2002 TOYOTA MR2 SPYDER tow

02 MY MR2 SMT(U) L/O 0108
168
01 06 12
2002 MR2 (OM17493U)
SB51001
Spray water on the side windows or top
seals from above, at a 45 angle to the
ground.
NOTICE
Do not spray water at side windows
and top seals in a way which may
cause water to enter the vehicle.
2. Wash with a mild carwash soap, mixed according to the manufacturer ’s
instructions. Use a soft cotton mitt and
keep it wet by dipping it frequently into
the wash water. Do not rub hard—let
the soap and water remove the dirt.
Plastic wheel ornaments: The plastic
wheel ornaments are damaged easily by
organic substances. If any organic sub-
stances splashes an ornament, be sure to
wash it off with water and check if the
ornament is damaged.
CAUTION
Do not attach the heavily damaged
plastic wheel ornament. It may fly off
the wheel and cause accidents while
the vehicle is moving.
Aluminum wheels: Use only a mild soap
or neutral detergent.
Plastic bumpers: Wash carefully. Do not
scrub with abrasive cleaners. The bumper
faces are soft. Road tar: Remove with turpentine or
cleaners that are marked safe for painted
surfaces.
NOTICE
Do not use organic substances (gaso-
line, kerosene, benzine or strong sol-
vents) which may be toxic or cause
damage.
3. Rinse thoroughly—dried soap can
cause streaking. In hot weather you
may need to rinse each section right
after you wash it.
4. To prevent water spots, dry the vehicle using a clean soft cotton towel. Do not
rub or press hard—you might scratch
the paint.
Automatic car wash
NOTICE
Do not run your Toyota through auto-
matic car washes or possible damage
to the soft top may result.

02 MY MR2 SMT(U) L/O 0108
184
01 06 12
2002 MR2 (OM17493U)
Do not leave used oil within the
reach of children.
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
Take care when filling the brake and
clutch fluid reservoirs because
brake fluid can harm your eyes and
damage painted surfaces. If fluid
gets in your eyes, flush your eyes
with clean water.
When racing the engine, make sure
that the gear position is in the “N”
position. In case the accelerator is
operated with the gear in any other
positions, the vehicle may move, re-
sulting in an unexpected accident.
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
Add only demineralized or distilled
water to fill the radiator. And if you
spill some of the coolant, be sure
to wash it off with water to prevent
it from damaging the parts or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Do not pry the outer electrode of a
spark plug against the center elec-
trode.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not reuse iridiumtipped spark
plugs by cleaning or regapping.
 Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the engine hood or
trunk, check to see that you have
not forgotten any tools, rags, etc.
Parts and tools
Here is a list of parts and tools you will
need on performing doityourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
Engine oil API grade SJ
“EnergyConserving”, SL
“EnergyConserving” or ILSAC
multigrade having viscosity proper for
your climate
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“TOYOTA Long Life Coolant” or equiva-
lent
See page 189 in Section 72 for de-
tails about coolant type selection.
Demineralized or distilled water
Tools:
Funnel (only for adding coolant)
CHECKING BRAKE FLUID
Parts (if level is low):

02 MY MR2 SMT(U) L/O 0108
185
01 06 12
2002 MR2 (OM17493U)
SAE J1703 or FMVSS No.116 DOT 3
brake fluidTools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Toyota P.S fluid EH or equivalent
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts)
CHECKING AND REPLACING FUSES
Parts (if replacement is necessary):
Genuine Toyota fuse or equivalent with
same amperage rating as original
ADDING WASHER FLUID
Parts:
Water
Washer fluid containing antifreeze
(for winter use) Tools:
Funnel
REPLACING LIGHT BULBS
Parts:
Bulb with same number and wattage
rating as original (See charts in
“Replacing light bulbs—” on page 204
in Section 73.)
Tools:
Screwdriver

