2002 JEEP LIBERTY 001

(6) Before installing the bolts the threads should
be oiled with clean engine oil, wipe off any excess oil.
(7) Install main bearing bedplate to engine block
bolts 11, 17, and 20 finger tight. Tighten these bolts
down together until the bedplate contacts the cylin-
der block.
(8) To ensure correct thrust bearing alignment,
perform the following steps:
²Step 1: Rotate crankshaft until number 4 piston
is at TDC.
²Step 2: Move crankshaft rearward to limits of
travel.
²Step 3: Then, move crankshaft forward to limits
of travel.
²Step 4: Wedge an appropriate tool between the
rear of the cylinder block(NOT BED PLATE)and
the rear crankshaft counterweight. This will hold the
crankshaft in it's furthest forward position.
²Step 5: Install and tighten bolts (1±10) in
sequence shown in (Fig. 45) to 41 N´m (30 ft. lbs.).
²Step 6: Remove wedge tool used to hold crank-
shaft.
(9) Tighten bolts (1±10) again to 41 N´m (30 ft.
lbs.) +1/4 turn in sequence shown in (Fig. 45).
(10) Install main bearing bedplate to engine block
bolts (11±20), and torque each bolt to 28 N´m (20 ft.
lbs.) in sequence shown in (Fig. 45).
(11) After the main bearing bedplate is installed,
check the crankshaft turning torque. The turning
torque should not exceed 5.6 N´m (50 in. lbs.).
(12) Install balance shafts and housing assembly.
(Refer to 9 - ENGINE/VALVE TIMING/BALANCE
SHAFT - INSTALLATION)
(13) Install the oil pump and pickup tube. (Refer
to 9 - ENGINE/LUBRICATION/OIL PUMP -
INSTALLATION)
(14) Install the timing belt rear cover. (Refer to 9 -
ENGINE/VALVE TIMING/TIMING BELT / CHAIN
COVER(S) - INSTALLATION)
(15) Install the timing belt. (Refer to 9 - ENGINE/
VALVE TIMING/TIMING BELT/CHAIN AND
SPROCKETS - INSTALLATION)
(16) Install the timing belt front covers. (Refer to 9
- ENGINE/VALVE TIMING/TIMING BELT / CHAIN
COVER(S) - INSTALLATION)
(17) Install engine support bracket.
(18) Install the oil pan. (Refer to 9 - ENGINE/LU-
BRICATION/OIL PAN - INSTALLATION)
(19) Install the oil filter.
(20) Install crankshaft rear oil seal. (Refer to 9 -
ENGINE/ENGINE BLOCK/CRANKSHAFT OIL
SEAL - REAR - INSTALLATION)
(21) Install flex plate. Apply MopartLock & Seal
Adhesive to bolt threads and tighten to 95 N´m (70
ft. lbs.).(22) Install the engine assembly. (Refer to 9 -
ENGINE - INSTALLATION)
CRANKSHAFT MAIN
BEARINGS
STANDARD PROCEDURE - MAIN BEARING -
FITTING
For crankshaft specifications (Refer to 9 - ENGINE
- SPECIFICATIONS).
CRANKSHAFT MAIN BEARINGS
The crankshaft is supported in five main bearings.
All upper and lower bearing shells in the crankcase
have oil grooves. Crankshaft end play is controlled by
a flanged bearing on the number three main bearing
journal (Fig. 46).
Upper and lower Number 3 bearing halves are
flanged to carry the crankshaft thrust loads and are
NOT interchangeable with any other bearing halves
in the engine (Fig. 46). All bearing cap bolts removed
during service procedures are to be cleaned and oiled
before installation. Bearing shells are available in
standard and the following undersized: 0.025 mm
(0.001 in.) and 0.250 mm (0.010 in.). Never install an
undersize bearing that will reduce clearance below
specifications. Replace or machine the crankshaft as
necessary to obtain proper bearing clearances.
MAIN BEARING INSTALLATION
(1) Install the main bearing shells with the lubri-
cation groove in the cylinder block (Fig. 47).
Fig. 46 Main Bearing Identification
1 - OIL GROOVE
2 - MAIN BEARINGS
3 - OIL HOLE
KJENGINE9s-35
CRANKSHAFT (Continued)

INSPECTION
(1) Inspect the mating surface of the oil pump.
Surface should be smooth. Replace pump cover if
scratched or grooved.
(2) Lay a straightedge across the pump cover sur-
face (Fig. 84). If a 0.025 mm (0.001 in.) feeler gauge
can be inserted between cover and straight edge,
cover should be replaced.
(3) Measure thickness and diameter of outer rotor.
If outer rotor thickness measures 9.40 mm (0.370 in.)
or less (Fig. 85), or if the diameter is 79.95 mm
(3.148 in.) or less, replace outer rotor.
(4) If inner rotor measures 9.40 mm (0.370 in.) or
less replace inner rotor (Fig. 86).
ASSEMBLY
(1) Assemble pump, using new parts as required.
Install the inner rotor with chamfer facing the
cast iron oil pump cover.
(2) Prime oil pump before installation by filling
rotor cavity with engine oil.
(3) Install cover and tighten fasteners to 12 N´m
(105 in. lbs.).
CAUTION: Oil pump pressure relief valve must be
installed correctly or serious engine damage may
occur.
(4) Install relief valve, spring, gasket and cap.
Tighten cap to 41 N´m (30 ft. lbs.).
INSTALLATION
(1) Make sure all surfaces are clean and free of oil
and dirt.
(2) Apply MopartGasket Maker to oil pump as
shown in (Fig. 87). Install O-ring into oil pump body
discharge passage.
(3) Prime oil pump with engine oil before installa-
tion.
(4) Align oil pump rotor flats with flats on crank-
shaft. Install the oil pump to the block.
CAUTION: To align, the front crankshaft seal MUST
be out of pump, or damage may result.
(5) Install new front crankshaft seal using Special
Tool 6780 (Fig. 88).
(6) Install crankshaft key (Fig. 82).
