2002 Peugeot 307 brake fluid

Zero reset
Your PEUGEOT dealer carries out this operation after each service.
However, if you carry out the serviceyourself, the re-set procedure is asfollows: Switch off the ignition,
Press and hold the trip recorder re-set button,
Switch on the ignition.
The display begins a countdown. When the display shows 0, release the button; the service symbol disap-pears. Important: after this operation, if you
wish to disconnect the battery, lock the vehicle and wait for at least fiveminutes, otherwise the zero re-setwill not be registered.
PEUGEOT SERVICING 21
MAINTENANCE OF PARTS SUBJECT TO WEAR and a check of consumables Certain essential components on your vehicle are subject to checks at specific frequencies:
- The brake fluid is to be replaced at a maximum of every 36,000/40,000 miles
(60 000km) or every two years.
- The pollen filter must be checked at each serviceby a PEUGEOT dealer
(services and intermediate visits) or more often, depending on the environment (dust, pollution, etc.).
- For the 2 litre HDI turbo diesel engines (108 hp) , maintenance of the parti-
culate emission filter and topping up of the additive reservoirmust be car-
ried out at a maximum of every 48,000 miles (80 000 km) by a PEUGEOT
dealer.
- Air bags and pretensioning parts on seat belts must be replaced every
10 years.
- The check on tyre inflation pressure must be carried out cold at least once
a month .

MILES (KM)40,000 (60 000)80,000 (120 000) 120,000 (180 000)
THE SERVICE LEVELS Each vehicle has its own servicing cycle, based upon the engine type.
This cycle consists of alternating 2 types of service, A and C, intermediate visits and a few additional operations specific to your vehicle; these correspond to key stages in the life of your 307. At your first and each subsequent service, your dealer will advise you of the type and content of the next service due.
PEUGEOT SERVICING
22
1st service at 6 000 miles
(10 000 km) or 6 months*.
This is necessary in order to benefit from the warranty.
Replacement of automatic gearbox oil every 40,000 miles (60 000 km). Replacement of brake fluidevery 2 years or 40,000 miles (60 000km).
These fixed operations are carried out with synthetically based oil. Synthetic oil or Fuel economy oil may also be used.
Arduous conditions of use (see corresponding section)
- Replacement of air filterevery 24,000 miles (40 000km).
- Replacement of timing beltevery 48,000 miles (80 000km).
* Whichever comes first.
+ replacement of timing belt
Intermediate visit included in the fixed interval services.
MAINTENANCE CYCLE FOR YOUR 307 PETROL ENGINE
Service every 2 years or 20,000 miles (30 000 km) maximum

72,000 (120 000)108,000 (180 000)
MILES (KM)36,000 (60 000)
PEUGEOT SERVICING 23
MAINTENANCE CYCLE FOR YOUR 307 TURBO DIESEL
Service every 2 years or 12,000 miles (20 000km) maximum
1st service at 6,000 miles
(10 000km) or 6 months*.
This is necessary in order to benefit
from the warranty.
+ maintenance of particulate
emission filter
2.0 l HDI 110 ch (96,000 km)
Replacement of timing beltevery 96,000 miles (160 000 km) (2.0 l HDI 90 bhp/110 bhp) and every 144,000 miles
(240 000 km) (1.4 l HDI 70 bhp). Replacement of brake fluid every 2 years or 36 000 miles (60 000km).
These fixed operations are carried out with synthetically based oil.
Synthetic oil or Fuel Economy oil may also be used.
Arduous conditions of use (see corresponding section).
- Replacement of air filterevery 27,000 miles (45 000km).
- Replacement of timing belt every 72,000 miles (120 000km).
* Whichever comes first.
Intermediate visit included in the fixed interval services.
+ maintenance of particulate
emission filter
2.0 l HDI 110 ch (48,000 miles)

PEUGEOT SERVICING25
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st service
A C Intermediate
DRAIN/REFILL- Engine oil.- Bleed fuel filter (diesel).- Oil filter.- Fuel filter (petrol).REPLACE- Fuel filter element (diesel).- Air filter element.- Spark plugs (petrol).- Engine oil (check + top-up). - Manual gearbox oil (check + top-up).- Battery (check + top-up) if cap is removable.LEVEL- Screen wash (check + top-up).- Coolant (check + top-up).- Brake fluid (check + top-up).- Power steering fluid (check + top up according to specification).- Operation of lights and indicators.- Condition of glass, headlamp and light lenses and mirrors.- Horn.- Windscreen washer jets.- Condition of wiper blades.- Condition and tension of the ancillary drive belts.- Handbrake.- Condition of hydraulic circuits (hoses and covers).CHECK- Condition of rubber boots and gaiters.- Brake pads. - Play in hubs, link rods, ball joints, flexible mountings.- Shock absorbers.- Rear drum brake lining wear.- Condition and pressure of tyres (including spare wheel).- Emission control check as per current legislation (petrol).- Smoke opacity (diesel).- Pollen filter (according to specification). - Visual check of the whole vehicle.ROAD TEST
: All driving conditions: Arduous conditions

