2002 HONDA PASSPORT service

232Technical Data
Vehicle Identification
Number (
VIN)
This is the legal identification of the
vehicle. It appears on a plate attached
to the left top of the instrument panel
and can be easily seen through the
windshield from outside the vehicle.
Engine type – W; 6VD1 3.2L
4S6DM58WI24400032
The VIN also appears on the
vehicle’s Certification Label on
the driver’s door lock pillar.
Engine Identification
You can identify your engine from
the
VIN. The eighth character of
the
VIN is the engine code that
gives the engine model (refer to
the illustration).
Some information in this section
may refer to the engine model.
The engine number is stamped on
the left side of the cylinder block
near the starter.
Service Parts Identification
The Vehicle Information Plate
(Service Parts
ID Plate) is
provided on all vehicle models.
It is located on the center dash
wall inside the engine
compartment. The plate lists the
VIN (Vehicle Identification
Number), paint information and
all production options and special
Vehicle Identification

233Technical Data
equipment on the vehicle when it
was shipped from the factory. Be
sure to provide this information to
your authorized Honda dealer
when it is necessary to order
parts.
Vehicle Loading Information
The components of your vehicle
are designed to provide
satisfactory service only if the
vehicle is not loaded in excess of
either the Gross Vehicle Weight
Rating (
GVWR) or the maximum
front and rear Gross Axle Weight
Ratings (
GAWRs). These ratings
are listed on the Vehicle
Certification Label located on the
left door lock pillar.
Your Honda dealer can advise you
of the proper loading conditions
for your vehicle. The use of
selected heavier suspension
components for added durability
purposes does not increase any of
the weight ratings printed on the
Vehicle Certification Label.
Maximum Front and Rear
Axle Weight
The weight of the cargo load must
be properly distributed over both
the front and rear axles. The
Certification Label shows the
maximum weight that the front
axle (front
GAWR) can carry. It
also shows the maximum weight
that the rear axle (rear
GAWR) can
carry. The
GVWR represents the
maximum permissible loaded
weight of the vehicle and takes
into account the engine,
transmission, frame, springs,
brake, axle, and tire capabilities.
Actual loads on the front and rear
axles can only be determined by
weighing the vehicle. This can be
done at highway weight stations
or other such commercial weigh
stations. Consult your Honda
dealer for assistance. The cargo
Vehicle Loading

Technical Data235
These specifications are given here for information only. Before using them, see the cautions and other instructions
throughout this manual. For further information, see the Service Manual covering the cha\
ssis or body parts in question.
Your Honda dealer may also be able to help.
Engine
Engine modelV632LItemV6-3.2L
Engine typeWater cooled 4-stroke, 75
V
Piston displacement193.1 cu.in. (3,165 cc)
Number of cylinders6
Compression ratio9.1:1
Spark plugsPK16PR11
Spark plug gap0.04 in. (1.05 mm)
Oil filterFull-flow cartridge type
Oil capacity (Original factory fill or rebuilt engine)6.3 U.S. quarts (6.0 liters)
*Oil capacity (Service change)
with filter change
without filter change
5.0 U.S. quarts (4.7 liters)
4.2 U.S. quarts (4.0 liters)
Idle speed750 rpm
Valve clearance (Cold)Intake
Exhaust0.011
0.002 in. (0.28
0.05 mm)
0.012
0.002 in. (0.30
0.05 mm)
* Oil capacities shown are approximate refill capacities.
* After refill, recheck oil level.
Specifications

238Technical Data
Front Suspension
Independent wishbone arms, torsion bar springs with
stabilizer bar.
Front Wheel Alignment
Toe-in2

2 mm (0.08 in.)–
Camber0°
30No more than 30 
side-to-side variation
Caster2
30 
45No more than 30 
side-to-side variation
Rear Suspension
5-link, coil spring type with stabilizer bar and direct
double-acting shock absorbers.
Rear Wheel Alignment
Toe-in0
5 mm (0.2 in.)
Camber0°
1°
Toe-Axis
1

Steering
Rack and pinion.
Service Brake
Hydraulic Front: Disc brake.
Rear: Self-adjusting drum brake, leading-trailing (2
WD model).
Disc brake (4
WD model).
Parking Brake
Mechanical, operating on rear wheels (2
WD model).
Mechanical, drum in disc, duo-servo, manual-adjusting,
operating on rear wheels (4
WD model).
Battery
Voltage (V)12
Cold-cranking performance (Amp)600
Reserve capacity (Min.)125
BCI group no.24

246 Owner Assistance
Your satisfaction and goodwill are
important to your Honda dealer
and to us, American Honda Motor
Co., Inc. Honda dealership
personnel are trained
professionals. They should be
able to answer all your questions.
If you encounter a problem that
your dealership does not solve to
your satisfaction, please discuss it
with the dealership’s
management. The Service
Manager or General Manager can
help. Almost all problems are
solved in this way.
If you are dissatisfied with the
decision made by the dealership’s
management, contact your Honda
Consumer Affairs Department.
American Honda Motor Co., Inc.
Honda Consumer Affairs Dept.
1919 Torrance Boulevard
Mail Stop 500-2C-7D
Torrance, California 90501-2746
(800) 999-1009 When you call or write, please
give us this information:
1.
Your name, address and
telephone number
2. Vehicle Identification Number
(see page 232)
3. The name and address of the dealer who services your
vehicle
4. Date of purchase
5. Mileage on your vehicle
6. Name and address of the dealer who sold you the
vehicle
7. A detailed description of the problem
Customer Relations Information