CAUTION: The crankshaft sprocket is set to a pre-
determined depth from the factory for correct tim-
ing belt tracking. If removed, use of Special Tool
6792 is required to set the sprocket to original
installation depth. An incorrectly installed sprocket
will result in timing belt and engine damage.
Fig. 84 Checking Oil Pump Cover Flatness
1 - STRAIGHT EDGE
2 - FEELER GAUGE
3 - OIL PUMP COVER
Fig. 85 Measuring Outer Rotor Thickness
Fig. 86 Measuring Inner Rotor Thickness
9s - 50 ENGINEKJ
OIL PUMP (Continued)

JEEP LIBERTY 2002
SPARE WHEEL & HARDWARE19-020-<8)
21-522~
23 .lLI
11
b
RACK & PINION10
~66~ -
24I14~
~2~
!
31~J~L2S--£3J
!;:;q)17
118-#~ I~
12~
/~004-09516 ~~'"
5~132616A-15~~
1 Wheel, Spare 14Steel 5GL65S4AAA 160.00 16 004 09907Alloy --
16x7Code WLD 10 Arm, Upper Control AiL 52088632AA m #2.0 128.00To 10-1-01 5GL67PAKAA 249.00 #W/Steering Knuckle Assy Removed Deduct 1.2 004 09522 c~From 10-1-01 5GL67PAKAB 24900 11 Bum~r, Control Arm AiL 52088684AB m 25.75 -
Code WND 5GL66PAKAB 260'00 12 Knuckle Assy, Steering R 52088652AA m #1.7 127.0017x7.5 .L 52088653AA m #1.7 127.00 1 Gear Assy, SteeringCode WGO 5HW90ZDRM 249.00 #/ncludes R&R Brake Rotor and Hub & Bearing Assy, 2.4L Eng 52128588M m #1.9 484.00Code WGR 5HW90AFMAA 24900 R&R Both Sides 3.2 37L Eng 52128518M m #1.9 459.002 Jack 52059104 83:35 13 Joint, Lower Balll] AiL 5069161AB m 2.0 27.50 #W/4WD Add 3.63 Wrench, Lug 52059478AA 12.85" l]/nc/uded w/Steering Knuckle Assy 2 Boot, Steering Gear1J AiL 5O72446M m 57.104 Bracket, Jack 52059369M 16.35!114Arm,LowerControl R 52088636AD m#2.2 117.00 3Bolt,Mountingl] AiL 6506517M 7.505 Label, Jack Instructions-See InforrnatJon Labels SectJon L 52088637AD m #2.2 117.00 4 Nut, MountJng:~ AiL 6504707 2.456 Bracke~ Spare. Wheel 55155933AB 59.10 #Includes R&R Bushings, w/Steering Knuckle 5 Bushing, Steering Gear1J AiL 52038783AB 15.20Cover, :opare Tire 5JG141X7M Removed Deduct.9 l1/nc/uded w/Steering Gear AssyAiL 52088746M m 12.25 6 Rod, Outer Tie R 5O72444M 46.70AiL 52088649AC m L 5072445M 46.70
AIL 6507080AA18 Bolt, Lower Carn (2/Side) AiL 6507321M19 Nut, Absorber AiL 6506443M 1.5020 Retainer, Absorber AiL 52089069M 2.25 2.4L ENG21 Mount, Absorber R 52128532AA m #1.8 91.70L 52128533AA m #1.8 91.7022 Isolator, Upper Spring AiL 52088686M m #1.8 16.25 423 Springl] AiL 52088625M m #1.8 35.75~.tr24 Absorber, Shock11 AiL 52088650AB m #1.8 36.95 111Additional Parts &lor Dealer Contact Required 0 3125 Isolator, Lower Spring AiL 52088686M m #1.8 16.25 -
I #R&R One Side Complete, Includes R&R ClevisAbsorber, w/Steering Knuckle Assy Removed Deducr ~.7, R&R Both Sides 3.426 Clevis, Absorber AiL 52088748AC m #.6 49.75#W/Steering Knuckle Assy Removed Deduct.4
29\",~~-l 004-09908
27 Retainer, Stab Bar AiL 52088631M m #.3 9.70 I128 Bushing, Slab Bar AiL 52088778M m #.3 4.60 c 004 09909#R&R One Side Complete, Not Included in O/H! -
29 Link, Stab Bar Ail 52088662AB m #.3 43.75PS.#Not Included in O/H 1 ump, teerlng30 Bar, Stabilizer 52088660M m #.8 98.25 2 Pulley, ~ump#Includes R&R Stab Bar Links, Bushings & Retainers 3 Reservoir, Pu~pNot Included in O/H 4 Cap, Reservoir.Bracket, Reservoir
6
~",,3
2
m .3m .3
52
Use Procedure Explanation 11 with the following text.
R&I Suspension/Sub.Frame Assy2WD m#2.74 WD m #3.6#Not Included in O/H SuspensionO/H SuspensionOne Side , R/Lm 4.7Both Sides. m 8.4Bleed Brake Systemw/ABS m .6w/oABS m .3AdjustFrontAlignment m 1.5NOTE 1: R&UR&R or O/H Does Not include alignment or bleedbrake system.
NOTE 2: All Parts in this section are included in overhaulunless noted otherwise.
