2002 HONDA PASSPORT belt

•
* 1
* 2Under severe driving conditions, service these items more often. –These fluids: brake, clutch, P/S, battery, ATF,
Using SAE 10W-40 oil, or any viscosity other than those recommended, may reduce engin\
e life and affect the warranty. windshield washer
This service is recommended only. – Tire pressure
204 Care and Maintenance
R – Replace L – Lube I – Inspect After inspection, clean, adjust, repair or replace if necessary.Service at the interval listed x1 000 il ( k ) ft th tx 1,000 miles7.51522.53037.54552.56067.57582.59097.5105Service at the interval listed x1,000 miles (or km) or after thatnumber of months whicheverx 1,000 km1224364860728496108120132144156168number of months, whichever
comes first.months612182430364248546066727884
Engine and TransmissionAir cleaner elementRRR
Fuel tank, cap, pipes, hoses and connectionsI
Spark plugsR
•Engine oil and oil filter * 1RRRRRRRRRRRRRREngine drive beltIII
Cooling system, heater hoses, and connectionsIIIIIII•Engine coolantRRR
Timing beltR*
2
Exhaust systemIIIIIIIIIIIIII
Starter safety switchIIIIIIIIIIIIII
Auto cruise control linkage and hoseIIIIIII
Radiator core and A/C condenserI
Manual transmission oil and transfer case oilRRRRAutomatic transmissionSee page 216.
Shift-on-the-fly systemIIIIValve clearanceAdjust only if noisy.
Check oil and coolant level at each fuel stop.Inspect monthly:
Maintenance Schedule

209Care and Maintenance
Sit in the driver
’s seat and
perform these checks:
1. With the engine stopped,
depress the brake pedal several
times; the travel distance and
effective pedal stroke should
remain unchanged.
2. Start the engine with the brake pedal fully depressed.
The brake pedal should go down
a little as the engine starts.
3. Depress the brake pedal, stop the engine and hold the pedal
depressed for about 30
seconds; the brake pedal
should remain in position
without rising or going down.
4. Restart the engine and run it for about a minute, then turn it
off and depress the brake
pedal firmly several times; the
brake pedal travel should decrease each time the brake
pedal is depressed.
If the brakes do not operate
normally, have them checked and
corrected by your Honda dealer.
Exhaust system — Be alert to any
changes in the sound of the exhaust
system or any smell of fumes.
These are signs the system may be
leaking or overheating. Have the
system checked and/or repaired at
once if these conditions exist. (Also
see “Carbon Monoxide Hazard” in
the “Driver and Passenger Safety ”
section and “ Three-Way Catalytic
Converter ” in the “Driving Tips ”
section.)
Windshield wipers and
washers —
Check the operation
and condition of the wiper blades.
Check the flow and aim of the
washer spray.
Defrosters — Check performance
by moving the controls to the
defrost setting and noting the
amount of air directed against the
windshield.
Rear view mirrors and sun
visors —
Check that the friction
joints hold the mirrors and sun
visors firmly in place.
Horn — Blow the horn now and
then to be sure it works.
Lap and shoulder belts — Check
the belt system, including
webbing, buckles, latch plates,
retractors, guide loops and
anchors for proper operation and
damage.
Seat adjusters — When adjusting
a seat, be sure the seat adjusters
latch securely by pushing the seat
forward and backward.

210Care and Maintenance
Seat-back latches — Seat-back
latches are designed to prevent
forward motion of the seat-back
when the vehicle stops suddenly.
Check to see that the seat-back
latches are holding by pulling
forward on the top of the folding
seat-back.
Also check to see that the
reclining seats are operating
properly.
Lights and beepers — Check
panel lighting, warning lights, and
the seat belt reminder light and
beeper. Also check the key beeper
and interior lights. On the outside,
check the license plate light, side
marker lights, headlights, parking
lights, taillights, brake lights, turn
signals, backup lights and hazard
warning flashers. Have the
headlight aim checked promptly if the beams seem to be aimed
improperly.
Glass — Check for broken,
scratched or damaged glass that
could reduce visibility or cause
injury.
Door latches — Check that the
doors close, latch and lock
securely.
Hood latch — Check that the
hood closes firmly. Check for
broken, damaged, or missing parts
that might prevent secure
latching. Make sure the secondary
latch keeps the hood from
opening all the way when first
released.
Fluid leaks — Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked
for awhile. Water dripping from
the air conditioning system after
use is normal. If you notice
gasoline fumes or fluid at any
time, locate the source and have it
corrected at once.
Spare tire and jack — Check that
the spare tire and all jack gear are
securely stowed at all times.
Tailgate latch — Check that the
tailgate closes, latches and locks
securely.

