2002 HONDA ACCORD COUPE cooling

Fill the radiator with coolant up to
the base of the f iller neck.
Fill the reserve tank to the MAX
mark. Install the reserve tank cap.
Install the radiator cap, and
tighten it to the first stop.Start the engine and let it run until
the radiator cooling f an comes on
at least twice. Then stop the
engine.
Remove the radiator cap. Pour
coolant into the radiator up to the
base of the f iller neck and into the
reserve tank up to the MAX mark.
Start the engine and hold it at
1,500 rpm until the radiator f an
comes on. Turn of f the engine.
Check the coolant level in the
radiator and add coolant if needed.
Install the radiator cap, and
tighten it fully.
If necessary, f ill the reserve tank
to the MAX mark. Install the
reserve tank cap.
Start the engine and let it run f or
about 30 seconds. Then turn of f
the engine.
9.
10. 11. 12.
13.
14.
15.
16.
8.
Cooling Syst em
Maint enance259
4 4-
-c
cy yl liinn d
de
err m
m o
od
de
ellss F
Fiillll u
u p
p t
too h
he
erree
F
FI
ILLL LEE R
R N
NEEC
CK K F
FIILLL LEE R
R N
NEEC
CK K
6
6- -c
cy yl liinn d
de
err m
m o
od
de
ellss
F
Fiillll u
u p
p t
too h
he
erree

Run the air conditioning at least once
a week during the cold weather
months. Run it f or at least ten
minutes while you are driving at a
steady speed with the engine at
normal operating temperature. This
circulates the lubricating oil con-
tained in the ref rigerant.If the air conditioning does not get as
cold as before, have your dealer
check the system. Recharge the
system with Ref rigerant HFC-134a
(R-134a). (See Specif ications on
pages and .)
Your car’s air conditioning is a sealed
system. Any major maintenance,
such as recharging, should be done
by a qualif ied mechanic. You can do
a couple of things to make sure the
air conditioning works ef f iciently.
Periodically check the engine’s
radiator and air conditioning
condenser f or leaves, insects, and
dirt stuck to the f ront surf ace. These
block the air f low and reduce cooling
ef f iciency. Use a light spray f rom a
hose or a sof t brush to remove them. 344 346
Maint enance
A ir Condit ioning Syst em
279
A A
I
IRR C
COON NDDI
ITT I
IOON NIINNG G
C
CO ON NDDE
EN
NS SEER
R
Whenever you have the air conditioning
system serviced, make sure the service
f acility uses a ref rigerant recycling
system. This system captures the
ref rigerant f or reuse. Releasing
ref rigerant into the atmosphere can
damage the environment.
The condenser and radiator f ins bend
easily. Only use a low-pressure spray
or sof t-bristle brush to clean them.

Check the condition of the drive
belts (two on 4-cylinder models, one
on 6-cylinder models). Examine the
edges of each belt for cracks or
f raying.Check the tension of each belt by
pushingonitwithyourthumb
midway between the pulleys.
The dust and pollen f ilter removes
pollen and dust that is brought in
f rom the outside through the heating
and cooling system/climate control
system.
This f ilter should be replaced every
30,000 miles (48,000 km) under
normal conditions. It should be
replaced every 15,000 miles (24,000
km) if you drive primarily in urban
areas that have high concentrations
of soot in the air f rom industry and
diesel-powered vehicles. Replace it
more of ten if air f low f rom the
heating and cooling system/climate
control system becomes less than
usual. Have the dust and pollen f ilter
replaced by your Honda dealer. Drive Belts
Dust and Pollen Filter
Maint enance
Dust and Pollen Filter, Drive Belts
280
4 4- -c
cy yl liinn d
de
err m
m o
od
de
ellss 6
6-
-c
cy yl liinn d
de
err m
m o
od
de
ellss
A
A
L
LTT E
ER
RN NA AT
TO
OR R B
BEEL
LTT
P
P O
OW WE ER
R S
STTE
EE
ER
RI INNG G
B
BE EL
LTT P
P
O
OW WE ER
R S
STTE
EE
ER
RI INNG G B
BEEL
LTT

If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Saf ely pull to the side of the road.
Put the transmission in Neutral or
Park and set the parking brake.
Turn of f the heating and cooling/
climate control system and all
otheraccessories.Turnonthe
hazard warning indicators.
The pointer of your car’s tempera-
ture gauge should stay in the mid-
range under most conditions. It may
go higher if you are driving up a long
steep hill on a very hot day. If it
climbs to the red mark, you should
determine the reason. Your car can overheat f or several
reasons, such as lack of coolant or a
mechanical problem. The only
indication may be the temperature
gauge climbing to or above the red
mark. Or you may see steam or
spray coming f rom under the hood.
In either case, you should take
immediate action. 1.
2.
If Your Engine Overheats
T aking Care of t he Unexpect ed324
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.
Driving with the temperature gauge
pointer at the red mark can cause
serious damage to your engine.