/1
I'~~II::It
52088711AA m 1.7 130.0053031722AA m 21.6052088713AA m .5 40.2552128513AA 10.4552088874AD 43.4552088722AC m .8 163.0052088718AC m 23.4552128561AA m .9 174.00
5
~L-7 Cooler, SteeringR&I Axle Housing Assy m 3.0R&I Outer Axle Shaft Assy R/Lm #1.5#WlSteering Knuckle Assy Removed Deduct .93.7L ENG
4004-09906
004-09520
1 Nut, Axle AiL 6506454AA m 8.502 Rotor, Brake AiL 52128247AA m #.9 104.00#R&R Both Sides 1.63 Caliper, Brake R 5066422AA m #.5 182.00 IL 5066423AA m #.5 182.00 I4 Bracket, Caliper Mounting AIL 5019986AA m #.5 42.50#R&R One Side Complete, w/Brake Rotor RemovedDeduct .3, R&R Both Sides .85 Pad Set, Brake 5066427AA m #1.0 128.00#Deduct .5 for Each Brake Caliper Removed6 Hub & Bearingw/ABS R 52128692AA m #1.3 259.00L 52128693AA m #1.3 259.00w/o ABS AiL 52128352AB m #1.3 259.00I#Includes R&R Brake Rotor, R&R Both Sides 2.47 Stud, Wheel AiL 6O36388AA m 2.958 Sensor, Front ABS-See ABSIBrakes Section9 Hose, Front Brake R 52128312AA m #.3 18.35L 52128311AA m #.3 18.35#W/Caliper Removed Deduct .2
567Procedure Explanation Pages Must Be Used with the Above Text for an Accura'~ Damage Report.Comments or suggestions? Need assistance? Call 1-800-854-7030 or 858/578-6550, Ext 8220. Fax 1-888-256-7969 or 858/549-0629.CH
R&I Steering Gear Assy m #1.7#W/4WD Add 3.6
NOTE: R&R Does Not include adjust wheel alignment.~
6~9 2
67rl1
~'~
3 2,
51 Shaft Assy, Outer Axle f IA
~,::;~~~~2.4LEng R 5066022AA m#1.5 994.00cJ1y L 5066023AA m #1.5 1155.00'
3.7L Eng R 5066020AA m #1.5 1020.00L 5066021AA m #1.5 1155.00#WlSteering Knuckle Assy Removed Deduct .92 Boot Kit, Inner1j AiL 5066024AA m 26 203 Boot Kit, Outer1j AiL 5066025AA m 25:50~/ncluded w/Outer Axle Shaft Assy 004-09524
Bracket, Mountin~2.4L Eng R 52059472AB m 81.85 1 PumplReservoir. Assy, Steering 52088710AA m 2.4 130.00L 52059473AB m 54.50 2 Cap, Reservolr1j 52088956AA 27.453.7L Eng R 52059464AB m 81.85 ~/ncluded w/Steering Pumf)/ReseIVo;r AssyL 52059465AB m 30.85 I 3 Pulley, Pump 5:3010258AC m #.3 20.25

JEEP LIBERTY 2002
2.4L ENGNOTE: All Parts in this section are included in R&R SteerinaColumn unless noted otherwise.
WHEEL & TRIM
2
~fI::;~~ ~/\1f'R14
151
r-54
4~3
~~29
~
5004-09529
1 Mount, Eng R 52059252AAL 52059253AA2 Mount, Trans 52059299AA3 Crossmember, Trans 52128592AA#/ncludes R&R Trans Mount
2
1~18.6 142.00.8 109.00.7 123.00'1.1 40.4519,.
004-09527
004-09910 ~
1 Wheel, Steeringll UR71 DX9AA m .5 136.00llAdditional Parts &lor Dealer Contact Required2 Module, Driver Air Bag-See Air Bag System Section3 Switch, Remote Radio R 560423f2AB m #.4 14.25L 56042313AB m #.4 13.50#R&R Both Sides .64 Switch, Cruise ControlLimited Mode! R 56010358AB m .3 24.60L 56010359AB m .3 24.60IRenegade, Sport Model R 56010088AC m .3 14.60L 56010089AC m .3 14.605 Clockspring-See Air Bag System Section
3.7L ENG
f17~
COLUMN
2
3~m 1.5m 2.5R&I Steering Column O/H Steering Column (Includes R&I)
9-AA
5 Belt, Timing 4621844 m 3.8 78.606 Tensioner, Timing Belt 53010371AA m #.2 0.001I 7 Pulley, Idler 53013324AA m #.1 20.458 Gear, Camshaft (2) 4667609 m #.2 24.109 Gear, Crankshaft 4621918 m #.2 18.35#W/Timing Belt Removed10 Cover, Inner Timing 53010482AB m 39.50 004-0953011 Cover Valve 53010493AC m .7 87.6012 Cap, Oil Filler 4648831AA 6.85 1 Mount, Eng R 52059226AA13 Gasket, Valve Cover 4777478 m 84.45 L 52059227AA14 Dipstick, Eng Oil 53010494AA 6.10 2 Mount, Trans15 Tube, Eng Dipstick 53010476AB .5 9.6Q 2 WD16 Pan, Eng Oil 53010491AA m 1.6 65.85 Man Trans 52059309AA17 Plug, Drain 6035417 5.25 Auto Trans 52059306AA18 Gasket, Eng Oil Pan 4621579 m 26.20 4 WD19 Pan, Trans vii Man Trans 52059324AA2 WD 4800078AA m.9 28.20 Auto Trans 52002334AB4 WD 5013681AA m.9 30.85 3 Crossmember, Trans 52058643AF#Includes R&R Trans Mount
.6 102.00.8 104.00
.7.7
.7.7'1.1
4 '
7~ 10 8-'-/
~J=::~~~$=l=~~::~
~ 114-12
5-"'1 1
6*
2~ ~
m 10.6R&I Enginefrrans Assy
32S
Q>--E
1 b~4
~A56010126AD
m .6 75.00I56010125AD m .6 75.0056010158AC m .5 29.204793576 m.7 5.205GK59DX9AB m #.3 6.20
96.206.25
6.206.20
5.45
.2-{
. 1 Cover, Engine Under2.4L Eng 52128540AA3.7L Eng 52128539AA2 Brkt, Eng Under Cover R 52128545AAL 52128544AA
.3 114.00.3 37.9517.9517.95
11
~