222Care and Maintenance
Front (4WD Only) and Rear
Propeller Shaft
Lubricate the sliding yoke with
EP chassis grease. Lubricate
universal joints with grease
containing MoS
2 (molybdenum
disulfide-type grease) at the
intervals shown in the
Maintenance Schedule. Also
check the propeller shaft
flange-to-pinion bolts for proper
torque of 64 N⋅ m (46.3 lb-ft).
Most lubrication recommendations
and procedures for four-wheel drive-
equipped vehicles are the same
for the corresponding components
in conventional drive vehicles.
Exhaust System
Check the complete exhaust
system and nearby body areas for
damaged, missing, or
mispositioned parts, open seams, holes, loose connections, or other
deterioration that could allow
exhaust fumes to seep into the
passenger compartment or cause
heat build-up in the floor pan. Any
necessary corrections should be
made immediately. For continued
safety, exhaust system pipes and
resonators rearward of the muffler
must be replaced whenever a new
muffler is installed.
Fuel Line and Fuel Tank/Cap
Inspect the fuel tank, cap and lines
for damage that could cause
leakage. Inspect the fuel cap and
gasket for correct sealing ability
and indications of physical
damage. Replace any damaged or
malfunctioning parts.
Drive Belt
Check the belt driving the
alternator, power steering pump,
and air conditioning compressor.
Look for cracks, fraying, and
wear. Replace as necessary.
Timing Belt
The timing belt should normally
be replaced at the intervals shown
in the Maintenance Schedule.
Valve Clearance
Incorrect valve clearance will
result in increased engine noise
and lower engine output, thereby
adversely affecting engine
performance.

229Care and Maintenance
•If an odor persists after
cleaning vomit or urine, treat
area with a water-baking soda
solution: 1 teaspoon (5 milliliters)
baking soda to 1 cup (250
milliliters) of warm water.
•Finally, if needed, clean lightly
with a fabric cleaner (solvent
type).
Combination Stains
These include candy, ice cream,
mayonnaise, chili sauce and
unknown stains.
•Carefully scrape off excess
stain; then clean with cool
water and allow to dry.
•If stain remains, clean with a
fabric cleaner (solvent type).
Cleaning Vinyl or Leather Trim
Ordinary soilage can be removed
from vinyl or leather with warm
water and a mild soap such as
saddle soap, oil soap or
equivalent.
•Apply a small amount of soap
solution and allow it to soak for
a few minutes to loosen dirt;
then rub briskly with a clean,
damp cloth to remove dirt and
traces of soap. (This may be
repeated several times, if
necessary.)
•Some compounds such as tar,
asphalt, shoe polish etc. will
stain if allowed to remain on
trim. They should be wiped off
as quickly as possible and the
area cleaned with a clean cloth
dampened with vinyl cleaner
(solvent type).
Seat Belt Care
•Clean seat belts only with mild
soap and lukewarm water.
•Do not bleach or dye belts
since this may severely weaken
them.

247Owner Assistance
Your new Honda is covered by
these warranties:
New Vehicle Limited Warranty
–
Covers your new vehicle, except
for the battery, emissions control
systems and accessories, against
defects in materials and
workmanship.
Emission Control Systems
Defects Warranty and Emissions
Performance Warranty


These
two warranties cover your
vehicle’ s emission control
systems. Time, mileage, and
coverage are conditional. Please
read the warranty manual for
exact information.
Original Equipment Battery
Limited Warranty


This
warranty gives up to 100% credit
toward a replacement battery. Seat Belt Limited Warranty


A seat belt that fails to function
properly is covered for the useful
life of the vehicle.
Rust Perforation Limited
Warranty
 All exterior body
panels are covered for rust-through
from the inside for the specified
time period with no mileage limit.
Accessory Limited Warranty

Genuine Honda Accessories are
covered under this warranty. Time
and mileage limits depend on the
type of accessory and other
factors. Please read your warranty
manual for details.
Replacement Parts Limited
Warranty

– Covers all Genuine
Honda replacement parts against
defects in materials and
workmanship. Replacement Battery Limited
Warranty

 Provides prorated
coverage for a replacement
battery purchased from a Honda
dealer.
Replacement Muffler Lifetime
Limited Warranty

– Provides
coverage for as long as the
purchaser of the muffler owns
the vehicle.
Restrictions and exclusions apply
to all these warranties. Please read
the 2002 Honda Warranty booklet
that came with your vehicle for
precise information on warranty
coverages. Your Honda ’s original
tires are covered by their
manufacturer. Tire warranty
information is in a separate
booklet.
Warranty Coverages

