2002 HONDA CIVIC service

µ
The treadwear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specif ied government
test course. For example, a tire
graded 150 would wear one and one-
half (1 1/2) times as well on the
government course as a tire graded
100. The relative perf ormance of
tires depends upon the actual condi-
tions of their use, however, and may
depart signif icantly f rom the norm
due to variations in driving habits,
service practices and dif f erences in
road characteristics and climate. The traction grades, f rom highest to
lowest, are AA, A, B, and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on
specif ied government test surf aces
of asphalt and concrete. A tire
marked C may have poor traction
perf ormance.
The tires on your car meet all U.S.
Federal Saf ety Requirements. All
tires are also graded for treadwear,
traction, and temperature perform-
ance according to Department of
Transportation (DOT) standards.
The f ollowing explains these
gradings.
All passenger car tires must conf orm
to Federal Saf ety Requirements in
addition to these grades.
Quality grades can be f ound where
applicable on the tire sidewall
between the tread shoulder and the
maximum section width. For
example:
Warning: The traction grade
assignedtothistireisbasedon
straight-ahead braking traction tests,
and does not include acceleration,
cornering, hydroplaning, or peak
traction characteristics.
DOT T ire Quality Grading (U.S. Cars)
T echnical Inf ormation
Treadwear Traction AA, A, B, C
T readwear 200
Traction AA
Temperature A
Unif orm T ire Quality Grading
298

Some conventional gasolines are
being blended with alcohol or an
ether compound. These gasolines
are collectively ref erred to as
oxygenated f uels. To meet clean air
standards, some areas of the United
States and Canada use oxygenated
f uels to help reduce emissions.
If you use an oxygenated f uel, be
sure it is unleaded and meets the
minimum octane rating requirement.
Bef ore using an oxygenated f uel, try
to conf irm the f uel’s contents. Some
states/provinces require this
informationtobepostedonthepump.If you notice any undesirable
operating symptoms, try another
service station or switch to another
brand of gasoline.
Fuel system damage or perf ormance
problems resulting f rom the use of
an oxygenated f uel containing more
than the percentages of oxygenates
given above are not covered under
warranty.
(ethyl or grain alcohol)
You may use gasoline containing up
to 10 percent ethanol by volume.
Gasoline containing ethanol may be
marketed under the name ‘‘Gasohol.’’
The f ollowing are the U.S. EPA and
Canadian CGSB approved
percentages of oxygenates:
(Methyl Tertiary Butyl
Ether)
You may use gasoline containing up
to 15 percent MTBE by volume.
(methyl or wood
alcohol)
Your vehicle was not designed to use
fuel that contains methanol.
Methanol can corrode metal parts in
the fuel system, and also damage
plastic and rubber components. This
damage would not be covered by
your warranties.
T echnical Inf ormation
Oxygenated Fuels
ET HA NOL
MT BE
MET HA NOL
300

When you call or write, please give
us this inf ormation:
Honda dealership personnel are
trained prof essionals. They should
be able to answer all your questions.
If you encounter a problem that your
dealership does not solve to your
satisf action, please discuss it with
the dealership’s management. The
Service Manager or General
Manager can help. Almost all
problems are solved in this way. Vehicle Identif ication Number
(see page )
Name and address of the dealer
who services your car
Date of purchase
Mileage on your car
Your name, address, and tele-
phone number
A detailed description of the
problem
Name of the dealer who sold the
car to you
If you are dissatisf ied with the
decision made by the dealership’s
management, contact your Honda
Customer Relations Of f ice.
U.S. Owners: Canadian Owners:
In Puerto Rico and the U.S. Virgin
Islands:
294
Warrant y and Cust omer Relat ions
Cust omer Relat ions Inf ormat ion
308
CUSTOMER RELATIONS
RELATIONS AVEC LA CLIENTÈLE
Honda Canada Inc.
715 Milner Avenue
Toronto, ON
M1B 2K8
Tel: 1-888-9-HONDA-9
Fax: Toll-free 1-877-939-0909 Toronto (416) 287-4776
Bella International
P.O. Box 190816
San Juan, Puerto Rico 00919-0816
Tel: (787) 250-4318
American Honda Motor Co.
Honda Consumer Affairs
Department
Mail Stop 500-2N-7D
1919 Torrance Boulevard
Torrance, California 90501-2746
Tel: (800) 999-1009