02 MY MR2 SMT(U) L/O 0108
228
01 06 12
2002 MR2 (OM17493U)
A
Adding washer fluid203
. . . . . . . . . . . . . . . .
Adjustment
Seats 28
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 30
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 107
. . . . . . . . . . . . .
Airbags 36
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 197 . . . . . . . .
Antiglare inside rear view mirror 59 . . . . .
Antilock brake system warning light 70
. . . . . . . . . . . . . . . . . . . . . .
Antitheft steering column lock 76 . . . . . . .
Appearance care Cleaning the interior 170
. . . . . . . . . . . . . .
Protecting your Toyota from
corrosion 166
. . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 167
. . . . . . . . . . . . . .
Auxiliary box 118
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Trunk lid 14
. . . . . . . . . . . . .
B
Battery
Checking battery condition 200 . . . . . . . .
Gas caution 200 . . . . . . . . . . . . . . . . . . . . .
Handling safety 200 . . . . . . . . . . . . . . . . . .
Recharging precautions 201 . . . . . . . . . . .
Winter driving tips 140 . . . . . . . . . . . . . . . .
Before starting the engine 138 . . . . . . . . . . .
Brake pad wear limit indicators 132 . . . . . .
Brake system 129 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 70 . . . . . . . . . . Brakes
Fluid level 191 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 132 . . . . . . . . . .
Parking 89 . . . . . . . . . . . . . . . . . . . . . . . . . .
Breakin tips 124 . . . . . . . . . . . . . . . . . . . . . .
Brightness control 64 . . . . . . . . . . . . . . . . . . .
C
Car audio system 93
. . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 127
. . . . . . . . . . .
Cassette player 94
. . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 202 . . . . . . . .
Checking brake fluid 191
. . . . . . . . . . . . . . . .
Checking the engine oil level 188 . . . . . . . .
Checking power steering fluid 191 . . . . . . .
Child restraint Child restraint system 46
. . . . . . . . . . . . .
Installation with seat belt 48
. . . . . . . . . . .
Precautions 46
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 47 . . . . . .
Cigarette lighter and ashtray 116
. . . . . . . . .
Cleaning the interior 170
. . . . . . . . . . . . . . . .
Clock 116
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 140
. . . . . . . . . . . . .
Compact disc player 94
. . . . . . . . . . . . . . . . .
Cooling system
Coolant level 189
. . . . . . . . . . . . . . . . . . . .
Engine overheating 150
. . . . . . . . . . . . . . .
Radiator and condenser 190
. . . . . . . . . . .
Radiator and reservoir 189
. . . . . . . . . . . .
Radiator cap 150
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . . Corrosion prevention
166
. . . . . . . . . . . . . . .
Cruise control 90
. . . . . . . . . . . . . . . . . . . . . .
Cup holders 121
. . . . . . . . . . . . . . . . . . . . . . .
D
Defogger, Rear window 65
. . . . . . . . . . . . . .
Dimensions and weight 214
. . . . . . . . . . . . .
Dimmer switch, Headlight 62
. . . . . . . . . . . .
Dinghy towing 141
. . . . . . . . . . . . . . . . . . . . .
Directional signals 62
. . . . . . . . . . . . . . . . . .
Discharge warning light 70
. . . . . . . . . . . . . .
Doityourself maintenance
Parts and tools 184
. . . . . . . . . . . . . . . . . . .
Service precautions 183
. . . . . . . . . . . . . .
Does your vehicle need repairing? 177
. . . . . . . . . . . . . . . . . . . . . . .
Driver ’s seat belt light 70
. . . . . . . . . . . . . . .
Driver ’s seat belt reminder buzzer 70 . . . . .
Driving Driving tips 139,140
. . . . . . . . . . . . . . . . . .
Manual transmission 88
. . . . . . . . . . . . . .
Sequential manual transmission 77 . . . .
Driving tips
Driving tips in various conditions 139
. . . . . . . . . . . . . . . . . . . . .
Driving with a manual
transmission 88
. . . . . . . . . . . . . . . . . . . .
Economical driving 142
. . . . . . . . . . . . . . .
Good driving practice 88
. . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . .
During Breakin 124
. . . . . . . . . . . . . . . . . . . . . . . .


