2002 TOYOTA AVALON cooling

’02 AVALON U (L/O 0107)
2712002 MY AVALON_U (OM22493U)
CAUTION
To prevent burning yourself, do not
remove the radiator cap when the en-
gine is hot.
Coolant type selection
Use of improper coolants may damage
your engine cooling system. Your coolant
must contain ethylene−glycol type coolant
for a proper corrosion protection of your
engine that contains aluminum
components. Use “TOYOTA Long Life
Coolant” or equivalent.
In addition to preventing freezing and
subsequent damage to the engine, this
type of coolant will also prevent corrosion.
Further supplemental inhibitors or additives
are neither needed nor recommended.
Read the coolant container for information
on freeze protection. Follow the manufac-
turer’s directions for how much to mix
with plain water (preferably demineralized
water or distilled water). The total capacity
of the cooling system is given in Section
8. We recommend to use 50% solution for
your Toyota, to provide protection down to
about
−35 C ( −31 F). When it is extreme-
ly cold, to provide protection down to
about −50 C ( −58 F), 60% solution is rec-
ommended. Do not use more than 70%
solution for better coolant performance.NOTICE
Do not use alcohol type antifreeze or
plain water alone.
If any of the above parts are extremely
dirty or you are not sure of their condi-
tion, take your vehicle to Toyota dealer.
CAUTION
To prevent yourself from burning, be
careful not to touch the radiator or
condenser when the engine is hot.
NOTICE
To prevent damage to the radiator
and condenser, do not perform the
work by yourself.
Checking the radiator and
condenser

’02 AVALON U (L/O 0107)
2772002 MY AVALON_U (OM22493U)
When driving with chains installed,
be sure to drive carefully. Slow
down before entering the curves to
avoid losing control of the vehicle.
Otherwise an accident may occur.WHEN TO REPLACE YOUR WHEELS
If you have wheel damage such as
bending, cracks or heavy corrosion, the
wheel should be replaced.
If you fail to replace damaged wheels, the
tire may slip off the wheel or cause loss
of handling control.
WHEEL SELECTION
When replacing wheels, care should be
taken to ensure that the wheels are re-
placed by ones with the same load ca-
pacity, diameter, rim width, and offset.
Correct replacement wheels are available
at your Toyota dealer.
A wheel of a different size or type may
adversely affect handling, wheel and bear-
ing life, brake cooling, speedometer/odom-
eter calibration, stopping ability, headlight
aim, bumper height, vehicle ground clear-
ance, and tire or snow chain clearance to
the body and chassis.Replacement with used wheels is not rec-
ommended as they may have been sub-
jected to rough treatment or high mileage
and could fail without warning. Also, bent
wheels which have been straightened may
have structural damage and therefore
should not be used. Never use an inner
tube in a leaking wheel which is designed
for a tubeless tire.
Replacing wheels

’02 AVALON U (L/O 0107)
2952002 MY AVALON_U (OM22493U)
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):9.0 (9.5, 7.9)
Coolant type: “TOYOTA Long Life Coolant” or equiva-
lent
With ethylene− glycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes
after the key is removed with all the
lights turned off
Charging rates: 5 A max.
AUTOMATIC TRANSAXLE
Fluid capacity (drain and refill),
L (qt., Imp. qt.): Up to 4.75 (5.0, 4.2)
Fluid type: Automatic transmission fluid D −II or
DEXRON III (DEXRON II) BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.)
55 (2.2)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment when depressed
with the force of 294 N (30 kgf, 66.1 lbf):
3—6 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel free play: Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III