004-09911
1 Switch Combinationw/Fog Lampsw/o Fog LamRs2 Switch, Hazard3 Switch, Ignition4 Cover, Upper Column5 Cover, Lower ColumnMan TranswfTilt 5GE04DX9AB m #.3w/o Tilt 5GEOODX9AB m #.3Auto Transwmlt 5GE08DX9AB m #.3w/o Tilt 5GE06DX9AB m #.3#R&R Complete6 Trim, Ignition Cylinder 55314965AB m7 Shaft, Upper1jMan Trans 10To 12-16-01 55314993AB m 2.0 389.00 004-09528
From 12-17-01 5057077AA m 2.0 425.00Auto Trans Damper, Crankshaft N.A. m 1.0 0.00To 12-16-01 55314994AB m 2.0 350.00 1 Cover, Timing 53021238AA m 272.00From 12-17-01 5057078AA m 2.0 420.00 2 Cover, Valve R 53020996 m #.8 22.45l1Additional Parts &/or Dealer Contact Required L 53020995 m #.8 22.858 Shaft, Lower 55315022AB m .8 330.00 #R&R Both Sides 1.29 Bracket, No.1 Column 55314992AA m 9.85'3 Gasket, Valve Cover AiL 53020992-1 m 24.0010 Bracket, No.2 Column 55314987AA m 154.00 4 Housing, Oil Filler 53020890 m 26.1011 Bracket, Shaft 55315003AB m 11.00 5 Gasket, Oil Filler Housing 53020889AB 4.8512 Bracket, Lower Column 55315009AA m 8.85 6 Cap, 011 Filler 53032389AC 5.107 Dipstick, En~ Oil 53021026AE 1.70I8 Tube, Eng I?lpstick 53021274AE .5 4.259 Pan, Eng 011 53021000AB m 2.7 69.20Gasket, Eng Oil Pan 53021001 m 16.7010 Plug, Drain 6504894AA 5.25111 Pan, Trans Oil2 WD 4800078AA m 1.3 28.204 WD 5013681AA m 1.3 30.85
2.4L ENG
R&I Air Cleaner Assy.4
1~
2~-l1.b-!6it
3~~ 004-0953,
1 Cleaner Assy.. Air 53013102AAElement, Air "Ieane~ 5019443AATube, Air Cleane~ 53013093AA1llncluded w/Air Cleaner Assy2 Tube, Inlet 53013101AA3 Bracket, Air Cleaner 53013473AAGrommet, Air Cleaner 53013357AA
Use Procedure Explanation 12 with the following text..4 113.00.2 14.603.75
.2 51.0025.252.70
2.4L ENG
m 7.4R&I Engine/Trans Assy
Illustration Located in Next Column3.7L ENG
.4R&I Air Cleaner Assy6503553 3.2053010477AA m .9 47.9553010483AA m .3 11.85153010484AA m #1.3 12.35"nc'udes R&R Crankshaft Pulley
1 Boll,
CH568
~~~10/;1
97.3572.25
115.0067.8595.00:v

JEEP LIBERTY 200253031090-1 m 2.00~3 Pip Converter, Front 52100544AB 1.7 309.00(J>I-4 -<-," 4 HangerJront 52128598AA 10.50 2' ' 5 Muffleu I ailpipe 52101120AC.7 215.00
~6 Insulator, Front 52128501AA 10.507 Hanger, Rear 52128502AB 3.203 8 Insulator, Rear 52128501AA 10.50
~
---1.
~
3 !"f1
2 2--"-~:;;:~~
~4.4 11800560108513500.2.2~
004-0953;\.;!!..'
2.4L ENG#Includes R&R Battery & Battery Cover5 Harness, Battery2.4L Eng 56044120AD m3.7L Eng 56044172AC m~3
R&RExhaustSystemComplete ..#1.6#Does Not Include R&R Exhaust Manifold or Shield
1 2
169.7071.954HORN
3~~4
l8
8
~
/":\{~
~..~
:;'-7004-09916
53013096AB m .7 94.50 004-0991953013097AA 30 9552109571AA 7:10 1 Horn 56010313AB.3 25.8552109572AA 5.454891416AD m.9 110.00 IGNITION52128546AC 275024LENG52128550AA m .4 29:70 .
2
1 Canister, Vacuum2 Bracket, Canister13 Hose, No.1 Canister4 Hose, No.2 Canister004-09913 5 Pump, Leak Detection6 Tube, Leak Detection53013263AA m 1.3 137.00 7 Solenoid;. Purge4781255AA m 9.50 8 Sensor, uxygen52101249AB 1.1 0.00 2.4L Eng52101150AA 10.50 Front 56031110AA m #.5 100.0052101120AC .7 215.00 Rear 56029112AA m #.5 102.0052128501AA 10.50 3.7L Eng52128502AB 3.20 Front R 56041951AA m #.5 30.8552101126AA 10.50 L 56041950AA m #.5 30.851Rear R 56041953AA m #.5 30.85L 56041952AA m #.5 30.85#Add .3 for Each Additional
w .
~3
~
1-\,
~4 """'-lJ 004-09920
1 Module, Controlll 56041591AD m.6 0.00lIOrder by Application2 Coil, Ignition 5269670 m.4 109.003 Sensor, Crankshaft 56041552AC m .6 16.704 Sensor, Camshaft 56041432AD m .7 16.70
ALTERNATOR
'f§;f-1IGNITION3.7L ENG18.5010.851#.3 35.003
~223.7L ENG004-09918
~004-0992156044530AB m 1.1 200.0056044532AB m 1.1 159.00
56029700AA m .9 405.0056029914AA m .9 350.00
4861371AA 74.70
~3
1 Module, ControlllMan Trans 56041601AD m .6 462.00Auto Trans 56041606AD m .6 490.001l0rder by ApplicationCoil, Ignition 56028138AD m .4 28.352 Sensor, Crankshaft 5066882AA m.6 58.353 Sensor, Camshaft 5066856AA m.7 86.70~3
1 Alternator2.4L Eng124 Amp136 Amp3.7L Eng136 Amp160 Amp2 Bracket, Alternator2.4L Eng3 Belt,Alternator2.4L Engwi A/Cw/o A/C3.7L Eng
53013352AB5281351AB53032037AF
.6.6.7
19.6019.2019.20
R&R Exhaust System Complete #1.9#Does Not Include R&R Exhaust Manifolds or Shields
Jtt?