ÎÎ
Î
µ
µ µµ
Î   $#
The f ollowing publications covering the operation and
servicing of your vehicle can be obtained f rom Helm
Incorporated, either by f illing out the attached f orm or,
f or credit card holders, calling the toll-f ree phone number
on the f orm. For manuals prior to the year shown below,
contact Helm Incorporated, P.O. Box 07280, Detroit,
Michigan 48207, or call 1-800-782-4356.
Valid only f or sales within the U.S. Canadian owners should contact their authorized Honda dealer.
Authorized Manuals
Purchasing Factory Authorized Manuals
(U.S. only)
311
ORDER TOLL FREE: 1-800-782-4356
OR
(NOTE: For Credit Card Holder Orders Only)
MINIMUM CREDIT CARD PURCHASE $10.00
Publication
Form Number 61S5A03
61S5A03EL 61S5A30
31S5A610 HON-R Form Description
2001 2002 Honda Civic 2/4 Door Service Manual
2001 2002 Honda Civic 2/4 Door
Electrical Troubleshooting Manual 2001 2002 Honda Civic 2/4 Door
Body Repair Manual
2002 Honda Civic 4 Door Owner’s Manual
Order Form for Previous Years-
Indicate Year and Model Desired Price
Each
$68.00 $48.00$42.00$32.00
FREE
PUBLICATION NUMBER VEHICLE MODEL
Name Year Qty
Price
Each Total
Price
GRAND TOTAL
HANDLING CHARGE
Mich. Purchases
Add 6% Sales Tax
TOTAL MATERIAL
$6.00
Prices are subject to change without notice and without incurring
obligation. Monday-Friday 8:00 A.M. 6:00 P.M. EST
By completing this form you can order the materials desired. You can
pay by check or money order, or charge to your credit card. Mail to
Helm Incorporated at the address shown on the back of the order form.
Prices are subject to change without
notice and without incurring obligation.
Orders are mailed within 10 days. Please
allow adequate time for delivery.

µµ
µ
( % ) $
%."#)
This manual describes the procedures involved in the
replacement of damaged body parts.
This manual covers maintenance and recommended
procedures f or repair to engine and chassis components.
It is written f or the Journeyman mechanic, but is simple
enough f or most mechanically-inclined owners to under-
stand.
This manual complements the Service Manual by
providing in-depth troubleshooting inf ormation f or each
electrical circuit in your vehicle.
Authorized Manuals
Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
312 NOTE: Dealers and Companies please provide dealer or company name,
and also the name of the person to whose attention the shipment should
be sent. For purchases outside U.S.A. please write to the address shown
below for a quotation.
P.O. BOX 07280·DETROIT, MICHIGAN 48207·1-800-782-4356
Customer Name Attention
Apartment Number
State & Zip Code
City
Daytime Telephone Number
Check or money order enclosed payable to Helm Inc U.S. funds only.
Do not send cash
Master
Card VISA Check here if your billing address is different
from the shipping address shown above.
Account Number Expiration: Mo. Yr.
CUSTOMER SIGNATURE DATE
Street Address No P.O. Box Number
()
These Publications cannot be returned for credit without receiving advance authorization within 14
days of delivery. On returns, a restocking fee may be applied against the original order.

