . . . . . . . .
Cup holders 121
. . . . . . . . . . . . . . . . . . . . . . .
D
Defogger, Rear window 65
. . . . . . . . . . . . . .
Dimensions and weight 214
. . . . . . . . . . . . .
Dimmer switch, Headlight 62
. . . . . . . . . . . .
Dinghy towing 141
. . . . . . . . . . . . . . . . . . . . .
Directional signals 62
. . . . . . . . . . . . . . . . . .
Discharge warning light 70
. . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 184
. . . . . . . . . . . . . . . . . . .
Service precautions 183
. . . . . . . . . . . . . .
Does your vehicle need repairing? 177
. . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt light 70
. . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 70 . . . . .
Driving Driving tips 139,140
. . . . . . . . . . . . . . . . . .
Manual transmission 88
. . . . . . . . . . . . . .
Sequential manual transmission 77 . . . .
Driving tips
Driving tips in various conditions 139
. . . . . . . . . . . . . . . . . . . . .
Driving with a manual
transmission 88
. . . . . . . . . . . . . . . . . . . .
Economical driving 142
. . . . . . . . . . . . . . .
Good driving practice 88
. . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . .
During Breakin 124
. . . . . . . . . . . . . . . . . . . . . . . .


02MY MR2 SMT(U) L/O 0108
2002 MR2 (OM17493U)
Publication No. OM17493U
Part No. 01999-17493
Printed in Japan 01010800
C
MR2(!"U)
Quick index
If a service reminder indicator or warning buzzer comes on 70 . . . . . . . . . . .
 If your vehicle will not start 146 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . .
 If your engine stalls while driving 149 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If your vehicle overheats 150 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . .
 If you have a flat tire 151 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . .
 If your vehicle needs to be towed 160 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 Tips for driving during breakin period 124 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 How to start the engine 138 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . .
 General maintenance 175 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . .
 Complete index 227 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . .
Gas station information
Fuel type:
1ZZFE engine: UNLEADED gasoline, Octane Rating 87
(Research Octane Number 91) or higher
See page 124 for detailed information.
Fuel tank capacity:
48 L (12.7 gal., 10.6 lmp. gal.)
Engine oil:
API grade SJ “EnergyConserving”, SL “EnergyConserving” or ILSAC
multigrade engine oil is recommended.
See page 188 for detailed information.
Tire information: See pages 192 through 197.
Tire pressure: See page 218.
#U4