1~~~:!:;:a~4~
8~
STARTER
BATTERY
Illustration Located in Next ColumnV 004-09915
1 Manifold, Exhaust R 53031086AB m 13.4L 53031085AB m #2.5#R&R Both Sides 4.4jJ004-09538
~~N.A.56041503AA
55136959AB55360084AC
#.2 0.00#.2 4.60
9.35#.5 25.60
44'25!1 Battery44.25 2 Cover, Battery#R&R CompleteI 3 Bracket, Hold-DownI 4 Support, Batteryv
Procedure Explanation Pages Must Be Used with the Above Text for an Accurate Damage Report.Comments or suggestions? Need assistance? Call1-80o-I!54-7030 or 858/578-6550, Ext 8220. Fax 1-888-256-7969 or 858/549-0629.CH569
.2 14.6019 Shield, Exhaust Manifold Ail 53031092-310 Shield, Front Heat 55176791AA2.70 11 Shield, Rear Heat 55176792AA
~
1 Manifold Exhaust2 Gasket, Exhaust Manifold3 Pipe/Converter, Front4 Hanger:front5 Muffler! I ailpipe6 Insulator, Front7 Hanger, Rear8 Insulator, Rear
9 Shield, Exhaust Manifold 53013264AA10 Shield, Front Heat 55176791AA11 Shield, Rear Heat 55176792AA#W/Exhaust System Removed

Starter2.4L Eng3.7L Eng
STARTER Cont'd
56041436M m .9 159.0056041641AC m 1.8 159.0035 I-
r~..:::---~ ~;i:i~:~'"
4~
Use Procedure Explanation 13 with the following tex!.R&IWindshield ...#2.7#Includes Clean Up Old Adhesive as Necessary
5 ~8
~~~~ -,
S-(::~:~~::~~:::::::~ ,,~(" p-~~ ~
\\\
f,
~
'~
):1
004-09541
1 Cover, Cowl 55155850AB.3 102.002 Pin, Cowl (4) 6501925 1.853 Seal, Cowl 55235927AA.1 16.254 Panel, Dash 55177300AB #7.0 127.00#W/Plenum Panel Removed Deduct 2.05 Panel, Plenum 55176767AC 7.0 270.00
\\\
4~1'"~
JEEP LIBERTY 2002
ELECTRICALCont'd2211 racket, Instrument anel9- 12 Bracket, Hush Panel 78 7.60
113 Kit, Radio Bracke~ 5072596M 11.701]lncludes Both Sides14 Bracket, Audio Equipment 5072606M 10.4515 Striker} Glove Box Latch 5072605M 25.4516 Brk! KI!t Passenger Air Bag-See Air Bag System Section11 Latch, ulove BoxSlate Gray WQ54XDVM.1 35.50Taupe WQ54WL8AA.1 24.8518 Module, PassenQer Air Bag-See Air Bag System Section19 Bracket, Lower Steeling Column 5531498TAA 154.0020 Box, GloveSlate Gray WC86XDVAA #.2 219.00Taupe WC86WL8AA #.2 219.00#Includes R&R Glove Box Latch21 Bezel, CenterLimited Model WA96DX9AA.3 92.75Renegade, Sport Model 5072479AA .3 180.0022 Knob, Li9hter 4685536 12.0023 Outlet, Lighter 4793554 11.0024 Ashtray WA97DX9AA 25.0025 SpeakerStandard AiL 56038610AC 43.00Premium AiL 56038594AC 73.0026 Bracket, UpperSt~ring Column 55314992AA 9.85
~/-
~313028
r:l-32I27
8-34 004-09924
2
7
5WIPER SYSTEM
213 I!
""""",~~~~-~~~4
5
~,..~6
,--d
~ :: 1
11~~~ ~ 19 ~14 .7
21~h13 4 1822 r:13 IIII ~ L16 15~ 18!Jj,j17~ 'j;--16 ~-" ~24 ~ ~
1~20 004-09923
7lf26--
?7 Cluster Ass~Black 56010151AF m .9 445.00Chrome 56010461AF m .9 454.00llAdditional Palts &/or Dealer Contact Required28 Lens, Cluster (a)Black 4728962AB m 1.0 0.00Chrome 4832731AB m 1.0 46.45la) Included wlCluster Assy29 RadioCode RBP 56038586AD.5 650.00Code RBY 56038583AD.5 0.00Code RBB 56038588AG.5 390.00Code RAD 56038585AD.5 1170.00Code RBK 56038589AH.5 460.00Code RBT 56038584AD.5 0.0030 Changer, CD 82203465 .5 345.00131 Cable, CD Changer 56038596AE 37.7032 Switch, Mirror 56010093AA #.2 22.95#Included in R&R Left Front Door Trim Panel, NotIncluded in R&R Instrument Panel33 Switch;, Climate ControlI wi Nv 55037533AB m .5 80.00wlo NC 55037531AB m .5 62.95134 Knob, Climate Controlll 5069169AA 1.451]As Required
8004-09540
on
6--<:~
#1.1
,-"-;:;;;;;;::~4~10 1
WD851DVAAWD851LSAA
WD581DVAAWD581L8AA
WD591DVAAWD591L8AB5072905AA5072906AA
.6 29.35.6 29.35
.6 43.00.6 43.00
#.2 92.85#.2 92.85#.2 10.00#.2 118.00
Use Procedure Explanations 14 and 28 with the following text.Refinish Dash Panel 1.5Refinish Plenum Panel 1.0
Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles.Comments or suggestions? Need assistance? Call 1.800-854-7030 or 8!;8/578-6550, Ext 8220. Fax 1-888-256-7969 or 858/549-0629.570CH
' 2 004-09922
1 Glass, WindshieldChrysler 55235913AC #2.3 0.00 ...NAGS c DW01449GBN #2.3 958.30 Use Procedure Explanation 14 with the following text.#Includes Clean Up Otd Adhesive as Necessary R&llnstrument Panel.. m #5.02 Spacer, Windshield /4) 55360509AA .35 #tncludes R&I Steering Column & Floor Console3 Mould!ng. Upper W/$ 55235917AB 9.60 NOTE: All Parts in this section are included in R&R4 Moulding. Side WIS R 55360052AB .2 58.85 Instrument Panel unless noted otherwiseL 55360053AB .2 58.85 .