Î
CONT INUED
.....................................
Tachometer . 66
Taillights, Changing
..................................
Bulbs . 250, 251
.
Taking Care of the Unexpected . 265
...................
Tape Player . 120, 132, 153
...............................
Saf ety Messages . ii
.....................................
Seat Belts . 8, 45
...............
Additional Information . 45
Automatic Seat Belt
...............................
Tensioners . 46
.....................................
Cleaning . 261
................
Lap/Shoulder Belt . 16, 45
................................
Maintenance . 47
......
Reminder Light and Beeper . 61
...................
System Components . 45
...............
Use During Pregnancy . 20
...
Wearing a Lap/Shoulder Belt . 16
........................
Seats, Adjusting the . 88
...............................
Serial Number . 294
...........................
Service Intervals . 198
...........................
Service Manual . 311
.........
Service Station Procedures . 165
..........
Setting the Clock . 119, 131, 143
.....
Shif t Lever Position Indicator . 182
........................
Shif t Lock Release . 186
..............................
Side Airbags . 10, 50
...................
Cut-of f Indicator . 52, 61
Side Marker Lights, Bulb ......................
Replacement . 248, 250
...............................
Signaling Turns . 72
.....................................
Snow Tires . 243 ...................
Solvent-type Cleaners . 258
................
Sound System . 114, 126, 138
Spare Tire
......................................
Inf lating . 266
............................
Specif ications . 297
................
Spark Plugs, Replacing . 227
....................
Specif ications Charts . 296
................................
Speed Control . 159
...................................
Speedometer . 66
.......................................
Spotlights . 103
..........
SRS, Additional Inf ormation . 48
...
Additional Safety Precautions . 53
.............................
Airbag Service . 53
How the Side Airbag Cut-of f
...........
Indicator Light Works . 52
How the SRS Indicator .......................................
Works . 51
How Your Front Airbags .........................................
Work . 48
...
How Your Side Airbags Work . 50
........................
SRS Components . 48
.............................
SRS Indicator . 51, 61
....
START (Ignition Key Position) . 81
..............
State Emissions Testing . 305 .......................
Starting the Engine . 179
In Cold Weather at High ..................................
Altitude . 179
................
With a Dead Battery . 274
........
Steam Coming f rom Engine . 276
Steering Wheel
..................................
Adjustment . 76
.............
Anti-theft Column Lock . 80
...
Stereo Sound System . 114, 126, 138
...........................
Storing Your Car . 256
Supplemental Restraint
................................
System . 10, 48
......................................
Servicing . 53
.........................
SRS Indicator . 51, 61
...................
System Components . 48
..................................
Synthetic Oil . 210
Index
T
VII

Service Inf ormat ion Summary
Gasoline:
Fuel Tank Capacity:
Recommended Engine Oil:Tire Pressure (measured cold):
Brake Fluid:
5-speed Manual Transmission Fluid:
Automatic Transmission Fluid:
Power Steering Fluid:
Unleaded gasoline, pump octane
number of 86 or higher.
13.2 US gal (50
, 11.0 Imp gal)
30 psi (210 kPa , 2.1 kgf/cm
)
Honda Heavy Duty Brake Fluid
DOT 3 preferred, or a DOT 3 or
DOT 4 brake fluid as a temporary
replacement (see page ).
Front/Rear:
Spare Tire:
60 psi (420 kPa , 4.2 kgf/cm
)
API Premium grade 5W-20
detergent oil (see page ).
Oil change capacity (including
filter):
3.4 US qt (3.2
, 2.8 Imp qt)
3.7 US qt (3.5
, 3.1 Imp qt) Honda ATF-Z1 (Automatic
Transmission Fluid) preferred, or
aDEXRON
III ATF as a
temporary replacement (see page ).
Honda Manual Transmission
Fluid preferred, or an API service
SG, SH or SJ, SAE 10W-30 or
10W-40 motor oil as a temporary
replacement (see page ).
Capacity (including differential): 1.6 US qt (1.5
, 1.3 Imp qt)
Honda Power Steering Fluid
preferred, or another brand of
power steering fluid as a
temporary replacement. Do not
use ATF (see page ).
DX, LX EX 220
221
224 222
209