02 MY MR2 SMT(U) L/O 0108
229
01 06 12
2002 MR2 (OM17493U)
E
Economical drivingSaving money on both fuel
and repairs 142 . . . . . . . . . . . . . . . . . . . .
Electrical system Battery 200,201 . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 182 . . . . . . . . . . . . . . . . . . .
Fuses 202 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 63 . . . . . . . . . . . .
Emergency, In case of Blown fuse 202 . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 63 . . . . . . . . . .
Flat tire 151 . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot increase the engine speed 149 . . . . . . . . . . . . . . . . . .
If you cannot shift the sequential manual transmission
selector lever 164 . . . . . . . . . . . . . . . . . .
If you lose your keys 164 . . . . . . . . . . . . . .
If your engine stalls while driving 149 . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 160 . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 146 . . . . . . . .
Jump starting 147 . . . . . . . . . . . . . . . . . . . .
Overheating 150 . . . . . . . . . . . . . . . . . . . . .
Towing 160 . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions Inspection and Maintenance (I/M) programs 178 . . . . . . .
Engine Before starting the engine 138 . . . . . . . . .
Checking the coolant level 189 . . . . . . . . Emission control device 126
. . . . . . . . . . .
Engine compartment 180 . . . . . . . . . . . . . .
Exhaust gas caution 127 . . . . . . . . . . . . . .
Hood release 16 . . . . . . . . . . . . . . . . . . . . .
Oil consumption 128 . . . . . . . . . . . . . . . . . .
Oil level 188 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 150 . . . . . . . . . . . . . . . . . . . . .
Starting procedure 137 . . . . . . . . . . . . . . .
Threeway catalytic converter 126 . . . . .
Engine coolant
Temperature gauge 68 . . . . . . . . . . . . . . . .
Winter driving tips 140 . . . . . . . . . . . . . . . .
Engine coolant temperature gauge 68 . . . .
Engine immobiliser system 10 . . . . . . . . . . .
Engine oil Winter driving tips 140 . . . . . . . . . . . . . . . .
Exhaust gas cautions 127 . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 128 . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 62 . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 158 . . . . . . . . . . . .
Changing tire 157 . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 151 . . . . . . . . . . . . . .
Jack point 156 . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 151 . . . . . . . . . . . . . .
Jacking up 156 . . . . . . . . . . . . . . . . . . . . . .
Loosening wheel nuts 155 . . . . . . . . . . . . .
Lowering vehicle 158 . . . . . . . . . . . . . . . . .
Wheel block 155 . . . . . . . . . . . . . . . . . . . . . Wheel nuts 157
. . . . . . . . . . . . . . . . . . . . . .
Floor mat 121 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level Brake 191 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 191 . . . . . . . . . . . . . . . . . . .
Washer fluid 203 . . . . . . . . . . . . . . . . . . . . .
Foreign countries, Operation in 126 . . . . . .
Front box 117 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filler door o pener 18. . . . . . . . . . . . . . . . .
Fuel economy 142 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 126 . . . . . . . . .
Gauge 68 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 126 . . . . .
Tank cap 18 . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 124 . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 126 . . . . . . . . . .
Fuses Fuse box 202 . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 182 . . . . . . . . . . . . . . . . . . . . .
G
Gauge
Engine temperature 68 . . . . . . . . . . . . . . .
Fuel 68 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 175 . . . . . . . . . . . . . . .
Glove box 117 . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice Manual transmission 88 . . . . . . . . . . . . . .


02 MY MR2 SMT(U) L/O 0108
230
01 06 12
2002 MR2 (OM17493U)
H
Hazard switch63
. . . . . . . . . . . . . . . . . . . . . .
Headlight switch 62
. . . . . . . . . . . . . . . . . . . .
High speed operation During breakin 124
. . . . . . . . . . . . . . . . . .
Hood release, Engine 16
. . . . . . . . . . . . . . . .
How to start the engine 138
. . . . . . . . . . . . .
I
Identification
Engine 133 . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 133 . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 76 . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5 . . . . . . . . . . . . . . . . . . . .
Instrument panel Cigarette lighter and ashtray 116 . . . . . . .
Clock 116 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 5 . . . . . . . . . . . . . . . . . .
Odometer 69 . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 69 . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 69 . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 64 . . . . . . . . .
Instrument panel overview 2 . . . . . . . . . . . .
Iridiumtipped spark plugs 129 . . . . . . . . . .
J
Jack
Location 153 . . . . . . . . . . . . . . . . . . . . . . . .
Positioning the jack 186 . . . . . . . . . . . . . . .
Jump starting 147 . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 74
. . . . . . . . . . . . . . . .
Keys 8,164
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Backup lights 209 . . . . . . . . . . . . . . . . . . .
Front turn signal lights 208 . . . . . . . . . . . .
Front side marker lights 208 . . . . . . . . . . .
Headlights 206 . . . . . . . . . . . . . . . . . . . . . . .
License plate lights 210 . . . . . . . . . . . . . . .
Parking lights 207 . . . . . . . . . . . . . . . . . . . .
Rear turn signal lights 209 . . . . . . . . . . . .
Rear turn signal, stop/tail, stop and backup lights 209 . . . . . . . . .
Light bulbs, replacing 204 . . . . . . . . . . . . . . .
Light reminder buzzer 70 . . . . . . . . . . . . . . .
Limitedslip differential 133 . . . . . . . . . . . . .
Lock
Side doors 11 . . . . . . . . . . . . . . . . . . . . . . . .
Steering column 76 . . . . . . . . . . . . . . . . . . .
Low fuel level warning light 70 . . . . . . . . . . .
Low engine oil pressure warning light 70 . . . . . . . . . . . . . . . . . . . . . .
Luggage space 119 . . . . . . . . . . . . . . . . . . . .
Luggage stowage precautions 132 . . . . . . .
M
Maintenance
Doityourself maintenance 183 . . . . . . .
Does your vehicle need repairing? 177 . . . . . . . . . . . . . . . .
General maintenance 175 . . . . . . . . . . . . .
Maintenance requirements 174 . . . . . . . .
Parts and tools 184 . . . . . . . . . . . . . . . . . . .
Where to go for service 174 . . . . . . . . . . .
Malfunction indicator lamp 70 . . . . . . . . . . .
Manual transmission Driving with a
manual transmission 88 . . . . . . . . . . . . .
Shift pattern 88 . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 88 . . . . . . . . . . . . . . . . . . . .
Maximum allowable speed Manual transmission 88 . . . . . . . . . . . . . .
Sequential manual transmission 77 . . . .
Mirror Antiglare inside rear view 59 . . . . . . . . .
Mirrors
Folding rear view 58 . . . . . . . . . . . . . . . . . .
Outside rear view 58 . . . . . . . . . . . . . . . . .
Power rear view 58 . . . . . . . . . . . . . . . . . . .
N
New vehicle breakin 124
. . . . . . . . . . . . . . .


