2002 SAAB 9-5 clutch

190 Car care and technical informationEngine compartment, 6-cyl. (3.0t V6)
99
2
1
4
57
6
10
83
IB1774
Engine compartment, 6-cyl. (3.0t V6) 1 Engine-oil dipstick
2 Engine-oil filler cap
3 Reservoir, brake/clutch fluid
4 Fuse box
5 Expansion tank, coolant
6 Washer-fluid filler cap
7Battery
8 Dipstick, automatic transmission fluid
9 Ignition discharge module
10 Reservoir, power-steering fluid
ProCarManuals.com

197 Car care and technical information
Brake and clutch fluid Checking the fluid level The combined brake and clutch-fluid reser-
voir is transparent to facilitate checking of
the fluid level.
The level should be between the MAX and
MIN marks. Top up, as necessary, with
DOT 4 fluid. Do
not
use DOT 5 brake fluid.
Use only new brake fluid from a sealed con-
tainer.
Check that there are no leaks in the brake
system.
The brake fluid level will fall somewhat as
the brake pads wear. The MAX level in the
reservoir corresponds to the amount of
brake fluid required with new brake pads. If
the fall in fluid level is moderate, due to
normal brake pad wear, topping up is not
necessary.
Changing of the brake fluid should be
carried out by an authorized Saab dealer.The vehicle´s regular braking system is
adjusted automatically, but the parking
brake has to be adjusted manually. This
work, involving adjustment of the parking
brake cables and brake pads, must only be
carried out by an authorized Saab dealer.
It is not possible to detect, through abnormal
pedal or parking brake-lever travel, whether
brake pads are worn and need replacing. It
is therefore essential that brake pads be
checked regularly, as specified in the ser-
vice program.
Brake pad wear indicators The outboard brake pads on the front
wheels incorporate pad-wear indicators.
When the lining is down to 0.11 in (3 mm),
the pad will produce a screeching, squeal-
ing or scraping noise when the brakes are
applied. New pads should be fitted without
delay.
Brake pads should only be changed by
an authorized Saab dealer. To ensure
optimum brake performance, use only
Saab original brake pads.
WARNING
Brake fluid deteriorates as it becomes
old. Because it is hygroscopic, it absorbs
water from the air and, in time, could allow
vapor to form in the brake system, thus
reducing its performance. It is therefore
important that brake fluid be changed reg-
ularly, as specified in the service pro-
gram.
NOTEAvoid spilling brake fluid onto paintwork,
since it can cause the paint to bubble and
lift. If any brake fluid is spilled, the area
should be flushed with large quantities of
water as quickly as possible.
IB1188
Brake and clutch-fluid reservoir
ProCarManuals.com

254 SpecificationsManual gearbox Automatic transmissionType ____________________________ All-synchromesh
5-speed with final
drive and differen-
tial
Oil ______________________________ Saab synthetic
manual gearbox oil
Oil capacity _______________________ 1.9 qts (1.8 litres)
Oil volume (on changing) ____________ 1.6 qts (1.5 litres)
Clutch type _______________________ Hydraulic, single
dry-plate clutch of
diaphragm-spring
type
Speed (mph / km/h) at 1000 rpm in 5th gear:
4-cylinder _______________________ 27–28 / 43–44Type _____________________________ Electronically con-
trolled 5-speed,
fully automatic with
hydraulic torque
converter, plane-
tary gear set and
integral final drive
Lock-up function in
selector positions 3,
4 and 5.
Selector-lever positions ______________ P R N D 4 3 L
Transmission-fluid capacity, dry transmis-
sion (incl. torque converter and oil cooler) 7.5 qts (7 litres)
If fluid change required, approximately
3.5 litres can be drained through the drain
plug in the transmission casing
Transmission fluid ___________________ Saab 3309 (mineral
oil based)
Clutch type ________________________ Hydraulic plate
clutches, brake
bands and one-way
couplings
Speed (mph / km/h) at 1000 rpm in 5th gear:
4- cylinder engines and 3.0t V6 _______ 29 / 47–48
ProCarManuals.com

261 Index
IndexAA/C system, fault diagnosis
________ 231
A/C system, maintenance _________ 231
ABS brakes
____________________ 165
ACC
__________________________ 72
ACC functions
___________________ 75
ACC, automatic climate control
______ 72
ACC, calibration
_________________ 80
ACC, condensation _______________ 81
ACC, programming _______________ 78
ACC, useful tips
_________________ 80
Adjusting the steering wheel
_______ 122
Adjustment, seats
_______________ 118
Afterheater, V6-engine cars
________ 82
Air conditioning (A/C), fault diagnosis
and maintenance
______________ 231
Air distribution, ACC ______________ 77
Airbag
_________________________ 29
Alarm __________________________ 43
Alarm functions
__________________ 46
Alarm signals
_______________ 43
, 46
Alternator
_____________________ 201
Alternator drive belt
_________ 201
, 253
Alternator rating
________________ 253
Anticorrosion treatment
___________ 235
Antidazzle rear-view mirror
________ 124
Ashtrays
______________________ 128
Audio System
___________________ 83
Audio System, quick guide
_________ 85Autochecking of lights on starting
____56
Automatic climate control (ACC) _____72
Automatic transmission,
technical data
_________________254
BBattery
________________________199
Battery charging/replacing
________200
Battery, boost starting
____________182
Belt guide
______________________12
Boost starting using jump leads
____182
Booster cushion
_________________27
Brake and clutch fluid
____________197
Brake-fluid reservoir
_____________197
Brakes, technical data ____________255
Bulbs, changing
_________________204
Bulbs, table of
__________________215
CCD changer
_____________________95
CD player
______________________93
CHECK messages
_______________63
CHECKING
_____________________63
Calibration, ACC
_________________80
Cancelling the programmed settings
__78
Car alarm
______________________43
Car care
______________________187
Cargo net, 9-5 Wagon
____________139
Carpeting, care of
_______________232
Cassette player
__________________90Catalytic converter,
important considerations
________ 150
Central locking
__________________ 38
Change language in SID
__________ 64
Change of address notification
____ 246
Changing a wheel
______________ 227
Changing bulbs
________________ 204
Changing the wheels round
_______ 223
Changing wiper blades
__________ 202
Chassis number
_______________ 257
Chassis number, key to
__________ 258
Child safety
____________________ 19
Child safety locks, rear doors
______ 41
Child seat, integral
_______________ 27
Cleaning, engine bay ____________ 233
Clock
______________________ 63
, 64
Color code, body
_______________ 257
Color code, trim ________________ 257
Compact spare wheel
___________ 226
Condensation, ACC
______________ 81
Coolant
______________________ 196
Courtesy Headlight Feature
_______ 66
Cruise control
_________________ 164
Cup holder
____________________ 131
DDICE/TWICE
__________________ 217
Dampers
_____________________ 255
Date code, tires
________________ 225
Dim-dipped beam _______________ 65
Direction indicators ______________ 67
ProCarManuals.com