251Owner Assistance
Treadwear
The treadwear grade is a
comparative rating based on the
wear rate of the tire when tested
under controlled conditions on a
specified government test course.
For example, a tire graded 150
would wear one-and-a-half
(1-1/2) times as well on the
government course as a tire
graded 100. The relative
performance of tires depends
upon the actual conditions of their
use, however, and may depart
significantly from the norm due to
variation in driving habits, service
practices and differences in road
characteristics and climate.
Traction – AA, A, B, C
The traction grades from highest
to lowest are AA, A, B, and C.
Those grades represent the tire’sability to stop on wet pavement as
measured under controlled
conditions on specified
government test surfaces of
asphalt and concrete. A tire
marked C may have poor traction
performance.
Warning: The traction grade
assigned to this tire is based on
straight-ahead braking traction
tests, and does not include
acceleration, cornering,
hydroplaning, or peak traction
characteristics.
Temperature – A, B, C
The temperature grades are A (the
highest), B and C, representing
the tire’
s resistance to the
generation of heat and its ability
to dissipate heat when tested
under controlled conditions on a specified indoor laboratory test
wheel. Sustained high temperature
can cause the material of the tire
to degenerate and reduce tire life
and excessive temperature can
lead to sudden tire failure. The
grade C corresponds to a level of
performance which all vehicle
tires must meet under the Federal
Motor Vehicle Safety Standard
No. 109. Grades B and A
represent higher levels of
performance on the laboratory test
wheel than the minimum required
by law.
Warning: The temperature grade
for this tire is established for a tire
that is properly inflated and not
overloaded. Excessive speed,
underinflation, or excessive
loading either separately or in
combination, can cause heat
build-up and possible tire failure.

253
Purchasing Factory-Authorized Manuals
The following publications covering the operation and
servicing of your vehicle can be obtained from Helm
Incorporated, either by filling out the form or, for
credit card holders, by calling toll free. For manuals
prior to the year shown below, contact Helm
Incorporated, P.O. Box 07280, Detroit, MI 48207 or
call 1-800-782-4356.
Publication
Form
NumberForm DescriptionPrice
Each *
61S3L082002 Passport Service Manual$68.00
61S3L092002 Passport Fuel & Emissions
Supplement$35.00
61S3L08EL2000–02 Passport Electrical
Troubleshooting Manual$48.00
31S3L6402002 Passport Owner’s Manual**$34.00
HON-ROrder form for previous years –
Indicate year and model desired.FREE
* Prices are subject to change without notice and without incurring obligation.
**Includes Off-Road Driving Information
ORDER TOLL FREE: 1-800-782-4356
(NOTE: For Credit Card Holder Orders Only)
Monday – Friday 8:00 a.m. – 6:00 p.m. EST
MINIMUM CREDIT CARD PURCHASE $10.00
OR
By completing this form you can order the materials
desired. You can pay by check or money order or charge
to your credit card. Mail to Helm, Incorporated at the
address shown on the back of the order form.
PUBLICATION FORMVEHICLE MODELQTYPRICETOTALPUBLICATION FORMNUMBERNAMEYEARQTY.PRICE EACH*TOTALPRICE
*Prices are subject to change withoutTOTAL MATERIAL*Prices are subject to change without
notice and without incurring obligation.
O d il d ithi 10 d
MICH. PURCHASES ADD
6% SALES TAX
Orders are mailed within 10 days.Pleaseallow adequate time for delivery.HANDLING CHARGE$6.00Please allow adequate time for delivery.GRAND TOTAL
Authorized Manuals

254Service Manual
This manual covers maintenance and recommended
procedures for repair to engine and chassis
components. It is written for the journeyman
mechanic, but is simple enough for most mechanically
inclined owners to understand.
Electrical Troubleshooting Manual
This manual complements the Service Manual by
providing in-depth troubleshooting information for
each electrical circuit in your car.
NOTE: Dealers and Companies please provide dealer or company name and also th\
e name of the
person to whose attention the shipment should be sent. For purchases out\
side U.S.A. please write to
the address below for quotation.
(CUSTOMER NAME)
(ATTENTION)
(CITY) (STREET ADDRESS – NO P.O. BOX NUMBERS)
(APT. NO.)
(STATE) (ZIP CODE)
DAYTIME TELEPHONE NO. AREA
CODE
()
Check or money order enclosed payable to Helm, Inc.
MasterCardVISACheck here if your billing address is different
from the shipping address shown above.
Account
Number
Expiration Mo-Yr
(CUSTOMER SIGNATURE) (DATE)
These publications cannot be returned for credit without receiving advan\
ce authorization within 14 days of
delivery. On returns, a restocking fee may be applied against the original order\
.
P.O. BOX 07280 •DETROIT, MI 48207 •1-800-782-4356
(U.S. funds only – do not send cash.)