2002 MERCEDES-BENZ ML430 traction control

226 Driving systems
Te ch n i c a l
data Instruments
and controlsOperationDrivingInstrument
cluster displayPractical hints Car care Index
If one drive wheel loses traction and begins to spin, the
brake is applied until the wheel regains sufficient
traction. The traction control engages at vehicle speeds
up to approx. 24 mph (40 km / h), and switches off at
50 mph (80 km / h).
Note:
Avoid spinning of one drive wheel. This may cause
serious damage to the drive train which is not covered
by the Mercedes-Benz Limited Warranty.
The ESP warning lamp, located in the speedometer dial,
starts to flash at any vehicle speed as soon as the tires
lose traction and the wheels begin to spin.
To return to the enhanced vehicle stability offered by
ESP: press lower half of the switch (the ESP warning
lamp in the speedometer dial goes out).Important!
If the ESP warning lamp flashes:
•During take-off, apply as little throttle as possible,
•While driving, ease up on the accelerator.
•Adapt your speed and driving to the prevailing road
conditions.
•Do not switch off the ESP.
LOW RANGE – ESP
During off-road driving a special low range system for
the electronic stability program (ESP) is operational
with transmission in LOW RANGE mode, see page 229.
In the LOW RANGE mode the electronic stability
program (ESP) operates in a traction improving fashion
specifically adapted for off-road driving. At speeds
below 27 mph (45 km / h) the ESP assists in over-/
understeering, thus improving vehicle tracking.

229 Driving systems
Te ch n i c a l
data Instruments
and controlsOperationDrivingInstrument
cluster displayPractical hints Car care Index Important!
During off-road driving a special low range system for
antilock brake system (ABS) and four-wheel electronic
traction system (4-ETS+) are operational with
transmission in the LOW RANGE mode.
In the low range mode the electronic stability program
(ESP) operates in a traction improving fashion
specifically adapted for off-road driving. At speeds
below 27 mph (45 km / h) the ESP assists in over- /
understeering, thus improving vehicle tracking.
If one or more tires lose traction while driving downhill
(accelerator released), the 4-ETS+ engages and the
warning lampv, located in the speedometer dial,
starts to flash.
When applying the service brakes at speeds below
approximately 18 mph (30 km / h), the front wheels are
locked cyclically to shorten the braking distance (dig in
effect). This affects steering the vehicle.Notes:
Driving off or driving up to 3 mph (5 km / h) with the
service brakes applied lightly (to reduce drive wheel
spin), the 4-ETS+ remains engaged. Driving with the
service brakes applied lightly at vehicles speeds above
3 mph (5 km / h), the 4-ETS+ will not engage.
If the indicator lamp blinks fast, one or more switching
conditions were not observed, or the LOW RANGE mode
is defective.
In the case of a defective in the LOW RANGE mode the
transmission shifts in the usual manner. It is not
possible to switch on the LOW RANGE mode.
Have the transmission checked at your authorized
Mercedes-Benz Light Truck Center as soon as possible.

239 Contents - Instrument cluster display
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Instrument cluster displayMalfunction and
indicator lamps in
the instrument cluster .............240
On-board diagnostic system –
Check engine malfunction
indicator lamp .............................240
Brake warning lamp .................. 241
Supplemental restraint system
(SRS) indicator lamp ..................242
Fuel reserve warning .................242Electronic stability program
(ESP) / Electronic traction
system (ETS) – warning lamp .. 243
BAS/ESP malfunction
indicator lamp ............................ 243
4-ETS malfunction
indicator lamp ............................ 243
LOW RANGE
indicator lamp ............................ 243
ABS malfunction
indicator lamp ............................ 244
Adjustable steering wheel –
indicator lamp ............................ 244
AIRBAG OFF
indicator lamp ............................ 244Seat belt warning lamp .............245
Charge indicator lamp ...............245
Low engine oil level
warning lamp ..............................246
Low engine coolant level
warning ........................................246
Low windshield and
headlamp washer system fluid
level warning lamp ....................247
Brake pad wear i
ndicator lamp ..............................247
FSS indicator ...............................247