RECOMMENDATIONS FOR APPROVED LUBRICANTS The oils which appear in the table opposite are suitable for most pur-poses. The diagram opposite states the optimum range of viscosity depen-ding on the temperatures at whichthe oils are to be used. It is also possible to use "superior quality" synthetic oils. In the absence of semi-synthetic or
synthetic oils, oils of API SH/SJ qua-lity (for petrol engines), or CD/CFquality (for diesel engines) may beused by following the "ArduousConditions" servicing schedulewhich specifies shorter intervals. Do not hesitate to ask for advice
from a PEUGEOT dealer to maintaindriving pleasure and to minimise themaintenance cost of your vehicle. For countries outside Europe, please
contact a local PEUGEOT dealer.
PEUGEOT SERVICING27
ONLY ONLY
Manual ESSO GEAR OIL BVTOTAL TRANSMISSION BVGearbox 75W80 PR 9736.41 75W80 AL4 ONLY
Automatic ATF 4HP20-AL4
Gearbox PR 9736.22
Other approved products
Power steering FLUIDE DA PR 9730.A1
Brake fluid PEUGEOT DOT4 Coolant
PROCOR TM108/GLYSANTIN G33 or REVKOGEL 2000
ONLYProtection to minus 35¡C

1 -Rev counter.
2 - Seat belt not fastened warning light.
3 -
Engine autodiagnostics warning light.
4 - Handbrake and low brake fluid level warning light.
5 - Left-hand direction indicator.
6 - Coolant temperature indicator. 7 -
Battery charge warning light.
8 - Central (STOP) warning light.
9 - Engine oil pressure warning light.
10 - Low fuel level warning light.
11 - Right-hand direction indicator.
12 - Fuel gauge.
13 - ABS warning light. 14 -
Air bag warning light.
15 - Passenger air bag disarming indicator light.
16 - Speedometer.
17 - Service indicator, oil level and
total distance recorder.
18 - Trip recorder zero reset.
19 - Rear fog lamp indicator light.
20 - ESP/ASR warning light*.
21 - Front fog lamps indicator light*.
22 - Diesel engine preheat light.
23 - Main beam headlamps indicatorlight.
24 - Low coolant level warning light*.
25 - Dipped beam headlampsindicator light.
26 - Water in diesel filter warning light*.
27 - Lighting rheostat.
* According to specification.
INSTRUMENTS AND CONTROLS
28
INSTRUMENT PANEL DIALS: PETROL / DIESEL

INSTRUMENTS AND CONTROLS29
1 -
Rev counter.
2 - Seat belt not fastened warning light.
3 -
Engine autodiagnostics warning light.
4 - Handbrake and low brake fluid level warning light.
5 - Left-hand direction indicator.
6 - Coolant temperature indicator. 7 -
Battery charge warning light.
8 - Central (STOP) warning light.
9 - Engine oil pressure warning light.
10 - Low fuel level warning light.
11 - Right-hand direction indicator.
12 - Fuel gauge.
13 - ABS warning light. 14 -
Air bag warning light.
15 - Passenger air bag disarming indicator light.
16 - Speedometer.
17 - Service indicator, oil level and
total distance recorder.
18 - Trip recorder zero reset.
19 - Rear fog lamp indicator light.
20 - ESP/ASR warning light*.
21 - Front fog lamps indicator light*.
22 -
Main beam headlamps indicator light.
23 - Low coolant level warning light*.
24 - Dipped beam headlampsindicator light.
25 - Lighting rheostat.
26 - Sport programme.
27 - Snow programme.
28 - Gear lever position indicator.
* According to specification.
INSTRUMENT PANEL DIALS: AUTOMATIC GEARBOX

Low coolant level warning light* Linked to the central STOPwarning light.
This comes on for approximately 3 seconds each time the ignition is switched on.
This warning light is accompanied by an audible signal and the message "Top up
coolant" on the multifunction display.
Stop immediately.
Warning: Allow the engine to cool before topping up.
The cooling system is pressurised. Central STOP warning light This is linked to the "engine oil pressure", ''oil temperature''*, ''coolant level low'', ''brake fluid level'', "electronic brake force dis-tribution fault'', and ''coolant temperature gauge'' warning lights, as
well as warnings of openings, indicated by a diagram on the multifunction dis-
play. This light comes on each time the ignition is switched on.Stop immediately if it flashes with the engine running.
Engine oil pressure warning light Linked to the central STOPwarning light.
If it comes on with the engine running, it is accompanied by an audible signal and the message ''Oil pressure low''or ''Top up engine oil' ' on
the multifunction display.
Stop immediately.If there is a lack of oil in the lubrication circuit, top up the level.
Contact a PEUGEOT dealer without delay.
INSTRUMENTS AND CONTROLS
A permanently lit warning light, or one that flashes with the engine running, indicates an operating fault in the relevant unit. Some warning lights may
be linked to buzzers and a message on the multifunction display. Do notignore this warning: contact a PEUGEOT dealer as soon as possible.
If the central STOP warning light comes on when you are driving, stop immediately ; stop your vehicle where it is safe to do so. To prevent the risk of scalding, uns-crew the cap by two turns to allowthe pressure to drop. Once the pressure has dropped, remove the cap and topup the level.
Contact a PEUGEOT dealer.According to engine.
Handbrake and low brake fluid levelwarning light
Linked to the central STOPwarning
light. This comes on each time the ignition is switched on. Illumination of this light is accompa- nied by an audible signal and a mes-sage on the multifunction displayindicating the cause of the warning: - ''Handbrake on'' , if the handbrake
is applied or has not been released
correctly,
- ''Low brake fluid level'' if there is
an excessive drop in the brakefluid (if the light remains on evenwith the handbrake released),
- ''Brake system problem'' is dis-
played simultaneously with theABS light, indicating a malfunctionof the electronic brake force distri-bution.
Stop immediately.
Contact a PEUGEOT dealer.
* According to specification.
INSTRUMENTS AND CONTROLS
30