2002 MAZDA MODEL MILLENIA inflation pressure

4-5
Before Driving Your Mazda
Form No. 8Q47-EA-01F
Before Starting the Engine
•Be sure the windows, outside mirror(s),
and outside lights are clean.
•Inspect inflation pressures and
condition of tires.
•Look under the vehicle for any sign of
a leak.
•If you plan to back up, make sure
nothing will be in your way.•Are all doors closed and locked?
•Are the inside and outside mirrors
adjusted?
•Is everyone’s seat belt fastened?
•Do all the lights work?
•Check all gauges.
•Check all warning lights when the
ignition switch is turned to the ON
position.
•Release the parking brake and make
sure the brake warning light goes off.
Always be thoroughly familiar with your
Mazda.
Before Getting In
NOTE
Engine oil, engine coolant, brake fluid,
washer fluid, and other fluid levels
should be inspected daily, weekly, or at
refueling, depending on the fluid. See
Maintenance, Section 8.
After Getting In
J76Y.book Page 5 Wednesday, March 27, 2002 5:04 PM

8-5
Maintenance and Care
Scheduled Maintenance
Form No. 8Q47-EA-01F

Schedule 2
I
: Inspect and repair, clean, adjust, or replace if necessary.
(Oil-permeated air filter cannot be cleaned using the air-blow method.)
R
: Replace
L
:Lubricate
*1: According to state and federal regulations, failure to perform maintenance on these items will not void your
emissions warranties. However, Mazda recommends that all maintenance services be performed at the
recommended time or kilometrage (mileage) period to ensure long-term reliability.
*2: If the vehicle is operated in cold districts { below -18 degrees C (0 degrees F) }, replace the timing belt at
96,000km (60,000miles).
Maintenance
Interval
Maintenance
ItemNumber of months or kilometers (miles), whichever comes first
Months 4 8 12 16 20 24 28 32 36 40 44 48
×1000 Km 8 1624324048566472808896
(×1000 Miles) (5) (10) (15) (20) (25) (30) (35) (40) (45) (50) (55) (60)
Engine valve clearanceMiller Cycle Engine
V6 DOHCI
Drive belts (tension)2.5 liter V6 DOHCII
Miller Cycle Engine
V6 DOHCReplace every 168,000km (105,000miles)
Engine timing belt2.5 liter V6 DOHC
*2Inspect at 96,000km (60,000miles)
Replace every 168,000km (105,000miles)
Miller Cycle Engine
V6 DOHCReplace every 96,000km (60,000miles)
Engine oilPuerto RicoReplace every 5,000km (3,000miles) or 3 months
othersRRRRRRRRRRRR
Engine oil filterRRRRRRRRRRRR
Cooling systemII
Engine coolantReplace at first 72,000km (45,000 miles) or 36 months ;
after that, every 48,000km (30,000miles) or 24 months
Engine coolant levelIIIIIIIIIIII
Idle speedI I
Fuel lines and hoses
*1I I
Hoses and tubes for emission*1I
Air filter
I *1R
I *1R
Spark plugs 2.5 liter V6 DOHCReplace every 48,000km (30,000miles)
Miller Cycle Engine
V6 DOHCReplace every 96,000km (60,000miles)
Function of all lightsIIIIIIIIIIII
Brake lines, hoses and connectionsII
Brake fluid levelIIIIIIIIIIII
Disc brakesIIII
Automatic transaxle fluid levelII
Tire inflation pressure and tire wearIIIIIIIIIIII
Steering operation and linkagesII
J76Y.book Page 5 Wednesday, March 27, 2002 5:04 PM

8-7
Maintenance and Care
Form No. 8Q47-EA-01F
Owner Maintenance
The owner or a qualified service technician should make these vehicle inspections at the
indicated intervals to ensure safe and dependable operation.
Bring any problem to the attention of an Authorized Mazda Dealer or qualified service
technician as soon as possible.

When Refueling
•Brake fluid level (page 8-15)
•Engine coolant level (page 8-12)
•Engine oil level (page 8-10)
•Washer fluid level (page 8-19)

At Least Monthly
•Tire inflation pressures (page 8-25)

At Least Twice a Year (For Example, Every Spring and Fall)
•Automatic transaxle fluid level (page 8-17)
•Power steering fluid level (page 8-16)
You can do the following scheduled maintenance items if you have some mechanical
ability and a few basic tools and if you closely follow the directions in this manual.
•Air filter (page 8-20)
•Engine coolant (page 8-12)
•Engine oil (page 8-11)
Owner Maintenance Schedule
J76Y.book Page 7 Wednesday, March 27, 2002 5:04 PM

8-24
Maintenance and Care
Owner Maintenance
Form No. 8Q47-EA-01F

Battery Maintenance
To get the best service from a battery:
•Keep it securely mounted.
•Keep the top clean and dry.
•Keep terminals and connections clean,
tight, and coated with petroleum jelly
or terminal grease.
•Rinse off spilled electrolyte
immediately with a solution of water
and baking soda.
•If the vehicle will not be used for an
extended time, disconnect the battery
cables.For reasons of proper performance, safety,
and better fuel economy, always maintain
recommended tire inflation pressures and
stay within the recommended load limits
and weight distribution.
Tires
Using Different Tire Types:
Driving your vehicle with different
types of tires is dangerous. It could
cause poor handling and poor
braking; leading to loss of control.
Except when using the temporary
spare tire, use only the same type tires
(radial, bias-belted, bias-type) on all
four wheels.
Using Wrong-Sized Tires:
Using any other tire size than what is
specified for your Mazda (page 10-6)
is dangerous. It could seriously affect
ride, handling, ground clearance, tire
clearance, and speedometer
calibration. This could cause you to
have an accident. Use only tires that
are the correct size specified for your
Mazda.
WARNING
J76Y.book Page 24 Wednesday, March 27, 2002 5:04 PM