5 Mirror, Rear View 4805332AB .2 19.45 16 Button, Rear View Mirror 55076401 8.25 25-{!:Q7 Moulding, Inr W/S Garnish R 5GM92TL2AC .3 46.35 6-0L 5GM93TL2AC .3 46.3598 Visor, Sun 5Illuminated R UY66TL2AA .2 103.00 I 10 6L UY67TL2AA .2 106.00 ~Non-Illuminated R UY64TL2AA .2 61.95 ~ 6 1L UY65TL2AA .2 63.70 ()\4Clip, Visor R/L 5072343AA 2.60
4 Arm, Wiper R 5666970AAL 5066968AA#Includes R&R Wiper Blade5 Module, Wiper 55155895AA6 Reservoir, Washer 5066867AA#Includes R&I/R&R Air Cleaner Assy7 Cap, Reservoir 5066881AA8 Pump, WasherTo 8-3-01 5066880AAFrom 8-3-01 5018129ACGrommet Pump 5011809AA9 Sensor, Fluid Level 4882797Grommet, Sensor 5013755AANozzle, Washer AiL 55155854AB#Included in R&R Cowl Cover
Use Procedure Explanation 14 with the following text.R&IFloorConsole .3
NOTE: All Parts in this section are included in R&R FloorConsole unless noted otherwise.
2
~~~~~~
,~-.- ,-,..1'70 3 Door, Passenger Air Bag-See Air Bag System Section1 16'60 4 Panel, Instrument.116'60Slate Gray..To 6-14-01 WC85XDVAA m #6.5 517.00#.2 24.10 From 6-14-01 WC85XDVAB m#6.5 517.00#.2 26.00 Taupe
To 6-14-01 WC85WL8AA m #6.5 517,0078,35 From 6-14-01 WC85WL8AB m #6.5 517,0078.50 #Includes R&I Steering Column & Floor Console25005 Bracket, Instrument Panel R 5073523AA 39.95, L 5072615AA 30,8588 45 6 Grille, Instrument Panel (4) WC88DX9AA .1 0,00.7 Cover, Instrument Panel531.1100Slate Gray R 5GN55XDVAD .1 10,95, L 5GK19XDVAD .1 17,5094,2005 Taupe R 5GN55WL8AD .1 10.95, L 5GK19WL8AD .1 17,50#.2 10,00 8 Bezel, No.1 Instrument PanelLimted Model WB02DX9AA.2 30,70 004-09544Renegade, Sport ModelSlate Gray WB021DVAA.2 30.70 1 Console, FloorTaupe WB021L8AA.2 30,70 Man Trans9 Bezel, No.2 Instrument Panel Slate GrayLimited Model WB03DX9AA.1 25,45 TaupeRenegade, Sport Model Auto TransSlate Gray WB031DVAA.1 25.45 Slate GrayTaupe WB031 L8AA .1 25.45 Taupe10 Bezel, No.3 Instrument Panel 2 Lid, ConsoleLimited Model WB05DX9AA.1 22.10 Slate Grayi Renegade, Sport Model TaupeISlate Gray WB051DVAA.1 22.10 3 Latch, LidTaupe WB051l8AA.1 22.10 4 Hinge, Lid

JEEP LIBERTY 2002
23.35
60.0011.35
LeamerPassenger Sidew/ButtonLight Taupe AiL WA49TL2AASlate Gray AiL WA49XDVAAwiG ButtonLight Taupe AiL WA50TL2AASlate Gray AiL WA50XDVAADriver Sidew/Button WA49TL2AAwiG Button WA50Tl2AA9 Sleeve. HeadrestPassenger Side AiL 5066563AADriver Side AiL 5O66563AA
~21
10
5.505.50
5.505.50
5.505.50
11.9511.95
5 Holder, Cup 5072903AA6 Bezel, ConsolellLimited Model 5HK42SZ5AA.1Sport Model 5GP21 DX9AB .1lIAdditional Parts &lor Dealer Contact Required7 Bin, StorageSlate Gray 5GP34XDVABTaupe 5GP34WL8AB8 Bezel, SwitchFrontSlate Gray WA63XDVAATaupe WA63WL8AARearSlate Gray WA64XDVAATaupe WA64WL8AA9 Switch, Power WindowFront 56010090AC10 Cover, Console 5GG16DX9AB11 Cover, Rear Console::ilate Gray 5GP35XDVABTaupe 5GP35WL8AB.12 Switch, Power Window~ear 56010091AB_.
6.606.60
1 22.10I 22.10
1 22.101 22.10
1 0.001 11.85
1 11.101 11.10!-, 27.85f-5
14
, 10
~A
14~
LeatherPassenger SideLight TaupeSlate GrayDriver SideLight TaupeSlate Gray
UZ401 L2AAUZ401DVAA
UZ401L2AAUZ401DVAA
#.8 577.00#.8 577.00
#.8 577.00#.8 577.00
15
1':J
20
1~
.,-'i
Use Procedure Explanations 14,15 and 28 with the fol/owingtext.