255
A
ABS.
See Anti-Lock Brake
System
Accessories, Installation
173. . . .
ACCESSORY
(Ignition Key Position)101. . . . .

\b 
\b\f

 117
\b\b\b\b\b
Adults\b 

 10
\b\b\b\b\b\b\b\b\b\b\b
Airbags (SRS)7. . . . . . . . . . . . .
\f\b\b
\b 19
\b\b\b\b
Air Cleaner Filter170, 214. . . . . .
Air Conditioning Maintenance
221. . . . . . . . . . .
Usage
120. . . . . . . . . . . . . . . . .
Air Filter. See Air Cleaner Filter
Air Outlets (Vents)
124. . . . . . . . .
Air Pressure, Tires
239. . . . . . . . . Alcohol and Driving
4. . . . . . . .
Alcohol in Gasoline
200. . . . . . . .
Alternator Belt. See Drive Belts
Antifreeze
217. . . . . . . . . . . . . . . .
Anti-Lock Brake System Indicator
67. . . . . . . . . . . . . . .
Operation
159. . . . . . . . . . . . . .
Anti-Theft Steering Column Lock
102. . . .
System
152. . . . . . . . . . . . . . . .
Appearance Care. See Cleaning
Ashtray
116. . . . . . . . . . . . . . . . . .
Assist Grip
115. . . . . . . . . . . . . . .
Audio System
125. . . . . . . . . . . . .
Automatic Transmission
76. . . .
Capacity, Fluid
237. . . . . . . . . .
Driving Pattern Selector
81. .
Fluid Temperature Indicator
70
Oil Temperature Indicator70.
Shift Lever Position Indicator
76. . . . . . .
Shift Lock
78. . . . . . . . . . . . .
Transfer Control, 4
WD80. . .
B
Battery198. . . . . . . . . . . . . . . . . .
Charging System Indicator
62
Jump Starting184. . . . . . . . . . .
Maintenance
198. . . . . . . . . . .
Specifications
238. . . . . . . . . .
Before Driving
156. . . . . . . . . . . .
Belts, Seat
6. . . . . . . . . . . . . . . .
Additional Information
41. . .
Beverage Holder
113. . . . . . . . . .
Body Repair
225. . . . . . . . . . . . . .
Brakes Anti-Lock Brake System
159. .
Brake System Indicator
61. . .
Index

256
Break-in158. . . . . . . . . . . . . . .
Fluid
219. . . . . . . . . . . . . . . . . .
Parking
86. . . . . . . . . . . . . . . .
Power
161. . . . . . . . . . . . . . . . .
Wear Indicators
162. . . . . . . . .
Break-in, New Vehicle
158. . . . . .
Brightness Control, Instrument Panel. See Illumination Control
Brights, Headlights
62. . . . . . . .
Bulb Replacement Specifications
243. . . . . . . . . . . .
C
Capacity Charts235. . . . . . . . . . .
Carbon Monoxide Hazard
47. . .
Care and Maintenance
195. . . . . .
Cargo Loading
233. . . . . . . . . . . . . . .
Carrying
17 . . . . . . . . . . . . . . . Cassette Player
Care
141. . . . . . . . . . . . . . . . . .
Operation
128. . . . . . . . . . . . . .
Catalytic Converter, Three-Way
172. . . . . . . . . . . . . .
CAUTION, Explanation ofiv. . .
CD Changer131. . . . . . . . . . . . . .
Certification Label
234. . . . . . . . .
Chains, Tire
168. . . . . . . . . . . . . .
Changing Oil How to
212. . . . . . . . . . . . . . . .
When
204, 205, 211. . . . . . . . .
Changing a Flat Tire
186. . . . . . .
Lifting Points
187. . . . . . . . . . .
Changing Engine Coolant
218. . .
Charging System Indicator
62. .
Check Engine Light
63. . . . . . . .
Checklist, Before Driving
156. . . Children, Protecting
18. . . . . . . .
Child-Safe Door Locks
105. . . . .
Child Seats, General Guidelines
22. . . . . . .
Cigarette Lighter
116. . . . . . . . . .
Circuit Breaker, Checking the
108
Cleaner, Air214. . . . . . . . . . . . . .
Cleaning Exterior
224. . . . . . . . . . . . . . .
Interior
226. . . . . . . . . . . . . . . .
Seat Belts
229. . . . . . . . . . . . . .
Vinyl
229. . . . . . . . . . . . . . . . .
Clock, Setting the
153. . . . . . . . . .
Clutch Fluid
223. . . . . . . . . . . . . .
CO in the Exhaust
47, 249. . . . . .
Consumer Information
246. . . . . .
Control Locations
56. . . . . . . . .
Controls, Instruments and
55. . .