2002 HONDA INSIGHT check transmission fluid

If Honda MTF is not available, you
may use an API service SG, SH or SJ
grade motor oil with a viscosity of
SAE 10W-30 or 10W-40 as a
temporary replacement. An SG
grade is pref erred, but an SH or SJ
grade may be used if SG is not
available. However, motor oil does
not contain the proper additives and
continued use can cause stif f er
shif ting. Replace as soon as it is
convenient.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
Check the f luid level with the
transmission at normal operating
temperature and the car sitting on
the level ground.
Remove the black cover under the
engine. Remove the transmission f iller bolt
and caref ully f eel inside the bolt hole
with your f inger. The f luid level
should be up to the edge of the bolt
hole. If it is not, add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Reinstall
the f iller bolt and tighten it securely.
Maint enance
T ransmission Fluid
5-speed Manual Transmission
178

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. However, the use of
any non-Honda brake fluid can cause
corrosion and decrease the lif e of the
system. Have the brake system
f lushed and ref illed with Honda
Heavy Duty Brake Fluid DOT 3 as
soon as possible.
Brake f luid marked DOT 5 is not
compatible with your car’s braking
system and can cause extensive
damage.
Check the f luid level in the reser-
voirs monthly. There are up to two
reservoirs, depending on the model.
They are:
The brake f luid should be replaced
accordingtothetimeanddistance
recommendations in the mainte-
nance schedule.
Brake f luid reservoir (all models)
Clutch f luid reservoir
(manual transmission only)
Maint enance
Brake and Clutch Fluid
Brake System
179
M M
A
AX
X
M
M I
INN

CONT INUED
...
Accessories and Modif ications . 126
................................
Accessories .126
...
Additional Safety Precaution . 127
............................
Modif ications .127
ACCESSORY (Ignition Key .......................................
Position) .70
...............
Accessory Power Socket . 81
....................
Additives, Engine Oil . 166
...............................
Airbag (SRS) .9, 47
................
Air Conditioning System . 90
..............................
Maintenance .188
............................................
Usage .90
.........................
Air Outlets (Vents) .90
.......................
Air Pressure, Tires .190
.........................
Normal Driving .191
.......................
Alcohol in Gasoline .246
......................................
Antif reeze .169
Anti-thef t Steering Column ..............................................
Lock .69
..........................
Appearance Care .205
..................................
Audio System .98
........................
Auto Idle Stop .135, 143
..............
Automatic Transmission . 138
..........................
Capacity, Fluid .242 ...............
Checking Fluid Level . 176
.......................................
Shif ting .138
.
Shif t Lever Position Indicator . 138
................
Shif t Lever Positions . 138
....................
Shif t Lock Release . 142
Battery Charging System ...........................
Indicator .56, 227
............................
Jump Starting .223
..............................
Maintenance .183
............................
Specif ications .243
..............................
Bef ore Driving .117
..........................................
Belts, Seat .8
.............................
Beverage Holder .80
.................................
Body Repairs .211
Brakes .............
Break-in, New Linings . 118
...........................................
Fluid .179
....................
Bulb Replacement .201
.........................................
Parking .79
.................
System Indicator . 46,230
........................
Wear Indicators .146
.............................
Braking System .147 ........................
Break-in, New Car .118
..
Brightness Control, Instruments . 62
........................
Brights, Headlights .61
Bulb Replacement ..........................
Back-up Lights .201
...............................
Brake Light .201
................
Front Parking Lights . 199
........
Front Side Marker Lights . 199
.................................
Headlights .198
.............................
Interior Light .203
.................
License Plate Lights . 202
............................
Specif ications .243
....................
Turn Signal Lights . 199
..............................
Bulbs, Halogen .198
............................
Capacities Chart .242
.............
Carbon Monoxide Hazard . 40
.............................
Carrying Cargo .128
Cassette Player ............................................
Care .115
...................................
Operation .104
..............
CAUTION, Explanation of . ii
Index
A
B
C
I