243 Malfunction and indicator lamps
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index Electronic stability program (ESP)/Electronic
traction system (4-ETS+) — warning lamp
The yellow warning lamp in the
speedometer dial comes on with the key in
steering lock position 2. It should go out
with engine running.
See page 221 for 4-ETS+ and page 223 for ESP if the
warning lamp lights up or flashes when the vehicle is
moving.
BAS/ESP malfunction indicator lamp
The malfunction indicator lamp for the ESP
is combined with that of the BAS.
The yellow BAS / ESP malfunction indicator
lamp in the instrument cluster comes on with the key in
steering lock position 2. It should go out with the engine
running.
If the BAS / ESP malfunction indicator lamp remains
illuminated with the engine running, see page 217 for
BAS and page 223 for ESP.4-ETS+ malfunction indicator lamp
The yellow ETS malfunction indicator lamp
in the instrument cluster comes on with the
key in steering lock position 2. It should go
out with the engine running.
If the ETS malfunction indicator lamp remains
illuminated with the engine running a malfunction has
been detected, see page 221 for 4-ETS+.
LOW RANGE indicator lamp
The yellow LOW RANGE indicator lamp in
the instrument cluster comes on with the
key in steering lock position 2. With the
LOW RANGE mode deactivated it should go out with the
engine running.
With the LOW RANGE mode activated the LOW RANGE
indicator lamp is illuminated continuously.
If the indicator lamp blinks fast, one or more switching
conditions were not observed, or the LOW RANGE mode
is defective, see page 227 for LOW RANGE mode.
BAS
ESP
ETSLOW
RANGE

320 Consumer information
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car care Index
Consumer information
This has been prepared as required of all manufactures
of passenger cars under Title 49, Code of U.S. Federal
Regulations, Part 575 pursuant to the “National Traffic
and Motor Vehicle Safety Act of 1966”.
Uniform tire quality grading
Quality grades can be found where applicable on the
tire sidewall between tread shoulder and maximum
section width. For example:
All passenger vehicle tires must conform to federal
safety requirements in addition to these grades.Treadwear
The treadwear grade is a comparative rating based on
the wear rate of the tire when tested under controlled
conditions on a specified government test course. For
example, a tire graded 150 would wear one and one-half
(1
1/2) times as well on the government course as a tire
graded 100. The relative performance of tires depends
upon the actual conditions of their use, however, and
may depart significantly from the norm due to
variations in driving habits, service practices and
differences in road characteristics and climate.
Traction
The traction grades, from highest to lowest are AA, A, B,
and C. Those grades represent the tire’s ability to stop
on wet pavement as measured under controlled
conditions on specified government test surfaces of
asphalt and concrete. A tire marked C may have poor
traction performance. Tread wear 200 Traction AA Temperature A
Wa r n i n g !
The traction grade assigned to this tire is based on
straight ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.

325 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex Driving instructions ...................................................... 192
Driving off ....................................................................... 194
Dust filter ......................................................................... 111
EEBP (Electronic brake proportioning) ........................ 222
Electrical outlet .............................................................. 252
Electronic brake proportioning (EBP) ........................ 222
Electronic stability program (ESP) .............................. 223
Control switch ...........................................................225
Malfunction indicator lamp ..................................... 243
Synchronizing ...........................................................224
Warning lamp ............................................................243
Electronic traction system (4-ETS+) ........................... 221
LOW RANGE – 4-ETS ...............................................222
Malfunction indicator lamp ..................................... 243
Emergency call
See Tele Aid ............................................................... 166
Emergency tensioning retractor (ETR) ......................... 57
Emergency unlocking in case of accident ................... 33
Emission control ............................................................ 179
Emission control label .................................................. 307
Engine compartment .....................................................253Engine malfunction
CHECK ENGINE
malfunction indicator lamp ............................... 240
Engine oil additives ....................................................... 316
Engine oil consumption ............................................... 256
Engine oil level
Checking .............................................................. 96, 255
Warning ..................................................................... 246
Engine oil level indicator ................................................ 96
Engine oils ...................................................................... 316
Capacities ................................................................... 314
Low engine oil level warning ................................. 246
Engine overheating ..........................................................87
Engine speed limit
Overrevving .................................................................. 88
Enlarged cargo area ....................................................... 149
Entrance lamps ............................................................... 130
ESP
LOW RANGE — ESP .................................................. 226
ESP (Electronic stability program) ............................. 223
Control switch .......................................................... 225
Malfunction indicator lamp .................................... 243
Synchronizing .......................................................... 224
Warning lamp ........................................................... 243
ETR (Emergency tensioning retractor) .........................57