Heated ---
Passenger SideUgh! Taupe UZ381L2AA 1.8 932.00Slate Gray UZ381DVAA #.8 932.00Driver SideUgh! Taupe UZ391L2AA #.8 932.00Slate Gray UZ391DVAA #.8 932.001Non-HeatedPassenger SideUght Taupe UZ361 L2AA 1.8 864.00Slate Gray UZ361DVAA 1.8 864.00Driver SideUght Taupe UZ371L2AA #.8 864.00Slate Gray UZ371DVAA 1.8 864.00#R&R One Side Complete, wISest Assy Removed3 Cover, Seat CushionClothPassenger SideISlate Gray UZ161DVAA Tau~ UZ161L5AA
Driver SideSlate Gray UZ171DVAAraupe UZ171L5AALeatherHeatedPassenger SideUgh! Taupe UZ201L2AASlate Gray UZ201DVAADriver SideUght Taupe UZ211 L2AASlate Gray UZ211DVAANon-HeatedPassenger SideUghtTaupe UZ181L2AASlate Gray UZ181DVAADriver SideLight Taupe UZ191L2AASlate Gray UZ191DVAA 4 Frame, Seat Cushionll
ManualPassenger Side 5072110AADriver Side 5072111AAPowerPassenger Side 5O72126AADriver Side 5072126AA1]Additional Palts &Jar Dealer Contact Required ~5 Heater, Seat Back .c
Passenger Side 5072368AADriver Side 5072368AA6 Heater, Seat CushionPassenger Side 5072369AAIDriver Side 5072369AA7 HeadrestClothPassen er SideSlate ~ray WB351DVAATaupe WB351L5AADriver SideSlate Gray WB351DVA.A.Taupe WB351L5AALeatherPassenger SideUght Taupe WA521L2AASlate Gray WA521DVAADriver SideLight Taupe WA521L2AASlate Gray WA521DVAA.. ..8 Cap, HeadrestClothPassenger Sidew/ButtonSlate GrayTaupeIwlo ButtonSlate Gray\raupe Driver Side
w/Buttonwlo Button
ROCKER/PILLARS
1
17--
g~285.00285.00
287.00287.00
004-09545
1 Panel, Outer Side Body Repair-See Side Body Section
FLOOR
1
16.3516.35
15.3515.35
""
~~6492.00350.00
495.003SQOO19.3513.3519.3513~~.,
~
),
144.00 I144.00
136.00136.00
20.5013.3521.70
13.35
13.3520.5013.3521.70
83.6083.6083.6083.60
65
87.9587.95
112.0011200
004-09546
1 Pan Assy, Front Floor 55176800AB #18.0 459.00#W/Each Front Frame Rail Removed Deduct 3.5, w/EachSide Body Si// Removed Deduct 2.02 Bracket, Floor1] 55360352AB 1.0 14.853 Crossmember, Front Seal1l R/L 55360058AA 1.5 23.954 Crossmember, Rear Seat1] 55360060AB 2.0 36.001]lncluded w/Front Floor Pan Assy5 Crossmember, Trans-See Englne/Trans Mounts Section6 Sill, Side Body R 55176878AA s 4.0 0.00L 55176879AA s 4.0 0.0012.7012.70
12.7012~0
.1 86.70.1 153.00
.1 86.701 15300LIMITED MODEL
R&I Seat AssyR/L.3
Illustration Located in Next Column5.505.50
5.505.50
5.505.50
AIL WA49XDVAAAIL WA49WL5AA
AIL WA50XDVAAAIL WASOWL5AA
AIL WA49WL5AAAIL WA50WL5AA
Seat Back
#.8 327.00#.8 327.00
#.8 327.00#.8 327.00
UZ311DVAAUZ311L5AA
UZ311DVAAUZ311L5AA
12.7012.70
12.7012.70
4.604.60
CH
3'(
~004-09547
SJt79-1 -S
2[;'
~C
~6
1.)
004-09548 "'i'-16
Adjuster, Seat Track10 ManualPassenger Side R 5072104AA #.5 97.10L 5072105AA #.5 123.00#R&R Both Sides .8, wISest Assy RemovedDriver Side R SO72107M #.5 97.10L 5072106AA #.5 t23.00#R&R Both Sides .8, wISest Assy RemovedI PowerPassenger Side WD24WL8AA #.4 799.00582.00 Driver Side WD25XDVAA #.4 799.00582.00I#WlSeat Assy Removed12 Handle, AdJuster585.00 Passenger Side 5072003AA ;,...;,---585.00 Dnver Side 5072003AA .;113 Cable, Recliner C
Passenger Side 5066458AADriver Side 5066458AA114 Shield, Adjuste~Manual ,Passenger Side R UZSOWL5AA .1L UZ42TL2AA .1Driver Side R UZ51WL5AA .1L UZ43TL2AA .1 ,---PowerPassenger SideHeatec R UZ541L2AA .1L UZ42TL2AA .1Non-Heated R UZ52TL2AA .1L UZ43TL2AA .1Driver SideHeated R UZ43TL2AA .1L UZ551L2AA .1Non-Heated R UZ43TL2AA .1L UZ53WL5AA .1,15 Recliner, Seat11; Passenger Side R 5072020AAL 5072021AADriver Side R SO72022AA.1 157.00 L 5072023AA.1 157.00IllAdditional Parts &/or Dealer Contact Required16 HandletRecliner.1 157.00 Light aupe.1 157.00 Passenger SideTo 6-1-01 UZ281L2AAFrom 6-1-01 UZ281L2ABDriver SideTo 6-1-01 UZ291L2AAFrom 6-1-01 UZ291L2AB -'./Slate Grav

JEEP LIBERTY 2002
FRONT SEAT Cont'd25.000.00#.4 799.00 I 5 Adjuster;. Seat Belt R/L 55315033AC#.4 799.00 6 Buckle, :oeat Belt11 R/L 5GM341L5AB '.2lIAdditional Parls &/or Deater Contact Required#w/Front Seat ASBY RemovedLIMITED MODEL Cont'd18 Switch, HeatPassenger Side 5GW44DX9ABDriver Side 5GW44DX9AB19 Switch, PowerPassen.Qer Side 55352782AADriver Side 55352782AA20 WIring, Seet1lPassenger Side 5O71990AADriver Side 5071991AA11Additional Parts &/or Dealer Contact Required21 Module, Heat ControlPassenger Side 56010113AADriver Side 56010113AA
25.4525.45
27.5027.50
40.9539.60
REAR
1
~2~
t'ower -