Î.......................................
CD Player .108
........................
Certif ication Label .240
............................................
Chains .195
....................
Charge/Assist Gauge .57
Changing Oil ........................................
How to .167
......................................
When to .156
....................
Changing a Flat Tire .215
............
Changing Engine Coolant . 171
............
Charging System Indicator . 56
............
Checklist, Bef ore Driving . 117
.....................................
Child Saf ety .19
Child Seats ..........
Tether Anchorage Points . 33
....................
Cleaner Element, Air . 181
Cleaning ......................................
Exterior .206
.......................................
Interior .209
...................................
Seat Belts .209
...........................................
Vinyl .209
....................................
Windows .210
.........................
Clock, Setting the .103
...................................
Clutch Fluid .179
........................
CO in the Exhaust .248
............
Cold Weather, Starting in . 133
..............................
Compact Spare .214 ...............
Consumer Inf ormation . 254
.............
Controls, Instruments and . 60
Coolant ........................................
Adding .169
....................................
Checking .123
.........................
Proper Solution .173
...................................
Replacing .171
...................
Temperature Gauge . 58
....................
Corrosion Protection .210
Crankcase Emissions Control ........................................
System .248
.....................
Current Fuel Mileage .55
..........
Customer Relations Of f ice . 254
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 44
................
Daytime Running Lights . 62
............
Defects, Reporting Safety . 258
..........................
Def og and Def rost .84
................
Def ogger, Rear Window . 65
................
Defrosting the Windows . 84
....................................
Dimensions .242
...............
Dimming the Headlights . 61Dipstick
..................................
Engine Oil .122
..........................
Directional Signals .63
........
Disc Brake Wear Indicators . 146
.....................
Disposal of Used Oil .168
..................
Display Change Button . 50
Doors ..............
Locking and Unlocking . 71
..........
DOT Tire Quality Grading . 244
Downshif ting, 5-speed Manual .............................
Transmission .134
.....................................
Drive Belts .189
...........
Driver and Passenger Safety . 5
...........................................
Driving .131
....................................
Economy .124
.........................
In Bad Weather .149
................
In Foreign Countries . 247
..................
DustandPollenFilter . 189
..............................
Economy, Fuel .124
............
Emergencies on the Road . 213
.............
Battery, Jump Starting . 222
...........
Brake System Indicator . 230
................
Changing a Flat Tire . 215
Index
D
E
II

CONT INUED
.....
Charging System Indicator . 227
..................
Checking the Fuses . 232
.....
Low Oil Pressure Indicator . 226
...
Malf unction Indicator Lamp . 228
..................
Overheated Engine . 224
...........................
Emergency Brake .79
......................
Emergency Flashers .65
......................
Emergency Towing .237
.......................
Emissions Controls .248
Engine ............................................
Belts .189
....
Coolant Temperature Gauge . 58
Malf unction Indicator ................................
Lamp .48, 228
..............
Oil, What Kind to Use . 165
...............................
Overheating .224
............................
Specif ications .242
.......................................
Starting .133
..........
Engine Speed Limiter . 137,141
......................
Ethanol in Gasoline .246
.
Evaporative Emissions Controls . 248
...............................
Exhaust Fumes .40
Expectant Mothers, Use of Seat ........................................
Belts by .17
..................
Exterior, Cleaning the . 206 ...............
Gas Mileage, Improving . 124
..........................................
Gasohol .246
.........................................
Gasoline .118
...............
Fuel Reserve Indicator . 48
...........................................
Gauge .50
................
Octane Requirement . 118
........................
Tank, Filling the .119
................
Gas Station Procedures . 119
............................
Fabric, Cleaning .209
.....................................
Fan, Interior .84
Features, Comfort and ................................
Convenience .83
....................
Filling the Fuel Tank . 119
Filter .........................
Dust and Pollen .189
...............................................
Oil .165
5-speed Manual Transmission ...............
Checking Fluid Level . 178
................................
Shif ting the .134
.............
Flashers, Hazard Warning . 65
...................
Flat Tire, Changing a . 215
Fluids Automatic Transmission .....................................
(CVT) .176
..........................................
Brake .179
.........................................
Clutch .180
..............
Manual Transmission . 178
..................
Windshield Washer . 175
FM Stereo Radio ...................................
Reception .112
.....
Foreign Countries, Driving in . 247
..........................
Four-way Flashers .65 .................................................
Fuel .124
......................
Fill Door and Cap .119
...........................................
Gauge .58
................
Octane Requirement . 118
...............................
Oxygenated .246
........................
Reserve Indicator .58
........................
Tank, Filling the .119
.....................
Fuses, Checking the .232
Index
F
G
III