8-25
Maintenance and Care
Owner Maintenance
Form No. 8Q47-EA-01F

Tire Inflation Pressure
Inspect all tire pressures monthly
(including the spare) when the tires are
cold. Maintain recommended pressures
for the best ride, top handling, and
minimum tire wear.
Refer to the specification charts (page 10-
6).
Incorrect Tire Inflation:
Overinflation or underinflation of
tires is dangerous. Adverse handling
or unexpected tire failure could result
in a serious accident. Always inflate
the tires to the correct pressure (page
10-6).
WARNING
NOTE
•Warm tires normally exceed
recommended pressures. Don’t
release air from warm tires to adjust
the pressure.
•Underinflation can cause reduced
fuel economy and poor sealing of
the tire bead, which will deform the
wheel and cause separation of tire
from rim.
•Overinflation can produce a harsh
ride and a greater possibility of
damage from road hazards.
Keep your tire pressure at the
correct levels. If one frequently
needs inflating, have it inspected.
J76Y.book Page 25 Wednesday, March 27, 2002 5:04 PM

10-6
Specifications
Form No. 8Q47-EA-01F

Air Conditioner

Light Bulbs

Tires
Check the tire pressure label for tire size and inflation pressure. Refer to Tire Inflation
Pressure on page 8-25.
Standard tire
Temporary spare tire

Fuses
Refer to the fuse rating on page 8-34.
Gas complies with SAE J639 Maximum operating charge
R-134a 0.8 kg (28.2 oz)
Light bulb Wattage
HeadlightsHigh beam (HB3) 60
Low beam (HB4) 51
Front turn signal lights 27
Parking lights 5
Fog lights55
Side-marker lights 3.8
High-mount brake lights 5
Rear turn signal lights 21
Brake lights/Taillights 21/5
Reverse lights 18
License plate lights 5
Trunk light5
Overhead light 8
Map lightsFront 8
Rear 5
Courtesy lights 3.4
Tire sizeInflation pressure
Front Rear
P215/55 R16 91V
220 kPa (2.2 kgf/cm
2, 32 psi or lb/po2) 200 kPa (2.0 kgf/cm2, 29 psi or lb/po2)
215/50 R17 91V
230 kPa (2.3 kgf/cm2, 34 psi or lb/po2) 210 kPa (2.1 kgf/cm2, 31 psi or lb/po2)
Tire size Inflation pressure
T135/70 D16 420 kPa (60 psi)
J76Y.book Page 6 Wednesday, March 27, 2002 5:04 PM

11-5
Index
Form No. 8Q47-EA-01F
P
Power Steering ................................. 5-12
Fluid
.......................................... 8-16
Power Windows
............................... 3-13
Push-Starting
.................................... 7-14
R
Rear Door Child Safety Locks ........... 3-9
Rear Seat
............................................ 2-5
Rear Window Defroster
................... 5-36
Rear-Armrest Opening
..................... 6-40
Rearview Mirror
............................... 3-24
Recreational Towing
........................ 7-17
Rocking the Vehicle
........................... 4-7
S
Safety Defects, Reporting ................ 9-15
Seat Belt System
2-point type
............................... 2-12
3-point type
............................... 2-10
Automatic locking
...................... 2-9
Emergency locking
..................... 2-9
Extender
.................................... 2-13
Pregnant women
......................... 2-8
Seat belt precautions
................... 2-7
Warning beep
............................ 2-15
Warning light
............................ 2-14
Seats
Front seat
.................................... 2-2
Rear seat
...................................... 2-5
Security System
Theft-deterrent system
.............. 3-20
Service Publications
......................... 9-16
Spare Tire and Tool Storage
.............. 7-3
Specifications
................................... 10-4
Speedometer
..................................... 5-19
S
SRS Air Bags
Air bag system description
........2-27
Supplemental restraint systems
precautions
................................2-23
Warning light
............................2-31
Starting the Engine
.............................5-3
Steering Wheel
.................................3-22
Horn
..........................................5-36
Storage Compartments
.....................6-38
Sunroof
.............................................3-18
Sunshade
...........................................3-18
Sunvisors
..........................................6-34
T
Tachometer .......................................5-20
Temporary Spare Tire
......................8-27
Theft-Deterrent System
....................3-20
Tiedown
Hook
..........................................7-16
Tires
Flat tire
........................................7-3
Inflation pressure
.......................8-25
Replacement
..............................8-26
Rotation
.....................................8-26
Snow tires
....................................4-8
Spare tire and tool storage
...........7-3
Specifications
............................10-6
Tire chains
...................................4-9
Uniform tire quality grading
system (UTQGS)
.......................9-12
Tool
....................................................7-3
Towing
Description
................................7-15
Emergency towing
....................7-15
Hook
..........................................7-16
Recreational towing
..................7-17
Trailer towing
............................4-10
J76Y.book Page 5 Wednesday, March 27, 2002 5:04 PM