Using gloves or a large heavy
cloth, turn the radiator cap
counterclockwise, without pushing
down, to the f irst stop. This
releases any remaining pressure in
the cooling system. After the
pressure releases, push down on
the cap and turn it until it comes
off.Start the engine and set the
temperature control dial to
maximum (climate control to
FULL AUTO at 90°F/32°C). Add
coolant to the radiator up to the
base of the f iller neck. If you do
not have the proper coolant
mixture available, you can add
plain water. Remember to have
the cooling system drained and
ref illed with the proper mixture as
soon as you can.Put the radiator cap back on
tightly. Run the engine and watch
the temperature gauge. If it goes
back to the red mark, the engine
needs repair. (See
on page .)
If the temperature stays normal,
check the coolant level in the
radiator reserve tank. If it has
gone down, add coolant to the
MAX mark. Put the cap back on
tightly.
9.
11.
12.
10.
338
T aking Care of t he Unexpect ed
If Your Engine Overheats
Emergency
Towing
326

ÎÎ
Î
Î
Î
Î Î
Î
µ
µ
µ
Î Î
Î
Î
Î
à à
á
á No. Amps. Circuits Protected
No. Amps. Circuits Protected1
2
3
4
5
6
7
8
9
10
11
12
13 15 A
10 A
7.5 A
7.5 A
7.5 A 15 A
7.5 A
7.5 A
7.5 A
7.5 A 15 A
30 A
7.5 A Fuel Pump
SRS
Heater Control, A/C Clutch
Relay, Cooling Fan Relay
Power Mirror
Daytime Running Light
ECU (ECM/PCM), Cruise
Control
SRS, Moonroof
ACC Relay
Back-up Lights, Meter
Lights
Turn Signals
IG Coil
Wiper
Starter Signal 1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16 30 A
20 A
20 A
10 A
20 A
20 A
20 A
20 A
15 A
7.5 A
20 A
7.5 A
7.5 A 20 A Moonroof
Power Seat
Not Used
Power Seat
Not Used
Daytime Running Light
LAF Heater
Moonroof Relay
Passenger’s Power Window
Radio, ACC Socket
Small Light, License Light
Interior Light, Courtesy
Lights
Power Door Locks
Clock, Back Up
ABS Motor Check
Driver’s Power Window
Not Used
On Canadian models
Special Edition, EX, EX-V6
Canadian Special Edition, U.S. LX-V6, and
EX, EX-V6
Canadian models
U.S. models except LX
1:
2:
3:
4:1
2
2
3
4 1
2
Fuses
T aking Care of t he Unexpect ed336
Driver’s Side INTERIOR FUSE BOX Passenger’s Side
F Frroo n
nt
t
F
Fr roo n
nt
t
:

Î
Î
Î Î
Î
Î
Î
Î
Î
No. Amps. Circuits Protected No. Amps. Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 20 A
7.5 A 20 A
20 A
20 A
15 A
30 A
15 A
20 A
30 A
100 A 20 A
40 A Lef t Headlight
Dimmer Relay
Right Headlight
ABS F/S
Stop
ACG
ABS Motor
Hazard
Spare Fuse
Spare Fuse
Battery
Cooling Fan
Back Up, ACC 14
15
16
17
18
19
20
21
22
23
24
40 A
40 A
20 A
40 A
40 A
7.5 A 10 A
15 A
20 A
20 A
50 A Power Window Motor
Power Seat
TCS F/S
Heater Motor
Rear Defroster
Spare Fuse
Spare Fuse
Spare Fuse
Heated Seat
Condenser Fan
IG1 Main
1:
2:
3:
4: EX-V6 in Canada
EX,V6models
V6 models
Canadian Special Edition, EX, and EX-V6
models1
2
2 3
4
Fuses
T aking Care of t he Unexpect ed337
UNDER-HOOD FUSE BOX

Fluids.........................................
Clutch .265
..............
Manual Transmission . 263
..........................
Power Steering .266
................
Windshield Washers . 260
FM Stereo Radio ...........................
Reception .124, 139
...........................
Folding Rear Seat .91
.....
Foreign Countries, Driving in . 351
..........................
Four-way Flashers .71
..............................
Front Airbags .9 ,45
.................................................
Fuel .192
......................
Fill Door and Cap .193
...........................................
Gauge .64
................
Octane Requirement . 192
...............................
Oxygenated .350
........................
Reserve Indicator .62
........................
Tank, Filling the .193
.....................
Fuses, Checking the .333
...............
Gas Mileage, Improving . 199
..........................................
Gasohol .350
.........................................
Gasoline .192
...............
Fuel Reserve Indicator . 62...........................................
Gauge .64
................
Octane Requirement . 192
........................
Tank, Filling the .193
................
Gas Station Procedures . 193
Gauges ...
Engine Coolant Temperature . 64
...............................................
Fuel .64
...............................
Speedometer .63
.................................
Tachometer .63
GAWR (Gross Axle Weight ......................................
Rating) .226
Gearshif t Lever Positions ..........
Automatic Transmission . 211
5-speed Manual .........................
Transmission .209
..............................
Glass Cleaning .308
........................................
Glove Box .84
GVWR (Gross Vehicle Weight ......................................
Rating) .226
.............
Halogen Headlight Bulbs . 290
..............
Hazard Warning Flashers . 71
........................................
Headlights .67
........................................
Aiming .290 Automatic Lighting Off
.....................................
Feature .68
............
Daytime Running Lights . 68
..................
High Beam Indicator . 62
....................
Lights On Indicator .62
.........................
Reminder Chime .67
........
Replacing Halogen Bulbs . 290
...................................
Turning on .67
..............................
Head Restraints .90
.....................
Heating and Cooling .108
.............
High Altitude, Starting at . 208
.................
High-Low Beam Switch . 67
HomeLink Universal ................................
Transceiver .185
....................................
Hood Latch .269
.......................
Hood, Opening the .194
..................................................
Horn .66
...........................
Hydraulic Clutch .265
.................................
Hydroplaning .224
...
Identif ication Number, Vehicle . 342
Ignition ..............................................
Keys .75
...........................................
Switch .76
Index
GHI
IV