02 MY MR2 SMT(U) L/O 0108
232
01 06 12
2002 MR2 (OM17493U)
Power rear view mirror control 58. . . . . .
Power window 13 . . . . . . . . . . . . . . . . . . . .
Windshield wiper and washer 64 . . . . . . .
T
Tachometer 69
. . . . . . . . . . . . . . . . . . . . . . . . .
Theft prevention labels 134
. . . . . . . . . . . . . .
Threeway catalytic converter 126 . . . . . . .
Tilt steering wheel 57
. . . . . . . . . . . . . . . . . . .
Tires Changing 151
. . . . . . . . . . . . . . . . . . . . . . . .
Flat tire 151
. . . . . . . . . . . . . . . . . . . . . . . . .
Rotation 194
. . . . . . . . . . . . . . . . . . . . . . . . .
Spare 153
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire information 192,193,195
. . . . . . . . . .
Tools 153
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
To w i n g
Dinghy 141
. . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency towing 161
. . . . . . . . . . . . . . . .
If your vehicle needs
to be towed 160
. . . . . . . . . . . . . . . . . . . .
Trailer 142
. . . . . . . . . . . . . . . . . . . . . . . . . .
Trailer towing 142
. . . . . . . . . . . . . . . . . . . . . .
Trip meter 69
. . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk lid (front) 14
. . . . . . . . . . . . . . . . . . . . .
Trunk room (front) overview 181
. . . . . . . . .
Turn signals 62
. . . . . . . . . . . . . . . . . . . . . . . .
Types of tires 135
. . . . . . . . . . . . . . . . . . . . . .
U
Uniform tire quality grading 225
. . . . . . . . . .
W
Warning buzzer 70
. . . . . . . . . . . . . . . . . . . . .
Washer fluid
Adding washer fluid 203
. . . . . . . . . . . . . . .
Washing and waxing 167
. . . . . . . . . . . . . . . .
Wheels
Aluminum wheel 197
. . . . . . . . . . . . . . . . .
Windshield wiper and washer switch 64
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 140
. . . . . . . . . . . . . . . . . .


02MY MR2 SMT(U) L/O 0108
2002 MR2 (OM17493U)
Publication No. OM17493U
Part No. 01999-17493
Printed in Japan 01010800
C
MR2(!"U)
Quick index
If a service reminder indicator or warning buzzer comes on 70 . . . . . . . . . . .
 If your vehicle will not start 146 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . .
 If your engine stalls while driving 149 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 If your vehicle overheats 150 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . .
 If you have a flat tire 151 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . .
 If your vehicle needs to be towed 160 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 Tips for driving during breakin period 124 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
 How to start the engine 138 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . .
 General maintenance 175 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . .
 Complete index 227 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . .
Gas station information
Fuel type:
1ZZFE engine: UNLEADED gasoline, Octane Rating 87
(Research Octane Number 91) or higher
See page 124 for detailed information.
Fuel tank capacity:
48 L (12.7 gal., 10.6 lmp. gal.)
Engine oil:
API grade SJ “EnergyConserving”, SL “EnergyConserving” or ILSAC
multigrade engine oil is recommended.
See page 188 for detailed information.
Tire information: See pages 192 through 197.
Tire pressure: See page 218.
#U4