CONT INUED
.....................................
Load Limit .129
......
LOCK (Ignition Key Position) . 69
Locks ............................
Fuel Fill Door .119
............................................
Hatch .71
........................
Low Coolant Level .123
.........................
Low Fuel Indicator .58
...
Lower Gear, Downshif ting to a . 137
...
Lubricant Specif ications Chart . 243
.........................................
Luggage .128
..................................
Maintenance .151
...
Owner Maintenance Checks . 163
........................................
Record .161
......................
Required Indicator .59
..........................................
Saf ety .152
....................................
Schedule .154
.
Malf unction Indicator Lamp . 48,228
...................
Manual Transmission . 134
........
Manual Transmission Fluid . 178
...............................
Meters, Gauges .50
...................
Methanol in Gasoline . 246
..........................
Mirrors, Adjusting .78 ..................
New Vehicle Break-in . 118
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 240
...
Octane Requirement, Gasoline . 118
.........................................
Odometer .50
...............................
Odometer, Trip .51
Oil ........................
Change, How to .167
......................
Change, When to .156
......................
Checking Engine .122
Selecting Proper Viscosity ......................................
Chart .166
...........
ON (Ignition Key Position) . 70
Onboard Ref ueling Vapor ....................................
Recovery .248
.........................
Opening the Hatch .71
..
Operation in Foreign Countries . 247
..............................
Outside Mirrors .78
....................
Overheating, Engine .224
.......
Owner Maintenance Checks . 163
.........................
Oxygenated Fuels .246 ..............................
Paint Touch-up .208
..............
Panel Brightness Control . 62
...........................................
Parking .145
.................................
Parking Brake .79
Parking Brake and Brake .................
System Indicator . 46,230
..
Parking Over Things that Burn . 250
.............................
PGM-FI System .249
..................
Polishing and Waxing . 208
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 17
............................
Protecting Adults .12
...
Additional Safety Precautions . 18
.....
Advice f or Pregnant Women . 17
........................
Protecting Children .19
.......
Protecting Larger Children . 29
.........
Protecting Small Children . 26
Using Child Seats with .....................................
Tethers .33
Index
M N
O
P
V

CONT INUED
........
Steam Coming f rom Engine . 224
Steering Wheel .............
Anti-theft Column Lock . 69
.....................
Stereo Sound System .98
...........................
Storing Your Car .204
Supplemental Restraint ..................................
System .9,36
......................................
Servicing .39
.........................
SRS Indicator .34 ,46
...................
System Components . 36
..................................
Synthetic Oil .166
.....................................
Tachometer .58
......
Taillights, Changing Bulbs in . 201
Taking Care of the ...............................
Unexpected .213
....................................
Tape Player .104
Technical Descriptions ......
DOT Tire Quality Grading . 244
.....
Emissions Control Systems . 248
.....................
Oxygenated Fuels .246
Three Way Catalytic ...............................
Converter .250
.......................
Temperature Gauge .58 ..............
Tether Anchorage Points . 33
..
Three Way Catalytic Converter . 250
..........................
Time, Setting the .103
....................................
Tire Chains .195
.........
Tire, How to Change a Flat . 193
...............................................
Tires .190
..............................
Air Pressure .191
.........................
Checking Wear .192
..........................
Compact Spare .214
......
DOT Tire Quality Grading . 244
......................................
Inf lation .190
..................................
Inspection .192
...................................
Replacing .193
......................................
Rotating .193
...........................................
Snow .195
............................
Specif ications .243
................................
Tire Chains .195
...................
Tools, Tire Changing . 215
Towing .....................................
A Trailer .150
................
Emergency Wrecker . 236
Transmission Checking Fluid Level, ..................
Automatic (CVT) . 176
Checking Fluid Level, ...................................
Manual .178 ...........................
Fluid Selection .178
..............
Identif ication Number . 241
..................
Shif ting the Manual . 134
.....................................
Treadwear .244
.....................................
Trip Meters .53
....................................
Trip Mileage .54
....................................
Turn Signals .63
.....................
Underside, Cleaning .206
Unexpected, Taking Care ..........................................
of the .213
....
Unif orm Tire Quality Grading . 244
........................
Unleaded Gasoline .118
.....................
Upholstery Cleaning .209
.......
Used Oil, How to Dispose of . 168
.................
Vehicle Capacity Load . 129
......................
Vehicle Dimensions .242
....
Vehicle Identif ication Number . 240
.............................
Vehicle Storage .204
Index
T U
V
VII