326 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex
ETS (4-ETS+) ................................................................... 221
LOW RANGE – 4-ETS+ ............................................. 222
Express opening and
closing of power windows ....................................... 122
Exterior lamp switch ....................................................... 97
Daytime running lamp mode .................................. 100
Exterior lamps ................................................................ 282
Additional turn signals on
the exterior mirror ...............................................288
Adjusting headlamp aim .......................................... 290
Fog lamp assembly ................................................... 286
Fog lamps ................................................................... 103
Headlamp assembly ........................................ 283, 284
Headlamps ................................97, 283, 284, 290, 300
High mounted stop lamp .........................................289
License plate lamps .................................................. 289
Low and high beam ............................................97, 285
Parking lamp .......................................................97, 285
Replacing bulbs ......................................................... 282
Side marker lamp ......................................................285
Standing lamp .....................................................97, 285
Taillamp assemblies ................................................. 287
Turn signal lamp .................................................97, 285
Exterior mirror, front passenger side,
parking position .......................................................... 78Exterior rear view mirrors .............................................. 77
Electrically folding ...................................................... 79
Parking position ..........................................................78
FFirst aid kit ..................................................................... 250
Flat tire
See Changing wheels .............................................. 267
Flexible service system (FSS) ........................................ 94
FSS indicator lamp ............................................. 85, 247
Floor plates
Removable .................................................................. 147
Fog lamp switch ............................................................. 103
Four ETS
LOW RANGE – 4-ETS+ ............................................ 222
Malfunction indicator lamp .................................... 243
Four wheel electronic traction system (4-ETS+) .......221
Malfunction indicator lamp .................................... 243
Fuel
Gasoline additives ..................................................... 318
Premium unleaded gasoline ................... 236, 315, 317
Fuel filler flap
Manual release ......................................................... 295
Fuel requirements ......................................................... 317

333 Index
Te ch n i c a l
data Instruments
and controlsOperation DrivingInstrument
cluster displayPractical hints Car careIndex Tie-down rings, cargo .................................................... 150
Tire inflation pressure .................................................. 272
Tire traction .................................................................... 197
Tires
Driving instructions ................................................. 195
Rims and tires ........................................................... 310
Rotating wheels ......................................................... 263
Tire inflation pressure ............................................. 272
Tire replacement ....................................................... 262
Winter driving instructions .................................... 199
Tool kit
See Vehicle tools ....................................................... 259
Tow-away alarm ................................................................ 37
Switching off ................................................................ 37
Towing the vehicle ......................................................... 277
Stranded vehicle ....................................................... 281
Transmission selector lever,
manually unlocking ............................................. 281
Trailer operation ............................................................ 216
Trailer towing .................................................................209
Transmission .................................................................. 183
Transmission control - LOW RANGE mode ...............227
Transmission fluid level ...............................................256Transmission selector lever,
manually unlocking .................................................. 281
Traveling abroad ............................................................201
Trip computer ................................................................... 89
Trip odometer ................................................................... 86
Trunk .................................................................................34
Opening ........................................................................ 27
Trunk lamp ..................................................................... 129
Turn signal failure ........................................................... 98
Turn signals ......................................................................97
UUnlocking the vehicle ...................................................... 27VVanity mirrors ................................................................ 131
Vehicle jack .................................................................... 259
Vehicle keys ......................................................................24
Vehicle tools
Screwdriver ............................................................... 259