’02 AVALON U (L/O 0107)
2982002 MY AVALON_U (OM22493U)
Instrument panel
9. DCC 30 A: “DOME”, “ECU−B” and
“RADIO” fuses
10. SRS WRN 5 A: SRS warning light
11. HAZ 15 A: Turn signal lights
12. A/F 25 A: Air/Fuel sensor
13. DOOR NO.2 15 A: Power door lock
system
14. HORN 10 A: Horn, theft−deterrent sys-
tem
15. AM2 10 A: SRS airbag system, multi-
port fuel injection system/sequential
multiport fuel injection system, starter
system, charging system, air/fuel sen-
sor, fuel pump 16. EFI NO.2 7.5 A:
Multiport fuel injection
system/se quential multiport fuel injec-
tion system, air flow meter, oxygen
sensor, evaporative emission control
system, throttle positi oner control sys-
tem, engine control system
17. ABS NO.3 25 A: Anti−lock brake sys-
tem
18. ABS NO.2 25 A: Vehicle skid control
system
19. EFI NO.1 15 A: Multiport fuel injection
system/se quential multiport fuel injec-
tion system, fuel pump
20. IG2 15 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
21. HEAD RH UPR 10 A: No circuit
22. HEAD LH UPR 10 A: No circuit
23. HEAD RH LWR 15 A: Right−hand
headlight (low beam)
24. HEAD LH LWR 15 A: Left−hand head-
light (low beam)
25. DRL 7.5 A: Daytime running light sys-
tem
26. HEAD LH UPR 10 A: Left−hand head-
light (high beam), high beam indicator
light 27. HEAD RH UPR 10 A:
Right−hand
headlight (high beam)
28. ECUIG NO.1 5 A: Electric cooling
fans
29. ECUB 7.5 A: Air conditioning system,
theft deterrent system, power seats,
meters, power windows (for driver and
front passenger), multiplex communica-
tion system
30. TAIL 10 A: Parking lights, license plate
lights, tail lights, rear side marker
lights, rear light failure warning light,
engine control system
31. SEAT HTR 20 A: Seat heaters
32. FR P/W 20 A: Power window (for front
passenger)
33. GAUGE NO.1 10 A: Vehicle skid con-
trol system, rear window defogger,
cruise control system, shift lock sys-
tem, anti− lock brake system, auto anti −
gl

are inside rear view mirror, automatic
light control system, power seats, rear
light failure warning light, automatic
transmission indicator lights, power out-
let, power window (for driver), brake
system warning light, electric moon
roof
34. HTR 10 A: Air conditioning system
35. FOG 15 A: Front fog lights

’02 AVALON U (L/O 0107)
2992002 MY AVALON_U (OM22493U)
36. TURN 7.5 A: Turn signal lights
37. A/C 10 A: Air conditioning system
38. RADIO 15 A: Audio system, multi −in-
formation display
39. PANEL 5 A: Gauges and meters, audio
system, cigarette lighter, air condition-
ing system, emergency flasher, elec-
tronically controlled automatic transmis-
sion system, power rear view mirrors,
multi −information display, glove box
light, instrument panel lights, instrument
panel light control, power outlet
40. FL P/W 25 A: Power window (for driv-
er)
41. PWR OUTLET NO.1 15 A: Power out-
let (ACC)
42. ECUACC 5 A: Audio system, power
rear view mirrors, multi −information dis-
play, shift lock system, multiplex com-
munication system
43. SRSACC 10 A: SRS airbag system
44. MIR HTR 10 A: Outside rear view mir-
ror defoggers, engine control system
45. PWR OUTLET NO.2 15 A: Power out-
let (IG)
46. GAUGE NO.2 10 A: Back−up lights
47. OBDII 7.5 A: On−board diagnosis sys-
tem 48. STOP 15 A:
Stop lights, high mounted
stoplight, anti −lock brake system, shift
lock system, cruise control system, ve-
hicle skid control system, engine con-
trol system
49. DOME 7.5 A: Interior light, front per-
sonal lights, door courtesy lights, igni-
tion switch light, vanity lights, garage
door opener, open door warning light,
illuminated entry system, rear personal
lights, automatic light control system,
trunk light, wireless remote control sys-
tem, multiplex communication system
50. OPNER 5 A: No circuit
51. RL P/W 20 A: Power window (for rear
left passenger)
52. RR P/W 20 A: Power window (for rear
right passenger)
53. WIP 25 A: Windshield wipers and
washer
54. ECUIG NO.2 10 A: Anti−lock brake
system, cruise control system, multi −in-
formation display, theft deterrent sys-
tem, vehicle skid control system, me-
ters, multiplex communication system
55. CIG 15 A: Cigarette lighter
56. DOOR NO.1 25 A: Theft deterrent sys-
tem, trunk opener, multiplex commu-
nication system 57. SUN ROOF 30 A:
Electric moon roof
Fuses (type B)
58. AM1 40 A: Multiport fuel injection sys-
tem/sequential multiport fuel injection
system
59. HTR 50 A: Air conditioning system
60. CDS 30 A: Electric cooling fans
61. RDI 30 A: Electric cooling fans
62. MAIN 40 A: St
arter system
63. DEF 40 A: Rear window defogger,
noise filter
64. PWR SEAT 30 A: Power seats
Fuses (type C)
65. ABS 60 A: Anti−lock brake system,
“ABS NO.4” fuse
66. ALT 120 A: “HTR”, “A/C”, “ABS NO.2”,
“ABS NO.3”, “RDI”, “CDS”, “AM1”,
“ABS” and “ABS NO.4” fuses