Passenger Side WD24WL8AADriver Side WD25XDVAA#WISest Assy Removed7 Handle, AdjusterPassenjjer Side 5072003AADriver Side 5072003AA8 Cable, ReclinerPassenjjer Side 5066458AADriver Side 5066458AA9 Shield, Adjuster1jManualPassenger Side R UZ50WL5AA .1L UZ42TL2AA .1Driver Side R UZ51WL5AA .1L UZ43TL2AA .1PowerPassenger SideHeateiJ R UZ541L2AAL UZ42TL2AANon-Heated R UZ52TL2AAL UZ43TL2AADriver SideHeated R UZ43TL2AAL UZ551L2AANon-Heated R UZ43TL2AAL UZ53WL5AA10 Recliner, Seal11Passenger Side R 5072020AAL 5072021AADriver Side R 5072022AAL 5072023AA1]Additional Paris &lor Dealer Contact Required11 Handle, ReclinerLight TaupePassenger SideTo 6-1-01 UZ281L2AAFrom 6-1-01 UZ281L2ABDriver SideTo 6-1-01 UZ291L2AAFrom 6-1-01 UZ291L2ABSlate GrayPassenger SideTo 6-1-01 UZ281DVAAFrom 6-1-01 UZ281 DVABDriver SideTo 6-1-01 UZ291 DVAAFrom 6-1-01 UZ291 DVABTaupePassenger SideTo 6-1-01 UZ281L5AAFrom 6'1-01 UZ281L5ABDriver SideTo 6-1-01 UZ291L5AAFrom 6-1-01 UZ291L5AB12 Knob, SwitchPassenjjer Side 4607042Driver Side 460704313 Switch, HeatPassenger Side 5GW44DX9ABDriver Side 5GW44DX9AB14 Switch, PowerPassenjjer Side 55352782AADriver Side 55352782AA15 Wiring, Seal11! Passenger Side 5071990AAIDriver Side 5071991AA1]Additional Paris &lor Dealer Contact Required16 Module, Heat Control! PassenSJer Side 56010113AADriver Side 56010113AA
16.3516.35
15.3515.35
19.3513.3519.3513.35~62.5062.50
RENEGADE, SPORT MODEL.1.1.1.1.1.1.1.1
3
~004-09550 ~20.50 1 Belt, Outer Rear Seat1] R 5HG341DVAD #1.0 112.0013.35 L 5HG331DVAB #1.0 209.0021.70 #Includes R&R Quarter Trim Panel13.35 2 Belt, Center Rear Seat1] 5HK441D2AA 119.003 Buckle, Rear Seat1] R 5GU581DVAD .2 30.9513.35 L 5GE491L5AD .2 45.6020.50 ~Additional Parts &/or Dealer Contact Required
83.60 I Use Procedure Explanations 16 and 28 with the following text.83.6083.60SHEET METAL
Refinish Door Outside. ...Add for Jambs & InteriorAddforJambs R&I Door Assy .""""'"
AIL 2.3AIL 1.0AIL .5AIL .612.7012.70
12.7012.70
1
""-l
12.7012.70
12.7012.70
#.8 28700#.8 287.00I#.8 287.00I#.8 287.0012.12:
12:12:
4.'4.'
25.25.
27.27.
40;39.'
~~004-09551
1 Cover, Seat BackSlate GrayPassenJjer Side UZ061DVAADriver Side UZ061DVAATaupePassenger Side UZ061L5AADriver Side UZ061L5AA2 Frame, Seat BackSlate GrayPassenger Side UZ321DVAA #.8 624.00Driver Side UZ331DVAA #.8 624.00TaupePassenJjer Side UZ321L5AA #.B 624.00Driver Side UZ331 L5AA #.B 624.00#R&R One Side Complete, wlSeat Assy Removed3 Cover, Seat CushionllSlate GrayPassenJjer Side UZ141DVAA 274.00Driver Side UZ141DVAA 274.00TaupePassenJjer Side UZ141L5AA 274.00Driver Side UZ141L5AA 274.004 Freme, Seat CushionManualPassenJjer Side 5O72110AA 144.00Driver Side 5O72111AA 144.00PowerPassenger Side 5O72110AA 144.00Driver S'tde 5O72126AA
~
1 Shell Assy, Door R 55176890AB #4.5 409.00L 55176891AB #4.5 410.00"ncludes R&UR&R Resr VIew Mirror2 Panel, Door Repair11 R 5066542AA #7.0 83.35L 5066543AA #7.0 0.001]lncluded wlDoor Shell Assy"ncludes R&UR&R Resr View MI"or & Door Glsss
EXTERIOR TRIM
R/L .4AiL #.6Refinish Side Moulding R&IRearViewMirror #Includes R&I Trim Panel
62.50!62.50
5-f1R&I Seal~Y:-: ;.,...~:::.:.:::::;;:.4
FRONT
1~~~~~~~~~~-, ~2
~~4~004-09552 --31 Moulding, Side (Adhesive)Limited ModelCode K2B I
Code K2E 1
Code K2F I
Code K2M
Code K2Q
Code K2R
Code K2S
Code K2T
Code K2W
Code K2X
\-52-t\)~
8/
i ~ TI\V6I
004-0954943
1 Belt, Front Seat1JTo 12-17-01 R 5HG341DVAD #.7 112.00L 5HG331DVAB #.7 209.00From 12-17-01 R 5HG341DVAC #.7 112.00L 5HG331DVAF #.7 260,00llAdditional Palts &lor Dealer Contact Required#Includes R&R Up~r & Lower Center Trim Panels2 Nut, Seat Belt R/L 6506002AA ,3 Plug, Lower TrimLight Taupe AiL 5HM79TL2AASlate Gray R/L 5HM79WL5AATaupe AiL 5HM79XDVAA
F 5GF54WB7ABL 5GF55WB7ABR 5GF54XGRABL 5GF55XGRABR 5GF54WE5ABL 5GF55WE5ABR 5GF54XRVABL 5GF55XRVABR 5GF54XBQABL 5GF55XBQABR 5GF54PR4ABL 5GF55PR4ABR 5GF54WS2ABL 5GF55WS2ABR 5GF54YU2ABL 5GF55YU2ABR 5GF54SW1ABL 5GF55SW1ABR 5GF54DX8ABL 5GF55DX8AB
.2 51.35.2 51.35.2 51.35.2 51.35.2 51.35.2 51.35.2 51.35.2 51.35.2 51.35.2 51.35.2 50.00.2 50.00.2 5f35.2 51.35.2 51.35.2 51.35.2 50.00.2 50.00..2 50.00.2 50.00
70
1.101.10
I1.10
Labor Times Shown are for Replacement with New OEM Undamaged Parts on New Undamaged Vehicles.Comments or suggestions? Need assistance? Call 1-800-854-7030 or 8~;8/578-6550, Ext 8220. Fax 1-888-256-7969 or 858/549-0629.572CH
7070
707060
604545
50501
95601